Quadra-Fire QVI-25FB Installer's Manual
Hide thumbs Also See for QVI-25FB:

Advertisement

Quick Links

Model:
QVI-25FB
READ THIS MANUAL BEFORE INSTALLING OR
OPERATING THIS APPLIANCE. THIS INSTALLERS
GUIDE MUST BE LEFT WITH APPLIANCE FOR
FUTURE REFERENCE.
WARNING: IF THE INFORMATION
IN THESE INSTRUCTIONS IS NOT
FOLLOWED EXACTLY, A FIRE OR
EXPLOSION MAY RESULT CAUS-
ING PROPERTY DAMAGE, PER-
SONAL INJURY, OR DEATH.
- Do not store or use gasoline or other flam-
mable vapors and liquids in the vicinity of this
or any other appliance.
-
What to do if you smell gas
• Do not try to light any appliance.
• Do not touch any electrical switch.
• Do not use any phone in your building.
• Immediately call your gas supplier from a
neighbor's phone. Follow the gas supplier's
instructions.
• If you cannot reach your gas supplier, call
the fire department.
- Installation and service must be performed by a
qualified installer, service agency, or the gas
supplier.
Printed in U.S.A. Copyright 2007
Quadra-Fire,
a brand of Hearth & Home Technologies
1445 North Highway, Colville, WA 99114
This product may be covered by one or more of the following patents: (United States) 4593510, 4686807, 4766876, 4793322, 4811534, 5000162, 5016609, 5076254, 5113843, 5191877, 5218953,
5263471, 5328356, 5341794, 5347983, 5429495, 5452708, 5542407, 5601073, 5613487, 5647340, 5688568, 5762062, 5775408, 5890485, 5931661, 5941237, 5947112, 5996575, 6006743, 6019099,
6048195, 6053165, 6145502, 6170481, 6237588, 6296474, 6374822, 6413079, 6439226, 6484712, 6543698, 6550687, 6601579, 6672860, 6688302B2, 6715724B2, 6729551, 6736133, 6748940,
6748942, D320652, D445174, D462436; (Canada) 1297749, 2195264, 2225408; or other U.S. and foreign patents pending.
Quadra-Fire • QVI-25FB • 2031-900 Rev. F • 9/07
WARNING: IMPROPER INSTALLA-
TION, ADJUSTMENT, ALTERATION,
SERVICE OR MAINTENANCE CAN
CAUSE INJURY OR PROPERTY DAM-
AGE. REFER TO THIS MANUAL. FOR
ASSISTANCE OR ADDITIONAL INFOR-
MATION CONSULT A QUALIFIED IN-
STALLER, SERVICE AGENCY, OR THE
GAS SUPPLIER.
1. This appliance may be installed in an af-
termarket, permanently located, manufac-
tured (mobile) home, where not prohibited
by local codes.
2. This appliance is only for use with the type
of gas indicated on the rating plate. This
appliance is not convertible for use with
other gases, unless a certified kit is used.
In the Commonwealth of Massachusetts:
• installation must be performed by a licensed
plumber or gas fitter;
• a CO detector shall be installed in the room
where the appliance is installed.
Please contact your Quadra-Fire dealer with any
questions or concerns. For the number of your nearest
Quadra-Fire dealer, please visit www.quadrafire.com.
Installers Guide
Underwriters
Laboratories Listed
1

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the QVI-25FB and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for Quadra-Fire QVI-25FB

  • Page 1 6048195, 6053165, 6145502, 6170481, 6237588, 6296474, 6374822, 6413079, 6439226, 6484712, 6543698, 6550687, 6601579, 6672860, 6688302B2, 6715724B2, 6729551, 6736133, 6748940, 6748942, D320652, D445174, D462436; (Canada) 1297749, 2195264, 2225408; or other U.S. and foreign patents pending. Quadra-Fire • QVI-25FB • 2031-900 Rev. F • 9/07...
  • Page 2: Safety And Warning Information

    DO NOT place furniture or any other combustible Young children should be CAREFULLY SUPERVISED household objects within 36 inches of the when they are in the same room as the appliance. appliance front. Quadra-Fire • QVI-25FB • 2031-900 Rev. F • 9/07...
  • Page 3: Table Of Contents

    Lighting Instructions ............18 After the Installation ..............18 Section 4: Maintaining and Servicing Your Appliance ..19 Section 5: Troubleshooting ............ 20 Limited Lifetime Warranty ............22 = Contains updated information. Quadra-Fire • QVI-25FB • 2031-900 Rev. F • 9/07...
  • Page 4 QVI-25FB Service Parts Service Parts Diagram Log Set Assembly Part number list on following page. Quadra-Fire • QVI-25FB • 2031-900 Rev. F • 9/07...
  • Page 5: Service Parts Lists

    Patch Kit Conversion Kit NG NGK-FBZC Conversion Kit LP LPK-FBZC Pilot Orifice NG 446-505 Pilot Orifice LP 446-517 Regulator NG 060-518 Regulator LP 060-519 Additional service part numbers appear on following page. Quadra-Fire • QVI-25FB • 2031-900 Rev. F • 9/07...
  • Page 6 Flexible Gas Connector 302-320A Flex Ball Valve Assembly Valve NG 060-522 Valve LP 060-523 2020-059 Wiring Assembly 2019-161 Gasket, Pilot (Bottom) 768-432 Gasket, Pilot (Top) Orifice NG (#36B) 567-801 Orifice LP (#52B) 074-801 Quadra-Fire • QVI-25FB • 2031-900 Rev. F • 9/07...
  • Page 7: Section 1: Approvals And Codes

    No. 70 (in the United States), or to the CSA C22.1 Canadian Electric Code (in Canada). These models may be installed in a bedroom or bed-sitting room in the U.S.A. and Canada. Quadra-Fire • QVI-25FB • 2031-900 Rev. F • 9/07...
  • Page 8: Section 2: Getting Started

    The original appliance may never be returned to sol- ber in a proper workmanship like manner. id fuel in this condition. Quadra-Fire • QVI-25FB • 2031-900 Rev. F • 9/07...
  • Page 9: Insert Dimensions

    * NOTE: If exhaust collar on insert and appliance damper do not line up, add 4 inches (102mm) to minimum appliance height for bends in vent pipe. Figure 1. Diagram of insert and minimum appliance dimensions Quadra-Fire • QVI-25FB • 2031-900 Rev. F • 9/07...
  • Page 10: Section 3: Installing The Insert

    50 feet. These dimensions are measured from the starting collars of the unit to the end of the last section of vent pipe. See dimension V in Figure 3. Quadra-Fire • QVI-25FB • 2031-900 Rev. F • 9/07...
  • Page 11 14/12 to 16/12 building. over 16/12 to 18/12 over 18/12 to 20/12 over 20/12 to 21/12 Figure 2. Minimum Height from Roof to Lowest Discharge Opening Quadra-Fire • QVI-25FB • 2031-900 Rev. F • 9/07...
  • Page 12 INLET AIR COLLAR OF THE TERMINATION CAP OR TERMINATED IN THE CHIMNEY. A 3 FOOT SECTION OF STAINLESS STEEL FLEXIBLE LINER MUST BE ATTACHED DIRECTLY TO THE EXHAUST COLLAR ON COLLAR SLIDE PLATE. Quadra-Fire • QVI-25FB • 2031-900 Rev. F • 9/07...
  • Page 13 (For Flashing Class-A Pipe) SLIDING PLATE CLASS A WOOD PIPE INLET AIR VENT PIPE 3 INCH STAINLESS STEEL COLLAR ADAPTER FOR EXHAUST (MUST BE INSTALLED) Figure 4. Typical configuration of vent liners. Quadra-Fire • QVI-25FB • 2031-900 Rev. F • 9/07...
  • Page 14: Step 2 Positioning, Leveling, And Securing The Insert

    CONNECTED TO A CONTROL VALVE IN A TO CHECK FOR GAS LEAKS. MILLIVOLT SYSTEM. STANDING PILOT CONTROLS FLEXIBLE GAS LINE SHUT-OFF Figure 5. Gas Controls System Figure 6. Gas Supply Line Quadra-Fire • QVI-25FB • 2031-900 Rev. F • 9/07...
  • Page 15: Step 5 Gas Pressure Requirements

    CAN CAUSE IMPROPER AND DANGEROUS OPERATION. VERIFY PROPER OPERATION AFTER SERVICING. THERMOCOUPLE THERMOPILE ROCKER SWITCH RED T1 VALVE WHITE T2 OPTIONAL WALL SWITCH THERMOSTAT OR REMOTE Figure 7. Standing Pilot Ignition Wiring Diagram Quadra-Fire • QVI-25FB • 2031-900 Rev. F • 9/07...
  • Page 16: Wiring The Fan

    SENSOR SWITCH ance must be replaced, it must be replaced with type 105 crated wire. 110-120 VAC Figure 9. Fan Wiring Diagram NOTE: Do NOT install blower if using operable glass doors. Quadra-Fire • QVI-25FB • 2031-900 Rev. F • 9/07...
  • Page 17: Step 7 Installing Logs And Ember Material

    ON/OFF switch ON/OFF through the hole at the upper SWITCH right corner of the surround - it will be retained in the hole. SURROUND WITH TRIM Figure 13. Quadra-Fire • QVI-25FB • 2031-900 Rev. F • 9/07...
  • Page 18: Step 9 Before Lighting The Appliance

    8 hours. This will help to cure the products bustible projections above the gas appliance. used in the paint and logs. Quadra-Fire • QVI-25FB • 2031-900 Rev. F • 9/07...
  • Page 19: Step 10 Lighting The Appliance

    This will help avoid setting off smoke detectors, and help eliminate LEAVE THIS INSTALLATION MANUAL WITH THE any odors associated with the appliance’s initial burning. APPLIANCE FOR FUTURE REFERENCE. Quadra-Fire • QVI-25FB • 2031-900 Rev. F • 9/07...
  • Page 20: Section 4: Maintaining And Servicing Your Appliance

    NOTE: DO NOT handle or attempt to clean the door when it is hot and DO NOT use abrasive cleaners. Quadra-Fire • QVI-25FB • 2031-900 Rev. F • 9/07...
  • Page 21: Section 5: Troubleshooting

    Check the burner orifice for stoppage. Remove stoppage. orifice. e. Wall switch or Follow the corrective action in Symptom and Possible Cause 1.a above. Check wires are defective. the switch and wiring. Replace where defective. Quadra-Fire • QVI-25FB • 2031-900 Rev. F • 9/07...
  • Page 22: Troubleshooting

    Ensure that no debris has been placed at the base of, or in the area of the air holes in the center of the base pan beneath the burner. Ensure that the glass is tightened properly on the unit, particularly on top corners. Quadra-Fire • QVI-25FB • 2031-900 Rev. F • 9/07...
  • Page 23: Limited Lifetime Warranty

    This limited Lifetime Warranty is effective on all appliances sold after May 1, 2002 and supersedes any and all warranties currently in existence. Quadra-Fire • QVI-25FB • 2031-900 Rev. F • 9/07...

Table of Contents