Evo Affinity 30G Owners & Installation Manual

Evo Affinity 30G Owners & Installation Manual

Outdoor gas cooktop
Hide thumbs Also See for Affinity 30G:

Advertisement

OWNER & INSTALLATION MANUAL
A f f i n i t y 3 0 G
C o o k t o p
R
Evo Affi nity 30G
Outdoor Gas Cooktop
Certifi cation: UL 197-2010 | CSA C22.2 No. 109-M1981 (R2009)
Part #: Commercial models: 10-0054-NG, 10-0054-LP
Residential models: 10-0051-NG, 10-0051-LP, 10-0055-LP, 10-0055NG
Doc: OM-C&R-30G v2 1/2012
Copyright © 2012
Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA
Phone 503.626.1802 | Fax 503.213.5869 | www.evoamerica.com | support@evoamerica.com

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Affinity 30G and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for Evo Affinity 30G

  • Page 1 Part #: Commercial models: 10-0054-NG, 10-0054-LP Residential models: 10-0051-NG, 10-0051-LP, 10-0055-LP, 10-0055NG Doc: OM-C&R-30G v2 1/2012 Copyright © 2012 Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA Phone 503.626.1802 | Fax 503.213.5869 | www.evoamerica.com | support@evoamerica.com...
  • Page 2: Installation Instructions

    Model #_______________________________ Serial # _________________________________ Date Purchased ________________________ Location Purchased _______________________ Date Installed __________________________ Location Installed _________________________ Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA Phone 503.626.1802 | Fax 503.213.5869 | www.evoamerica.com | support@evoamerica.com...
  • Page 3 Grill shall not be located under unprotected overhead made of combustible construction. Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA Phone 503.626.1802 | Fax 503.213.5869 | www.evoamerica.com | support@evoamerica.com...
  • Page 4 DURING THE FIRST FEW HOURS OF OPERATION IT IS NORMAL FOR OILS USED IN THE MANUFACTURING PROCESS TO BURN OFF AND GIVE AN ODOR OR PETROLEUM SMOKE. Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA Phone 503.626.1802 | Fax 503.213.5869 | www.evoamerica.com | support@evoamerica.com...
  • Page 5 This appliance is not intended to be installed in or on boats, and is not intended to be installed in or on recreational vehicles. Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA Phone 503.626.1802 | Fax 503.213.5869 | www.evoamerica.com | support@evoamerica.com...
  • Page 6 The maximum liability to Evo, Incorporated in any event, shall not exceed the purchase price of the product paid by the original consumer-purchaser.
  • Page 7 One Year from the original date of purchase from Evo, Inc. This warranty is for the benefi t of the original use purchaser and is non-transferable.
  • Page 8: Installation Checklist

    INSTALL COOK SURFACE AND TIGHTEN FASTENERS 18-20 CONNECT GAS & CHECK FOR LEAKS 21-24 CHECK INSTALLATION & TEST EVO Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA Phone 503.626.1802 | Fax 503.213.5869 | www.evoamerica.com | support@evoamerica.com...
  • Page 9 Ignition components are exposed during uncrating and installation. Use caution and do not alter factory set positions. Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA Phone 503.626.1802 | Fax 503.213.5869 | www.evoamerica.com | support@evoamerica.com...
  • Page 10 Read the instructions carefully in this booklet to install the Evo Affi nity 30G Cooktop to a stainless steel, stone or wood countertop surface. Cabinet layout and construction may vary. Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA...
  • Page 11 704.85mm OPENING IN COUNTERTOP FRONT STEP 2: Mark the fi nished position of the Evo Affi nity 30G drip pan on the countertop using the dimensions shown. The circular dimension of 18-1/8” is the diameter of the drip pan to the outside fl...
  • Page 12 Also ensure allowance for the countertop overhang as shown on the SIDE VIEW (see next page). When you have confi rmed the position is correct, cut the countertop and substrate. Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA Phone 503.626.1802 | Fax 503.213.5869 | www.evoamerica.com | support@evoamerica.com...
  • Page 13 Example of 3/8” tile with substrate for a minimum 3 cm (1-1/5”) overall. Make sure you allow for the countertop overhang as shown. Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA Phone 503.626.1802 | Fax 503.213.5869 | www.evoamerica.com | support@evoamerica.com...
  • Page 14 30G if desired. STEP 3: Construct a bay for the Evo unit with your chosen cabinet system. Position and fasten the supplied mounting brackets 7.65” below the fi nished countertop surface. Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA...
  • Page 15: Insert Chassis In Countertop

    Gas Installation must be done by a licensed professional in accordance with local guidelines once unit has been completely installed. Refer to pages 21- 24 for further instructions. Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA Phone 503.626.1802 | Fax 503.213.5869 | www.evoamerica.com | support@evoamerica.com...
  • Page 16 From the inside of the skirt, use each of the three latches to pull the drip pan down into the counter. Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA Phone 503.626.1802 | Fax 503.213.5869 | www.evoamerica.com | support@evoamerica.com...
  • Page 17 STEP 6: Secure drip pan to chassis using access slot (A). Rewrap drip pan gasket around top of drip tray and secure (B). Ensure seal under drip pan edge is touching countertop(C). Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA Phone 503.626.1802 | Fax 503.213.5869 | www.evoamerica.com | support@evoamerica.com...
  • Page 18 Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA Phone 503.626.1802 | Fax 503.213.5869 | www.evoamerica.com | support@evoamerica.com...
  • Page 19 (B) and the rear bullet secures in the chassis slot (C) . Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA Phone 503.626.1802 | Fax 503.213.5869 | www.evoamerica.com | support@evoamerica.com...
  • Page 20 If screws are secure, cook surface should not move more than 1/16”. Remove all protective cardboard on cook surface and drip pan. Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA Phone 503.626.1802 | Fax 503.213.5869 | www.evoamerica.com | support@evoamerica.com...
  • Page 21: Connecting Gas

    Refer to pages 21-24 for specifi c instructions regarding LP and NG connections, checking for gas leaks and recognizing abnormal gas operation (page 29). Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA Phone 503.626.1802 | Fax 503.213.5869 | www.evoamerica.com | support@evoamerica.com...
  • Page 22 If the above information is not followed exactly, a fi re causing death or serious injury may occur. Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA Phone 503.626.1802 | Fax 503.213.5869 | www.evoamerica.com | support@evoamerica.com...
  • Page 23 Note: All factory-made connections have been thoughly checked for gas leaks. The burners and ignition system has been fl ame tested. As a safety precaution, we recommend you recheck all fi ttings for leaks before using your Evo grill. Shipping and handling may loosen or damage a gas fi tting.
  • Page 24 Note: All factory-made connections have been thoughly checked for gas leaks. The burners and ignition system has been fl ame tested. As a safety precaution, we recommend you recheck all fi ttings for leaks before using your Evo grill. Shipping and handling may loosen or damage a gas fi tting.
  • Page 25: Check Installation

    GAS CONNECTION HOOKED UP PROPERLY 21-24 Check for gas leaks. Check for proper operation. INSTALLATION IS COMPLETE Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA Phone 503.626.1802 | Fax 503.213.5869 | www.evoamerica.com | support@evoamerica.com...
  • Page 26: Operator Instructions

    Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA Phone 503.626.1802 | Fax 503.213.5869 | www.evoamerica.com | support@evoamerica.com...
  • Page 27: Removable Spillover Trays

    Spillover debris and liquids can be hot and cause burns, and/or damage to the internal operation of the grill. Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA Phone 503.626.1802 | Fax 503.213.5869 | www.evoamerica.com | support@evoamerica.com...
  • Page 28: Lighting Instructions

    4. Once the burner has been lit, remove the match and extinguish the match fl ame. Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA Phone 503.626.1802 | Fax 503.213.5869 | www.evoamerica.com | support@evoamerica.com...
  • Page 29: Recognizing Abnormal Gas Operation

    Remove cooking surface and drip pan to access valve cover located just above center control knob. Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA Phone 503.626.1802 | Fax 503.213.5869 | www.evoamerica.com | support@evoamerica.com...
  • Page 30: Replacing Electronic Ignitor Battery

    Place the cover back on and insert the spillover drawer carefully onto the slides. 4. If the ignitor is still not working, contact Evo Customer Support for an ignitor replacement. Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA...
  • Page 31: Affinity 30G Dimensions

    Diameter 36 5/32” 914mm 11 7/32” 292mm LPG Inlet Hose Connection Right Rear Quarter 21 7/32” 495mm Evo, Inc. | 8140 SW Nimbus Ave., Bldg 5 | Beaverton, Oregon 97008 USA Phone 503.626.1802 | Fax 503.213.5869 | www.evoamerica.com | support@evoamerica.com...
  • Page 32 To condition the Evo cook surface you should use the grill cleaning kit supplied with your grill. The grill cleaning kit contains a blue grill pad handle, grill cleaning screens, and grill grey polishing pads. Use the polishing pad after the grill cleaning pads to achieve a smooth cooking surface for the most delicate foods and applications.

Table of Contents