TurboChef TORNADO Service Manual page 6

Chapter 7: The Convection Circuit
Convection Circuit Components
Convection Circuit/Blower Motor Parts
Convection Circuit Troubleshooting
Motor Winding Resistances Table
Chapter 8: IR Element and Catalytic Converter
Components
IR Element and Catalyst Removal
Removing the IR Element
Removing & Installing the Catalytic Converter
Installing a New IR Element
IR Element and Catalytic Converter Parts
Chapter 9: Schematics and Schematic Components
Schematic Parts
Line Voltage Components
Low Voltage Components
Wire Harness Replacement P/N's
I/O Control Board Item Identification and Test Point Locations
Schematic - I/O Board
Oven Schematics
Chapter 10: Service Parts and Illustrations
Figure 7: NGC (Tornado) Control System
Figure 17: Control System Panel Enclosure and Parts
Figure 18: Monitor Circuit - Shown in Failsafe State
Figure 20: Microwave System Parts
Figure 21: Microwave System Parts
Figure 22: Wave Guide Cover/Wave Guide Removal and Replacement
Figure 24 & 25: High Voltage Diode and Magnetron
Figure 26: Oven Door Removal and Parts
Figure 29: Primary and Secondary Adjustment and Parts - Old Switch Setup
Figure 30: Door Switch Assembly and Parts
Figure 31: Motor Switch Adjustment and Assembly - Old Switch Setup
Figure 32: Primary Interlock Adjustment and Parts - New Switch Setup
Figure 33 & 34: Secondary and Monitor Adj. and Assy. - New Switch Setup
Figure 35: Oven Door Assembly
Figure 37: Convection Circuit Block Diagram
Figure 38: Convection Circuit Assembly and Parts
Figure 39: IR Element and Catalytic Converter Parts and Assembly
Figure 46: Covers and Miscellaneous Parts - Non-SBK Ovens
Figure 47: Covers and Miscellaneous Parts - SBK Ovens
Chapter 11: Comprehensive Part List
Comprehensive Part List
47
48
49
50
51
51
51
52
52
52
53
53
53
53
53
54
55 - 63
65
66
67
67
68
68
69
69
70
70
71
71
72
73
74
75
76
77
78
79