Advertisement
U
S
ERIES
TO THE INSTALLER: This manual is the property of the owner and must be affixed near the boiler for
TO THE OWNER: This boiler should be inspected annually by a Qualified Service Agency.
Service Agency
Address
Boiler Model No. DE-
I
SER'S
NFORMATION
DE G
future reference.
WARNING: If the information in this manual is not
followed exactly, a fire or explosion may result causing
property damage, personal injury or loss of life.
– Do not store or use gasoline or other flammable vapors
and liquids in the vicinity of this or any other appliance.
– WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch;
do not use any phone in your building.
• Immediately call your gas supplier from a neighbor's
phone. Follow the gas supplier's instructions.
• If you cannot reach your gas supplier, call the fire
department.
– Installation and service must be performed by a qualified
installer, service agency or the gas supplier.
TO BE COMPLETED BY THE INSTALLER
PB HEAT, LLC
131 S. CHURCH ST • BALLY, PA 19503
AS
Serial No.
M
ANUAL
B
OILERS
Phone No.
Date of Installation:
DE8040 R3 (12/10-5C)
Printed in U.S.A.
Advertisement
Table of Contents
Related Manuals for PB Heat DE Series
Summary of Contents for PB Heat DE Series
- Page 1 TO BE COMPLETED BY THE INSTALLER Service Agency Phone No. Address Boiler Model No. DE- Serial No. Date of Installation: PB HEAT, LLC 131 S. CHURCH ST • BALLY, PA 19503 DE8040 R3 (12/10-5C) Printed in U.S.A.
- Page 2 Basic Operation WARNING Service on this boiler should be undertaken only by trained and skilled personnel from a qualified service agency. CAUTION Should overheating occur or the gas supply fail to shut off, do not turn off or disconnect the electrical supply to the pump.
- Page 3 Figure 1: Control Locations Figure 2: Safety Relief Valve Figure 3: Safety Relief Valve Hook-Up Installation with Air Hook-Up with Air Elimination Elimination in System Piping B. Instructions to place boiler in operation and to turn off the boiler are shown on the Operating Instruction Label posted on the inner jacket panel of the boiler.
- Page 4 Figure 4: Intermittent Ignition Operating Instructions...
- Page 5 User Maintenance WARNING Product Safety Information Refractory Ceramic Fiber Product This appliance contains materials made from refractory ceramic fibers (RCF). Airborne RCF, when inhaled, have been classified by the International Agency for Research on Cancer (IARC), as a possible carcinogen to humans. After the RCF materials have been exposed to temperatures above 1800°F (980°C), they can change into crystalline silica, which has been classified by the IARC as carcinogenic to humans.
- Page 6 WARNING Service on this boiler should be undertaken only by trained and skilled personnel from a qualified service agency. Inspections should be performed at intervals specified in the Installation, Operation and Maintenance Manual and this User’s Information Manual. Maintain manuals in a legible condition. Keep boiler area clear and free of combustible materials, gasoline and other flammable vapors and liquids.
- Page 7 7. Check main burner flames. See Figure 5. The flames should have clearly defined inner cones approximately 1½" (40 mm) high and should have a very sharp blue color characteristic. If the flame is yellow and lazy, follow instructions TO TURN OFF GAS TO APPLIANCE (see Figure 4), and contact qualified service agency.
Need help?
Do you have a question about the DE Series and is the answer not in the manual?
Questions and answers