RAIS 600 Manual Manual

RAIS 600 Manual Manual

Wood burning stove
Hide thumbs Also See for 600:

Advertisement

ENGLISH 
RAIS ­ manual for Rais 600 & Rais 80 
INSTRUCTIONS FOR INSTALLATION, 
USE AND MAINTENANCE 
RAIS 600 & RAIS 80 
IMPORTANT INFORMATION 
On first lighting the stove you must be careful not to touch the painted 
surfaces and it is MOST IMPORTANT that the door is kept slightly 'ajar' in 
order for the door seal and sealant to cure. 
This will prevent the door seal sticking to the painted body and becoming 
damaged.

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the 600 and is the answer not in the manual?

Questions and answers

Summary of Contents for RAIS 600

  • Page 1 ENGLISH  RAIS ­ manual for Rais 600 & Rais 80  INSTRUCTIONS FOR INSTALLATION,  USE AND MAINTENANCE  RAIS 600 & RAIS 80  IMPORTANT INFORMATION  On first lighting the stove you must be careful not to touch the painted  surfaces and it is MOST IMPORTANT that the door is kept slightly ‘ajar’ in  order for the door seal and sealant to cure.  This will prevent the door seal sticking to the painted body and becoming  damaged.
  • Page 2 ENGLISH  RAIS ­ manual for Rais 600 & Rais 80 2 ...
  • Page 3: Table Of Contents

    ENGLISH  RAIS ­ manual for Rais 600 & Rais 80  Revision : 4  Date  : 2011 INTRODUCTION  …………………………………………………………..  4  WARRANTY  …………………………………………………….…………..  4  SPECIFICATIONS …………………………………………………………..  5  CONVECTION  …………………………………………………….………...  6  INSTALLATION INSTRUCTIONS ………………………………….………  7  CHIMNEY ………………………………………………………….………….  8­9  INSTALLATION ……………………………………………………………..  10  QUICK GUIDES ……………………………………………………………..  11­12  INSTALLATION DISTANCE ……………………………………………….  14­16  FOR THE INSTALLER ……………………………………………………..  18  OPERATING INSTRUCTIONS …………………………………………….  19  FUEL ………………………………………………………………………….  19  DRYING AND STORAGE …………………………………………………..  20  USING THE WOOD BURNING STOVE ………………………………….  21  ADJUSTMENT OF AIR DAMPER  ………………………………………...  21­22  CONTROL …………………………………………………………………… ...
  • Page 4: Introduction

    ENGLISH  RAIS ­ manual for Rais 600 & Rais 80  Introduction  Thank you for purchasing a Rais wood burning stove.  These appliances have been approved by HETAS as  intermittent operating appliances for burning wood logs only. A Rais wood burning stove is more than just a heat source: it also shows that you  care about design and quality in your home.  To make the most of your wood burning stove it is important that you read the manual  thoroughly before installing and using it.  In the case of warranty coverage, and for general queries regarding your wood  burning stove, it is important that you know the stove’s production number.  We therefore recommend that you note down the number in the table below.  The production number is located in the top of the convection box.  Warranty  Your Rais wood burning stove comes with a 5 year warranty.  The warranty, however, does not cover heat­insulating materials, glass and seals.  These are available to order from your local Rais dealer / stockist.  Any alterations made to the stove will void the warranty.  4 ...
  • Page 5 ENGLISH  RAIS ­ manual for Rais 600 & Rais 80  Rais 600  Rais 80  Nominal output (kW):  5  5  Min. / Max. output (kW):  2 ­ 6  2 ­ 6  2  Heating area (m  ):  Ca. 80  Ca. 80  Size, width/depth/height (mm):  700  ­  448  ­  475  504  ­  408  ­  960  Combustion chamber  width/depth/height (mm).  530  ­  330  ­  350  372  ­  238  ­  300  Recommended amount of wood when fuelling (kg)  1.6  1.7 ...
  • Page 6: Convection

    ENGLISH  RAIS ­ manual for Rais 600 & Rais 80  Convection  Rais stoves are convection stoves. This means that the stove’s back and side panels are  not over­heated. Convection means that there is a circulation of air, which ensures that  the heat is distributed more evenly throughout the entire room. The cold air is sucked in at  the base of the stove and up through the convection channel, which runs along the  stove’s combustion chamber. The heated air comes out at the top of the stove, which  ensures a circulation of warm air throughout the room. The stoves are equipped with cool door handles  ­  a Rais special feature  ­ which means  you could almost do away with gloves.  Be aware, however, that all exterior surfaces  become hot during use  ­  so take extreme care.  6 ...
  • Page 7: Installation Instructions

    ENGLISH  RAIS ­ manual for Rais 600 & Rais 80  Installation Instructions  The following pages give instructions for the safe and proper installation of this heating  appliance in the UK. These instructions cover the basic principles of installation,  although some details may need slight modification to suit particular local site conditions.  In all cases the installation must comply with current UK Building Regulations, Local  Authority Byelaws and other specifications or regulations as they affect the installation of  the stove.  Please note that it is a legal requirement under England and Wales Building Regulations  that the installation of the stove is either carried out under local Authority Building  Control approval or is installed by a Competent Person registered with a Government  approved Competent Persons Scheme. HETAS operate such a scheme and a listing of  their registered Competent Persons can be found on their website at www.hetas.co.uk.  It should be noted that the current Building Regulations requirements are given in  Approved Document J. These requirements may also be met by adopting the relevant  recommendations given in British Standards BS 8303, BS 6461 and BS 7566.  WARNING.  Health and Safety Advice Notice.  The installation of this heating appliance is governed by the Health and Safety at Work  Act 1974. it is the responsibility of the installer to ensure that all requirements of this Act  are met during the installation works. Attention is drawn in particular to the following:  Handling:  The appliance is a heavy item and adequate facilities must be available  for loading, unloading and site handling.  Fire Cement:  Some types of fire cement are caustic and should not be allowed to come  into contact with the skin. Protective gloves should be worn when  handling fire cement. In case of contact with the skin, wash immediately  with plenty of water.  Asbestos:  This stove contains no asbestos. If there is a possibility of disturbing any  asbestos in the course of the installation, then please seek specialist  guidance and use appropriate protective equipment.  Metal Parts:  When installing or servicing this stove care should be taken to avoid the  possibility of personal injury.  Important Warning  ­  Preparatory Work and safety Checks: This stove must not be installed into a chimney which serves any other heating ...
  • Page 8: Chimney

    ENGLISH  RAIS ­ manual for Rais 600 & Rais 80  Chimney  The chimney is the driving force which makes the stove function. In order for the stove to  perform satisfactorily the chimney height must be sufficient to ensure the correct draught  of 14 to 18 Pa, so as to clear the products of combustion and prevent problems of smoke  leaking into the room when the stove is lit.  Note: A chimney height of not less than 4.5 metres, measured vertically from the outlet of  the stove to the top of the chimney, should be satisfactory.  Alternatively the calculation procedure given in BS 5854:1980 may be used as the basis  for deciding whether a particular chimney design will provide sufficient draught.  Please Note, this appliance has been tested by the manufacturers and works on a 3m  straight flue.  The outlet from the chimney should be above the roof of the building in accordance with  the provisions of the Building Regulations Approved Document J.  If the installation is into an existing chimney, then it must be sound and have no cracks or  other faults which may allow fumes into the house. Older properties, especially, may have  chimney faults or the cross section may be too large i.e. more than 230 x 230mm.  Remedial action should be taken if required, expert advice should be sought where  required.  If the chimney requires lining, then a suitable solid fuel flue liner must be used, in  accordance with Building Regulations Approved Document J.  Any existing chimney must be clear of obstruction and should have been swept clean  immediately before the installation of the stove. If the stove is fitted in place of an open  fire, then the chimney should be swept one month after installation to clear any soot falls  which may have occurred due to the difference in combustion between the stove and the  open fire.  If there is no existing chimney then either a prefabricated block chimney, in accordance  with Building Regulations Approved Document J or a twin wall insulated stainless steel  flue to BS 4543 can be used. These chimneys must be fitted in accordance with the  manufacturer’s instructions and the Building Regulations.  A single wall metal fluepipe is suitable for connecting the stove to the chimney but is  not suitable for using for the complete chimney. The chimney and  connecting fluepipe must have a minimum diameter of 150mm and it’s  dimension should be not less than the size of the outlet socket of the stove which is  150mm. Any bend in the chimney or connecting fluepipe should not exceed 45°. 90°  bends should not be used.  Combustible material should not be located where the heat dissipating through the  walls of fireplaces or flues could ignite it. Therefore when installing the stove in the  presence of combustible materials due account must be taken of the ...
  • Page 9 ENGLISH  RAIS ­ manual for Rais 600 & Rais 80  If it is found that there is excessive draught in the chimney then either an  adjustable flue damper or alternatively a draught stabiliser should be fitted. The  adjustable flue damper should not close off the flue entirely, but should in its  closed position leave a minimum continuous opening free area of at least 20 % of  the total cross sectional area of the flue or fluepipe.  Adequate provision e.g. easily accessible soot door or doors must be provided for  sweeping the chimney and connecting fluepipe.  You should also familiarise yourself with the draught conditions for chimneys with  2 flues.  For strong draughts, the chimney or flue should be fitted with a draught  stabiliser. In which case, it is important to ensure that there is a free flow­through  2  area of minimum 20 cm  when the regulating gate is shut. Otherwise, the fuel en­  ergy may not be used optimally.  If, at any time, you are unsure about the condition of the chimney, you should  contact a chimney sweep.  Remember that access to the soot door should be kept clear. 9 ...
  • Page 10: Installation

    ENGLISH  RAIS ­ manual for Rais 600 & Rais 80  Installation  It is prohibited to carry out unauthorised alterations to the stove.  There must be plenty of fresh air in the room where the stove is being installed, in order to  ensure proper combustion. Note that any mechanical exhaust ventilation ­ e.g. an  extraction hood ­ may reduce the air supply. Any air grilles must be placed in such a  manner, that the air supply is not blocked.  Building Regulations Approved Document J gives specific guidance on the required  permanent ventilation into the room for combustion air of solid fuel appliances.  The floor structure must be able to carry the weight of the wood burning stove, as well as  the weight of a chimney, if necessary.  The stove should be set up at a safe distance from inflammable materials.  See the manufacturer's plate on the wood burning stove. 10 ...
  • Page 11 ENGLISH  RAIS ­ manual for Rais 600 & Rais 80 11 ...
  • Page 12 ENGLISH  RAIS ­ manual for Rais 600 & Rais 80 12 ...
  • Page 13 ENGLISH  RAIS ­ manual for Rais 600 & Rais 80 13 ...
  • Page 14 ENGLISH  RAIS ­ manual for Rais 600 & Rais 80 14 ...
  • Page 15 ENGLISH  RAIS ­ manual for Rais 600 & Rais 80  Using a spirit level against the door and body of the stove, ensure that the stove is  perfectly level and make adjustments using the levelling bolts in the base.  Remove the frame and door from the stove. Be careful not to damage the glass or paint.  Seal the flue pipe on to the flue outlet using fire cement and self tapping screws and con­  nect to the chimney. 15 ...
  • Page 16 ENGLISH  RAIS ­ manual for Rais 600 & Rais 80 16 ...
  • Page 17 ENGLISH  RAIS ­ manual for Rais 600 & Rais 80  Using a spirit level against the door and body of the stove, ensure that the stove is  perfectly level and make adjustments using the levelling bolts in the base.  Remove the frame and door from the stove. Be careful not to damage the glass or paint.  Seal the flue pipe on to the flue outlet using fire cement and self tapping screws and con­  nect to the chimney. 17 ...
  • Page 18: For The Installer

    ENGLISH  RAIS ­ manual for Rais 600 & Rais 80  For the Installer  Finally before firing the stove for the first time a check should be made to ensure that the  assembly and stove installation has been satisfactory and that there are no leaks in any  seals in the appliance and appliance connections to the chimney.  Ensure that the appliance and chimney flue are functioning correctly before finally  handing over to the user. Read the later parts of this manual for guidance on care  required when first lighting.  Inform the user that the appliance has been commissioned and ready to use and give in­  struction on the safe operation of the stove.  These Instructions must be left with the user and the user should be instructed to keep  them in a safe place. 18 ...
  • Page 19: Operating Instructions

    ENGLISH  RAIS ­ manual for Rais 600 & Rais 80  Operating instructions  Please note that HETAS Appliance Approval only covers the use of dry seasoned wood  logs on this appliance. HETAS Approval does not cover the use of other fuels either  alone or mixed with the wood logs, nor does it cover instructions for the use of other  fuels.  Fuel  The stove is designed and approved in accordance with EN 13240 and NS 3058 for  stoking split, dried firewood. The firewood must have a water content of 15­22% and its  max. length should be the length of the combustion chamber minus 50­60 mm.  Stoking with wet firewood causes both soot, environmental pollution and bad fuel  economy. Freshly cut wood contains approx. 50­70% water and is thoroughly unsuitable  for stoking. Allow at least 1 year of storage time for newly cut wood before using. Wood  with a diameter of more than 100 mm should be split. Regardless of wood size, it should  always have at least one surface area free of bark.  We do not recommend stoking with painted, laminated or impregnated wood, wood with  a synthetic surface, painted refuse wood, chipboard, plywood, domestic waste, paper  bri­quettes and pit coal, as this will produce malodorous smoke, which could be  poisonous.  When firing with the above­mentioned items and amounts larger than those  recommended, the stove is subjected to a larger amount of heat, which results in a  higher chimney temperature and lower efficiency. This can result in the stove and  chimney becoming damaged and would void the warranty.  The calorific value of the firewood is closely connected to the moisture level.  Moist firewood has a low heat value. The more water the wood contains, the more  energy it takes for this water to vaporise, resulting in this energy being lost. ONLY USE RECOMMENDED FUELS  The following table shows the calorific value of different types of wood, which have been  stored for 2 years and which have a residual moisture of 15 ­  17%.  3  Wood  Kg dry wood pr m  compared to beech/oak  Hornbeam  640  110%  Beech and oak  580 ...
  • Page 20: Drying And Storage

    ENGLISH  RAIS ­ manual for Rais 600 & Rais 80  Drying and storage  Drying wood takes time: proper air drying takes approximately 2 years.  Here are some tips:  Store the wood sawn, split and stacked in an airy, sunny place, which is protected against  rain (the south side of the house is particularly suitable).  Store the firewood stacks at a hand's breadth apart, as this ensures that the air flowing  through takes the moisture with it. Avoid covering the firewood stacks with plastic, as this  prevents the moisture from escaping. It is a good idea to bring the firewood into the house  2­3 days before you need it.  Regulating the combustion air  All RAIS stoves are equipped with a one­handed operating lever for regulating the damper.  The stove­specific regulating mechanisms can be seen on the diagrams.  Primary air is the combustion air added to the primary combustion zone, i.e. the bed of  glowing embers. This air, which is cold, is only used in the lighting stage. Secondary air is  the air which is added in the gas combustion zone, i.e. air which contributes to the  combustion of the pyrolysis gasses (preheated air, which is used for the cleaner glass  system and combustion). This air is sucked through the damper under the combustion  chamber and is pre­heated through the side channels and then emitted as hot scavenging  air onto the glass. The hot air rinses the glass and keeps it soot­free.  The tertiary channel, which can be seen at the top of the combustion chamber towards the  back, serves to combust the final gas residues.  By setting the interval between position 1 and 2, the energy content in the firewood is used  optimally, as there is oxygen for combustion and for the burning of the pyrolysis gasses.  When the flames are a clear yellow the damper has been set correctly. Finding the correct  position comes with time after you have used for stove for a while.  It is not recommended that you turn it down completely. A mistake commonly made is  shutting the damper too early because it feels too hot. This results in dark smoke emanating  from the chimney and in the calorific value of the firewood not being used to its fullest. 20 ...
  • Page 21: Using The Wood Burning Stove

    ENGLISH  RAIS ­ manual for Rais 600 & Rais 80  Using the wood burning stove  Adjusting the air damper.  The damper has 3 settings.  Position 1  The damper is closed meaning that there is a minimal  air intake.  Position 2  Push the lever to the right until it stops. This position  gives full secondary air.  During normal use the lever is set between position 1  and 2.  When the flames are clear and yellow, the damper is  set correctly, i.e. resulting in a slow/optimal burning.  Position 3  Push the lever upwards and to the right.  The air damper is completely open and gives full  primary and secondary air. This position is for the  lighting stage and is not used under normal operation.  Control  If the ash is white and the walls in the combustion chamber are soot free after the stove  has been used, the air regulation was set correctly and the wood was sufficiently dry. 21 ...
  • Page 22: Control

    ENGLISH  RAIS ­ manual for Rais 600 & Rais 80  Adjusting the air damper.  The damper has 3 settings.  Position 1  The damper is closed meaning that there is a minimal  air intake.  Position 2  Push the lever to the right until it stops. This position  gives full secondary air.  During normal use the lever is set between position 1  and 2.  When the flames are clear and yellow, the damper is  set correctly, i.e. resulting in a slow/optimal burning.  Position 3  Push the lever upwards and to the right.  The air damper is completely open and gives full  primary and secondary air. This position is for the  lighting stage and is not used under normal operation.  Control  If the ash is white and the walls in the combustion chamber are soot free after the stove  has been used, the air regulation was set correctly and the wood was sufficiently dry.  22 ...
  • Page 23: First Usage

    ENGLISH  RAIS ­ manual for Rais 600 & Rais 80  First usage  A careful start pays off. Start with a small fire, so that the wood burning stove can get  accustomed to the high temperature. This gives the best start and any damage is  avoided.  Be aware that a strange but harmless odour and smoke concoction may emanate from  the surface of the stove, the first time you fire up. This is because the paint and  materials need to harden. The odour disappears quickly, but you should check the  ventilation and draught, if possible. See also, the IMPORTANT warning notice below  about persistent fumes.  During this process you must be careful not to touch the painted surfaces, it is  recommended that you regularly open and close the door to prevent the door seal from  sticking.  The stove may also produce "clicking noises" during heating and cooling, caused by the  large temperature differences which the material is subjected to.  Never use any type of liquid fuel for kindling or maintaining the fire. You could be at risk  of explosion.  The stove gets very hot when in use, always wear protective gloves when tending the  stove.  If the stove has not been used for a while, follow the steps as if you were using it for the  first time.  IMPORTANT ­ Warning Note!  Properly installed, operated and maintained this appliance will not emit fumes into the  dwelling. Occasional fumes from de­ashing and re­fuelling may occur.  However, persistent fume emission is potentially dangerous and must not be tolerated.  If fume emission does persist, the following immediate actions should be taken:  (a)  Open doors and windows to ventilate room.  (b)  Let the fire out or eject and safely dispose of fuel from the appliance.  (c)  Check for flue or chimney blockage, and clean if required.  (d)  Do not attempt to relight the fire until the cause of the fume emission has been  identified and corrected. If necessary seek expert advice. 23 ...
  • Page 24 ENGLISH  RAIS ­ manual for Rais 600 & Rais 80  To light the stove, use alcohol briquettes or  similar, as well as approximately 2kg of  firewood, split into kindling sticks. Set the air  damper to the fully open position.  Tips before firing up:  Open a door or window close to the wood  burning stove.  If there is ‘storm’ in the stove coming from the  chimney it is advisable to place a screwed up  piece of newspaper between the upper baffle  plate and the chimney. Light the paper and  wait until you hear a ‘rumbling’ noise in the  chimney. This means that there is definitely a  draught in the chimney and you should avoid  smoke coming back into the room.  Light the fire and shut the  door, leave the door ajar  approximately 10­15mm. 24 ...
  • Page 25 ENGLISH  RAIS ­ manual for Rais 600 & Rais 80  When the flames are clear, after approximately 5­10  minutes, close the door.  Damper  ­  see adjustment of the damper.  After approximately 10­20 minutes, when you have a  good bed of glowing embers, add 2­3 pieces of wood.  Leave the door ajar until the fire has caught properly,  then close the door.  Damper  ­  see adjustment of the damper.  After approximately 5 minutes, or when the flames are  clear and stable, close the damper gradually.  It is recommended to have a layer of approximately  20mm, as it has an insulating effect.  NOTE!  During operation the  door should always  remain closed. 25 ...
  • Page 26: Cleaning And Care

    ENGLISH  RAIS ­ manual for Rais 600 & Rais 80  Cleaning and care  The wood burning stove and the chimney must be serviced by a chimney sweep twice a  year.  During cleaning and care, the stove must be cold.  If the glass is sooty:  ­  Moisten a piece of paper or newspaper, dip it in the ash, and rub the sooty glass with it.  ­  Now rub with a dry piece of paper and the glass will become clean.  ­  As an alternative you can use glass cleaner, which you can buy from you RAIS  distributor.  Clean the exterior with a dry sponge or a soft brush.  Cleaning the combustion chamber:  Scrape/shovel the ash out and store it in a non­flammable container until it has cooled  down. You can dispose of ash with your normal household waste or recycle on the  garden.  REMEMBER!!  Never remove all the ashes from the combustion chamber ­ the wood will burn at its best  with a layer of ashes of approx. 20 mm.  Prolonged periods of non­use:  If the stove is to be left unused for a prolonged period of time then it should be given a  thorough clean to remove ash and unburned fuel residues. To enable a good flow of air  through the appliance to reduce condensation and subsequent damage, leave the air  controls fully open.  Prior to a new heating season, it should be checked that the chimney and flue pipe  connector are not blocked. 26 ...
  • Page 27 ENGLISH  RAIS ­ manual for Rais 600 & Rais 80  Remove the baffle plate by  lifting it up at one end and  tilting it slightly at an angle.  Carefully pull out the plate. ONLY RAIS 80  Push the throat plate up into  the hollow space.  Then carefully  pull it out,  downwards  Remove any dirt / dust and put the parts back in, in  reverse order.  27 ...
  • Page 28: Problem Solving

    ENGLISH  RAIS ­ manual for Rais 600 & Rais 80  Problem solving  Smoke spillage around door:  ­ could be due to too low draught in the chimney <12Pa  ­  check if the flue or chimney is blocked  ­  check if a extraction hood is switched on; if it is, switch it off and open a window/door in  the proximity of the stove for a short while.  Soot on glass:  ­  could be because the firewood is too wet.  ­  make sure that the stove is heated properly when firing up, prior to closing the door  ­  could be because the damper regulation is too low.  A stove burning too strong could be caused by:  ­  a leak around the door seal  ­  chimney draught too large >22 Pa, draught control regulator should be installed.  A stove burning too weakly could be caused by:  ­  too little firewood  ­  too little air supply for the room ventilation  ­  dirty smoke channels  ­  leaking chimney  ­  leakage between chimney and flue  If your stove continues to malfunction, we recommend that you contact your RAIS  distributor or chimney sweep.  IMPORTANT!!  To ensure safe burning there must be clear yellow flames or clear embers at all times. The  firewood should not be smouldering. Therefore you should never completely cut off the air  supply.  WARNING!! ...
  • Page 29: Accessories And Spare Parts

    ENGLISH  RAIS ­ manual for Rais 600 & Rais 80  Accessories and spare parts  If spare parts other than those recommended by RAIS are used, the warranty is voided.  All replacement spare parts can be purchased from your RAIS distributor / stockist.  See the following spare parts diagrams for the individual products. 29 ...
  • Page 30 ENGLISH  RAIS ­ manual for Rais 600 & Rais 80  Position  Quantity  Item No.  Description  1  1  7081490/95  Standard frame  2  1  7081090/95  Door  3  1  7082200  Firebrick set  4  1  4054­01  45° adaptor  5  1  4035500  Seal set 30 ...
  • Page 31 ENGLISH  RAIS ­ manual for Rais 600 & Rais 80 31 ...
  • Page 32 ENGLISH  RAIS ­ manual for Rais 600 & Rais 80  Position  Quantity  Item No.  Description  1  1  3061090/95  Door  2  1  1211490/95  Standard Frame  3  1  3061216BLACK  Smoke bonnet ­  upper channel  4  1  1212212  Upper baffle plate  5  1  3062200  Firebrick set  6  1  3064001 / 3064002  Ash pan with cover  7  1  1211790  Air box  8  1  3065500  Seal set 32 ...
  • Page 33 ENGLISH  RAIS ­ manual for Rais 600 & Rais 80 33 ...
  • Page 34 ENGLISH  RAIS ­ manual for Rais 600 & Rais 80  U K Distributor.  Robeys Ltd.  Riverside, Goods Road, Belper,  Derbyshire, England.  DE56 1UU  Tel: 01773 820940  Fax: 01773 820477  E Mail: info@robeys.co.uk  www.robeys.co.uk  June 2011 34 ...

This manual is also suitable for:

80

Table of Contents