02
–
Fit roof aerial
Engine compartment (from above)
–
Check battery no-load voltage; recharge if necessary
–
Check tight connection of electric cables and plug connections (in particular battery ca-
bles)
–
Brake fluid level (at „MAX" marking)
–
Check the engine oil level (to be in-between the marking on the dipstick)
–
Check the coolant level (in-between marking), for special equipment antifreeze down to -
35 °C
–
Fill up fluid in washer reservoir, in the winter add antifreeze
–
Check windscreen wiper and washer system, the spray nozzle adjustment and the resting
position of the windscreen wipers
Vehicle interior
–
Inspect upholstery, interior trim, carpeting and footmats for cleanliness and damage
–
Inspect all switches, all electrical components, gauges/indicators and controls
–
Radio: Inspect for proper operation, store stations, encode, set clock
–
Fit net in luggage compartment (if available)
–
Vehicle log book - for completion: Operating manual and service plan (in the correct lan-
guage and with the correct edition data), short introduction, technical data, support in the
case of a breakdown, other manuals (radio,...) ) - all in the vehicle log book pouch
–
Reset service interval display
–
Power windows: Inspecting positioning
–
Key switch for airbag deactivation, front passenger side: Check function „ON/OFF" and
switch-over to the position „ON"
Underside of vehicle (on lift platform)
–
Inspect underbody (underbody protection for damage)
–
Inspect for leaks and damage: Engine, gearbox, final drive, steering, brake system, axles,
joint boots. Check proper routing of the brake hoses and brake lines, fuel lines including
ventilation of the fuel system
–
Inspect tyres and wheels for damage
Concluding operations
–
Perform a test drive
–
Interrogate fault memory of all systems, if necessary erase
–
Complete the service schedule, affix the vehicle data sticker in the Service Schedule to
the floor of the luggage compartment next to the spare wheel, complete the „Next Service
Date" sticker and affix to the side of the dash panel on the driver's side
–
Remove recharging table (if affixed)
–
Remove protective seat covers
–
Install the carpets supplied in the vehicle
–
Final inspection to ensure proper condition for handover to customer
02-2
4
page
FABIA 2000
Inspection
Inspection and Maintenance
02-6
02-5
02-3
02-3
02-7
02-6
02-6
02-6
02-6
02-7
02-7
02-3, 02-5
02-5
02-9
02-6
02-7
Edition 09.04
S00.5301.14.20