Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for King Canada POWER FORCE KCG-2500i
Summary of Contents for King Canada POWER FORCE KCG-2500i
- Page 1 2500W GASOLINE DIGITAL INVERTER GENERATOR Read this manual. Do not attempt to operate this generator until you have read and understood the safety, operation, and maintenance instructions MODEL: KCG-2500i INSTRUCTION MANUAL COPYRIGHT © 2025 ALL RIGHTS RESERVED BY KING CANADA TOOLS INC.
-
Page 2: Warranty And Service Information
LIMITED TOOL WARRANTY KING CANADA makes every effort to ensure that this product meets high quality and durability standards. KING CANADA warrants to the original retail consumer a 1-year limited warranty as of the date the product was purchased at retail and that each product is free from defects in materials. - Page 3 BASIC & SPECIFIC SAFETY PRECAUTIONS BE CAREFUL! DO NOT USE DO NOT CONNECT TO KEEP FLAMMABLE DO NOT USE IN IN YOUR HOUSE MATERIALS AWAY WET CONDITIONS HOUSEHOLD CIRCUIT WHEN REFUELING: STOP ENGINE! NO SMOKING! DO NOT SPILL GASOLINE! BASIC SAFETY INFORMATION EXHAUST FUMES ARE DANGEROUS FUEL •Never operate the engine in a closed area or it may cause...
-
Page 4: Specific Safety Precautions
SPECIFIC SAFETY PRECAUTIONS OPERATION OF GENERATOR IN RAIN, WET, ICY, OR FLOODED RISK OF BREATHING - INHALATION HAZARD CONDITIONS. Operate generator in clean, dry, well ventilated area. Never operate Water is an excellent conductor of electricity! Water which comes in unit in enclosed areas such as garages, basements, storage, sheds, or contact with electrically charged components can transmit electricity to in any location occupied by humans or animals. - Page 5 GETTING TO KNOW YOUR DIGITAL INVERTER GENERATOR 1. Fuel cap. Make sure the fuel cap is always screwed on tightly. Use optional Parallel Cable (Mod. K-X2P) for combined output power. unleaded gasoline only! 4.2 Liter capacity. Turn cap lever to the “On” 10.
-
Page 6: Pre-Start Check
PRE-START CHECK ASSEMBLY Your Digital Inverter Generator comes completely assembled, please proceed to the pre-start check before attempting to start the engine. PRE-START CHECK WARNING! To prevent permanent damage to generator or any appliances, you MUST check oil level, fuel level, air cleaner filter and unplug any load from the generator before starting. -
Page 7: Starting Procedures
STARTING PROCEDURES STARTING PROCEDURES GROUNDING WARNING! BEFORE STARTING, YOUR GENERATOR MUST BE GROUNDED! Before operating make sure to ground the generator. A ground terminal (A) Fig.4 identified by the ground symbol can be found on the front control panel of the generator, attach a metal spike to a wire, attach the wire to the ground terminal and ground the metal spike into the earth. -
Page 8: Electrical Connections
Plug voltage sensitive appliances such as TV's, VCR's, microwaves, ovens, computers, and cordless telephones. Overloading the generator will cause power fluctuations and can damage equipment and appliances. King Canada will not be responsible for equipment damaged as a result of voltage surges, improper operation or improper installation of the generator. -
Page 9: Wattage Calculations
CONTROL PANEL & WATTAGE CALCULATIONS CONTROL PANEL • MAIN AC RESET -(A) FIG.8. If an overload or short-circuit of the main circuit occurs, the main circuit reset will “trip” to protect the circuit, causing the generator to automatically shut off. Disconnect all electrical items from the control panel. Press the main AC reset (A) and the corresponding tripped reset button and restart the generator. -
Page 10: Maintenance
MAINTENANCE Engine Oil Replacement Engine oil should be replaced after the first 20 hours of operation or after the first month of use, it should be replaced every 50 hours or 6 months after. To replace engine oil; 1) Open rear access panel, loosen and remove the oil gauge dipstick (A) Fig.9. 2) Tilt the generator forward and drain the oil from the engine. -
Page 11: Storage & Troubleshooting
STORAGE & TROUBLESHOOTING GENERATOR STORAGE If you plan on storing your generator for an extended period of time, the following steps should be followed; 1) Add fuel stabilizer to fuel tank to minimize the formation of fuel gum deposits during storage. - Page 12 OPERATING YOUR GENERATOR IN HIGH ALTITUDE (2,000 FT - 7000 FT ABOVE SEA LEVEL) High Altitude Operation Above 2,000 feet WARNING! Operating this engine above 2,000 feet above sea level without the proper High Altitude Parts Kit installed may increase the engine’s emissions and decrease fuel economy and performance.
-
Page 13: Parts Diagram & Parts Lists
ELECTRICAL DIAGRAM PARTS DIAGRAM & PARTS LISTS Refer to the Parts section of the King Canada web site for the most updated parts diagram and parts list.
Need help?
Do you have a question about the POWER FORCE KCG-2500i and is the answer not in the manual?
Questions and answers