Advertisement
Advertisement
Table of Contents
Related Manuals for King Canada KCG-2000i
Summary of Contents for King Canada KCG-2000i
- Page 1 2000W GASOLINE DIGITAL INVERTER GENERATOR Read this manual. Do not attempt to operate this generator until you have read and understood the safety, operation, and maintenance instructions MODEL: KCG-2000i INSTRUCTION MANUAL COPYRIGHT © 2009 ALL RIGHTS RESERVED BY KING CANADA TOOLS INC.
-
Page 2: Warranty And Service Information
KING CANADA shall in no event be liable for death, injuries to persons or property or for incidental, special or consequential damages arising from the use of our products. Shipping and handling charges may apply. If a defect is found, KING CANADA will either repair or replace the product. - Page 3 BASIC & SPECIFIC SAFETY PRECAUTIONS BE CAREFUL! DO NOT USE KEEP FLAMMABLE DO NOT USE IN DO NOT CONNECT TO IN YOUR HOUSE HOUSEHOLD CIRCUIT MATERIALS AWAY WET CONDITIONS WHEN REFUELING; STOP ENGINE! NO SMOKING! DO NOT SPILL GASOLINE! BASIC SAFETY INFORMATION EXHAUST FUMES ARE DANGEROUS FUEL •Never operate the engine in a closed area or it may cause...
-
Page 4: Specific Safety Precautions
SPECIFIC SAFETY PRECAUTIONS OPERATION OF GENERATOR IN RAIN, WET, ICY, OR FLOODED RISK OF BREATHING - INHALATION HAZARD CONDITIONS. Operate generator in clean, dry, well ventilated area. Never operate Water is an excellent conductor of electricity! Water which comes in unit in enclosed areas such as garages, basements, storage, sheds, or contact with electrically charged components can transmit electricity to in any location occupied by humans or animals. - Page 5 9. Recoil starter. Starts the engine. 19. Oil gauge dipstick. Check the oil level using this oil gauge 10. DC Outlet. Use to power 12V DC items. dipstick. MODEL KCG-2000i Peak Wattage (starting) 2100W Running Wattage 2000W AC Outputs 1(2x 120V/16.7A)
-
Page 6: Pre-Start Check
PRE-START CHECK ASSEMBLY Your Digital Inverter Generator comes completely assembled, please proceed to the pre-start check before attempting to start the engine. PRE-START CHECK WARNING! To prevent permanent damage to generator or any appliances, you MUST check oil level, fuel level, air cleaner filter and unplug any load from the generator before starting. -
Page 7: Starting Procedures
STARTING PROCEDURES STARTING PROCEDURES GROUNDING WARNING! BEFORE STARTING, YOUR GENERATOR MUST BE GROUNDED! Before operating make sure to ground the generator. A ground terminal identified by the ground symbol (Fig.5) can be found on the front control panel of the generator, attach a metal spike to a wire, attach the wire to the ground terminal and ground the metal spike into the earth. -
Page 8: Electrical Connections
Plug voltage sensitive appliances such as TV's, VCR's, microwaves, ovens, computers, and cordless telephones. Overloading the generator will cause power fluctuations and can damage equipment and appliances. King Canada will not be responsible for equipment damaged as a result of voltage surges, improper operation or improper installation of the generator. -
Page 9: Wattage Calculations
WATTAGE CALCULATIONS WATTAGE CALCULATIONS DETERMINING WATTAGE REQUIREMENTS IMPORTANT! Never exceed the rated capacity of your generator. Note: Volts X Amps = Watts Example: 120V X 16.7 Amps = 2000 Watts Serious damage to the generator or appliance could result from an overload. -
Page 10: Maintenance
MAINTENANCE Engine Oil Replacement Engine oil should be replaced after the first 20 hours of operation or after the first month of use, it should be replaced every 50 hours or 6 months after. To replace engine oil; 1) Open rear access panel, then loosen and remove the oil gauge dipstick (A) Fig.9. 2) Screw the oil drain pipe (B) into the oil gauge dipstick opening. -
Page 11: Storage & Troubleshooting
STORAGE & TROUBLESHOOTING GENERATOR STORAGE If you plan on storing your generator for an extended period of time, the following steps should be followed; 1) Add fuel stabilizer to fuel tank to minimize the formation of fuel gum deposits during storage.