Table Of Contents - PEERLESS Stainless Steel Gas Boilers Installation, Operation & Maintenance Manual

TABLE OF CONTENTS

TABLE OF CONTENTS
USING THIS MANUAL
A. INSTALLATION SEQUENCE . . . . . . . . . . . . .1
B. SPECIAL ATTENTION BOXES . . . . . . . . . . . .1
1. PREINSTALLATION
A. ACCESSIBILITY CLEARANCES . . . . . . . . . . .2
B. CLEARANCE FROM COMBUSTIBLE
CONSTRUCTION . . . . . . . . . . . . . . . . . . . . . .2
C. INSTALLATION SURVEY . . . . . . . . . . . . . . . .2
D. PLANNING THE LAYOUT . . . . . . . . . . . . . . . .2
2. BOILER SET-UP
3. WATER PIPING AND CONTROLS
A. GENERAL . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
B. SPECIAL APPLICATIONS . . . . . . . . . . . . . . . .4
C. OPERATING PARAMETERS . . . . . . . . . . . . . .4
D. PRIMARY/SECONDARY PIPING . . . . . . . . . .4
E. SYSTEM COMPONENTS . . . . . . . . . . . . . . . .5
F. SYSTEM PIPING . . . . . . . . . . . . . . . . . . . . . . .5
G. FREEZE PROTECTION . . . . . . . . . . . . . . . . . .6
4. GAS PIPING
5. VENTING
A. GENERAL . . . . . . . . . . . . . . . . . . . . . . . . . . .14
B. EXHAUST VENT/AIR INLET VENT
LOCATION . . . . . . . . . . . . . . . . . . . . . . . . . .14
C. EXHAUST VENT INSTALLATION . . . . . . . .14
D. AIR INLET VENT INSTALLATION . . . . . . . .15
E. EXTENDED VENT LENGTHS WITH
4" PIPE . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18
F. CONDENSATE . . . . . . . . . . . . . . . . . . . . . . .18
1
G. BOILER REMOVAL FROM COMMON
VENTING SYSTEM . . . . . . . . . . . . . . . . . . .18
6. ELECTRICAL
2
A. WIRING . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19
B. ZONED SYSTEM WIRING . . . . . . . . . . . . . .19
C. SEQUENCE OF OPERATION . . . . . . . . . . . .21
7. START-UP PROCEDURES
A. COMPLETING THE INSTALLATION . . . . . . .22
B. LIGHTING/OPERATING INSTRUCTIONS . . .23
3
C. CONTROL DESCRIPTIONS . . . . . . . . . . . . .24
D. CHECK-OUT PROCEDURE . . . . . . . . . . . . . .24
4
8. TROUBLESHOOTING
A. SHUT-DOWN . . . . . . . . . . . . . . . . . . . . . . . .25
B. BOILER FAULT CODES . . . . . . . . . . . . . . . .26
C. BOILER FAULT CONDITIONS . . . . . . . . . . .26
9. MAINTENANCE
A. GENERAL (WITH BOILER IN USE) . . . . . . .28
B. WEEKLY (WITH BOILER IN USE) . . . . . . . . .28
12
C. ANNUALLY (BEFORE START OF
HEATING SEASON) . . . . . . . . . . . . . . . . . . .28
14
10. BOILER DIMENSIONS & RATINGS
11. REPAIR PARTS
19
22
25
28
29
31