Oil Injection System - Sea-doo 2005 3D RFI Operator's Manual

CAUTION:
The XP-S synthetic
(1)
2-stroke oil is specially formulated
and tested for the severe require-
ments of the 787 RFI engines. Use
of any other brand two-stroke oil
may void the limited warranty. Use
only XP-S synthetic 2-stroke oil.
There is no known equivalent on
the market for the moment. If a
high quality equivalent were avail-
able, it could be used.
The XP-S synthetic 2-stroke oil pro-
vides superior lubrication, reduced en-
gine component wear and oil deposit,
thus maintaining maximum-level per-
formance and anti-friction properties.
This synthetic injection oil meets the
latest ASTM and JASO standards by
ensuring high biodegradability and low
exhaust smoke.
CAUTION:
Never use four-stroke
petroleum or synthetic motor oil
and never mix these with out-
board motor oil. Do not use NMMA
TC-W, TC-W2 or TC-W3 outboard
two-stroke engine oils or ashless
two-stroke engine oils. Avoid mix-
ing different brands of API TC oil as
resulting chemical reactions may
cause severe engine damage.
CAUTION:
DO NOT allow any
four-stroke oil to be used,
put two-stroke oil into a used
four-stroke oil container.
four-stroke oil enters the system,
the entire oil system (pump, reser-
voir, lines, valves etc) must be thor-
oughly cleaned out.

Oil Injection System

This watercraft features an oil injection
system which does not require manu-
al fuel/oil mixing.
A sufficient amount of injection oil
should be maintained in the reservoir.
The use of a funnel is recommended
to pour the oil into the reservoir. Stop
filling as soon as oil appears at approx-
imately 13 mm (1/2 in) from top of
reservoir. Do not overfill.
______________________
48
CAUTION:
ficient amount of injection oil in the
oil reservoir. Check and refill every
time you refuel if necessary. Do not
overfill. If the engine runs out of
oil, severe engine damage will oc-
cur. If the oil reservoir is found al-
most empty, air can enter in the sys-
tem and it should be bled. Immedi-
ately refer to an authorized Sea-Doo
dealer to have the oil injection sys-
tem inspected.
or
If any
www.SeaDooManuals.net
Always maintain a suf-