Roof Penetration - Heatilator C40 Installation Manual

G. Roof Penetration
• Re er to i ure 10
• lu ro roo to enter o
• Drive a nail u t rou
• Measure to eit er si e o nail an
14-1/2 in 3 8
• Measure o enin on t e ori ontal a tual len t
e lar er e en in on roo
• Cut out an ra e o enin
• Re er to Chapter 25 of the Uniform Building Code for
roo ra in etails
Install Flashing
• sse le i ne so it asses t rou
o enin
• li t e as in over t e
Roofing shingles must be below the flashing
NOTICE:
plate on the lower side of a sloped roof and over the
flashing plate on the sides and top.
• ail t e as in to t e roo
as in late an t e roo to a
• Caul t e as in
t e verti al sea
e aul e it a roo n sealant
• Caul t e overla sea o an e ose
t at are lo ate a ove t e roo line to revent lea s
H. Manufactured Home Installation
SL-300 Series Ceiling/Roof Thimble
NOTICE: REQUIRED for manufactured homes.
• o ate t e oint
lu in o n to t e enter o t e
ut an ra e a 14-1/2 in 3 8
easure on t e ori ontal t rou
stru ture Consult local codes for framing details.
• e t i le ust e ten
stru ture s iel in
oles ave een rovi e to allo
roo t i nesses
t e eilin /roo t i ness e ee s 12-1/2 in 318
e e tension s oul overla t e t i
• o atta t e e tension to t e t i
oles t rou t e outer s iel o t e t i
re rille oles in t e e tension as ui es
e tension to t e t i
t e e tension
• Install t e t i le asse
ra in e ers
30 Heatilator • C40 Constitution • 480-2340 Installation Manual • Rev D • 05/30/13
i ne
roo to ar enter o
ar t e 14-1/2 in
3 8 o enin re uire
it
i ne
ee a s et een t e
ini u
late an roo un tion as ell as
on t e as in ll nail ea s
i e se tions
ere t e i ne ill e it t e roo
i ne
s uare o enin
t e eilin an roo
o letel t rou
o usti le aterials
or a variet o eilin /
t i le e tension is re uire
le one in
le rill 1/8 in 3
le usin t e
le usin t e s re s rovi e
l an nail it se urel to t e
i e
a
t e ra e
ust
• Center t e as in over t e
a out roo
to a
as ell as t e verti al sea on t e as in
ust e aul e
t e roo • inis
ive lo ation ter ination a
rovi e
en
tta t e
it
Figure 6.11 Installing Part: 12966A, Configuration 1
Figure 6.10 Ceiling/Attic Construction
ee a s et een t e as in
ini u Caul t e as in
it a roo n sealant
asse lin t e i ne
ollo in t e installation instru tions
it t e
F L A S H I N G
i ne an nail it to t e
late an t e roo
late an roo un tion
ll nail ea s
stor ollar an
C H I M N E Y
F L A S H I N G
P L A T E
J O I S T S
N A I L
T H I M B L E