LIMITED TOOL WARRANTY KING CANADA makes every effort to ensure that this product meets high quality and durability standards. KING CANADA warrants to the original retail consumer a 1-year limited warranty as of the date the product was purchased at retail and that each product is free from defects in materials.
Page 3
BASIC & SPECIFIC SAFETY PRECAUTIONS BE CAREFUL! DO NOT USE KEEP FLAMMABLE DO NOT USE IN DO NOT CONNECT TO IN YOUR HOUSE WET CONDITIONS HOUSEHOLD CIRCUIT MATERIALS AWAY WHEN REFUELING: STOP ENGINE! NO SMOKING! DO NOT SPILL GASOLINE! BASIC SAFETY INFORMATION WARNING! The engine muffler will be very hot after use, avoid touching the engine or muffler while they are still hot.
SPECIFIC SAFETY PRECAUTIONS OPERATION OF GENERATOR IN RAIN, WET, ICY, OR FLOODED RISK OF BREATHING - INHALATION HAZARD CONDITIONS. Operate generator in clean, dry, well ventilated area. Never operate Water is an excellent conductor of electricity! Water which comes in unit in enclosed areas such as garages, basements, storage, sheds, or contact with electrically charged components can transmit electricity to in any location occupied by humans or animals.
Page 5
GETTING TO KNOW YOUR GENERATOR IMPORTANT To obtain max wattage, use the standard 120V double receptacles together as shown below. (Max 41.6A). Note: If drawing 10 Amp. from a 120V double receptacle, only 10 Amp. are available for use from the 120V/240V L14-30 Nema receptacle.
ASSEMBLY & PRE-START CHECK WARNING! To prevent permanent damage to generator or any appliances, you MUST check oil level, fuel level, air cleaner filter and unplug any load from the generator before starting. ASSEMBLY Remove all the contents from the carton and proceed to the following assembly steps: Wheels To install a wheel (B) Fig.1 to the right end of the frame, insert bolt (A) through the wheel, then slide washer (C) on opposite side of the wheel.
PRE-START CHECK & STARTING PROCEDURES PRE-START CHECK AIR CLEANER FILTER The air cleaner filter should be checked before every start-up and after prolonged storage, the following steps should be done when checking air cleaner filter: 1) Snap the two side clips (A) Fig.3 backwards and remove the air cleaner cover (B). 2) Remove the air cleaner filter (C), shake off debris and dust, blow with air if needed.
Overloading the generator will cause power fluctuations and can damage equipment and appliances. King Canada will not be responsible for equipment damaged as a result of voltage surges, improper operation or improper installation of the generator.
WATTAGE CALCULATIONS WATTAGE CALCULATIONS DETERMINING WATTAGE REQUIREMENTS IMPORTANT! Never exceed the rated capacity of your generator. Seri- Note: Volts X Amps = Watts ous damage to the generator or appliance could result from an over- Example: 120V X 10 Amps = 1200 Watts load.
MAINTENANCE & STORAGE MAINTAINING YOUR GENERATOR Engine Oil Replacement Engine oil should be replaced after the first 20 hours of operation or after the first month of use, it should be replaced every 100 hours or 6 months after. To replace engine oil: 1) Loosen the oil gauge dipstick (A) Fig.8.
Page 11
PARTS DIAGRAM & PARTS LISTS Refer to the Parts section of the King Canada web site for the most updated parts diagram and parts list.
Need help?
Do you have a question about the POWER FORCE KCG-6502GE and is the answer not in the manual?
Questions and answers