Fri-Jado TDR 5 User Manual

Tdr-p eco series
Hide thumbs Also See for TDR 5:

Advertisement

ECO
TDR-P
Models
USER MANUAL
ECO
TDR-P
SERIES EN (Original Instruction)
9123872 / 1205

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the TDR 5 and is the answer not in the manual?

Questions and answers

Summary of Contents for Fri-Jado TDR 5

  • Page 1 TDR-P Models USER MANUAL TDR-P SERIES EN (Original Instruction) 9123872 / 1205...
  • Page 2 Models KEEP THIS USER MANUAL FOR FUTURE USE © 2012 Fri-Jado BV, Etten-Leur, The Netherlands. We advise you to contact your supplier for the guarantee period and conditions. Further we refer to our General Terms and Conditions for Sales and Delivery that are available upon request.
  • Page 3: Table Of Contents

    TDR-P Models CONTENTS INTRODUCTION ......................5 1.1. General ........................... 5 1.2. Identification of the unit ....................5 1.3. Pictograms and symbols....................5 1.4. Safety instructions ......................6 1.4.1. General ........................6 1.4.2. Moving ........................7 1.4.3. Outdoor use restrictions ................... 7 1.5.
  • Page 4 TDR-P Models 5.1. Operation of the rotisserie ..................22 5.2. Operation options ....................... 26 5.2.1. To end a running program..................26 5.2.2. Check the actual temperature ................26 5.2.3. Check the remaining time in a program .............. 27 5.2.4. Show all actual program information ..............27 5.2.5.
  • Page 5: Introduction

    TDR-P Models INTRODUCTION 1.1. General This manual is intended for the user of the TDR-P . The features and controls are being described, along with directions for the safest and most efficient use, in order to guarantee a long life of the unit. All pictograms, symbols and drawings in this manual apply to all available TDR models.
  • Page 6: Safety Instructions

    TDR-P Models 1.4. Safety instructions WARNING The outside of the unit can be very hot. WARNING The maximum load on top of the unit may never exceed 50 kg. WARNING Always use the brakes on both front wheels: 1.4.1. General The user of the unit will be fully responsible for abiding the locally prevailing safety- rules and regulations.
  • Page 7: Moving

    TDR-P Models 1.4.2. Moving When moving the unit:  Before moving the unit, first switch off the mains voltage by pulling the plug from the wall socket and empty the fat collecting drawer. After that, cool-down the unit for at least ten minutes.
  • Page 8: Hygiene

    TDR-P Models 1.5. Hygiene The quality of a fresh product always depends on hygiene. Especially grilling products. With the risk of salmonella contamination – especially for chicken products – you must make sure that grilled products can never be mixed with uncooked products. Also contact between grilled products and hands or tools that have been in contact with raw chicken meat, must be avoided at all times.
  • Page 9: Description Of The Unit

    TDR-P Models DESCRIPTION OF THE UNIT 2.1. Technical description The unit uses a combination of direct infra red radiation and convection heat. The rotor is being wheeled by a maintenance-free motor and gearbox. The fan ensures an equally divided heat. The glass panes are equipped with a heat reflecting layer to keep the heat inside the grill.
  • Page 10: Installation And First Use

    TDR-P Models INSTALLATION AND FIRST USE 3.1. Unpacking the unit Your unit is packed in a plastic cover with protective corners, and a carton box around it. All units are placed on a wooden pallet. Around the box there are two tightening straps. Figure 3 Figure 4 Figure 5...
  • Page 11: Dismantling The Pallet

    TDR-P Models All packing materials used for this unit are suited for recycling. After unpacking, check the state of the unit. In case of damage, store the packing material, and contact the transporter within fifteen working days after receiving the goods. 3.2.
  • Page 12: Installation And Positioning

    TDR-P Models 3.3. Installation and positioning Figure 7  The user must have sufficient freedom of movement to properly operate the unit (see Figure 7).  The minimum free distance must be at least 250  During grilling, the glass panes will get very hot. While positioning, keep the unit out of children’s reach.
  • Page 13 TDR-P Models The cleaning remains will find its way to the fat collection drawer, so this drawer must be cleaned and emptied after cleaning the unit.  Place the bottom plates in the grilling compartment (see Figure 8). Bottom Plates Figure 8 ...
  • Page 14 TDR-P Models Metal odour To remove the metal odour that will appear at first use, the unit must be heated at the maximum temperature for at least half an hour. 14-48 9123872 / 1205 EN /...
  • Page 15: Operation And Use

    TDR-P Models OPERATION AND USE 4.1. Control Panel ON/OFF UNDO LIST FORWARD BACK ROTOR Figure 10 Functions of the controls Button Function ON / OFF Switching the unit on / off UNDO Go back to previous menu LIST Receipt / Programming modus FORWARD One step ahead in setting ROTOR Switching the rotor on...
  • Page 16: Switching-On The Unit

    TDR-P Models 4.2. Switching-on the unit 4.3. Loading the rotisserie First select a program (see section 5). When the door is open press the rotor button to activate the rotor. This allow easy loading or unloading the products. Whilst loading the unit, make sure that the rotor gets evenly loaded, so that the mass of the products is evenly spread over de rotor, causing an equal balance.
  • Page 17 Whole uncut chickens should always be grilled using the meat forks. This way their natural fat will baste each other, giving a perfectly slender cooking result. Refer to the You-Tube movie: “Fri-Jado instruction for binding and loading chicken”. 17-48 9123872 / 1205 EN /...
  • Page 18: Loading The Rotisserie Using Meat Baskets (Accessory)

    Figure 14), act as follows:  With the TDR 5 you must stick the ends of the meat baskets through the appropriate holes of the rotor disks (see Figure 13).  With the TDR 7 and TDR 8 you must attach the meat baskets to the appropriate pins...
  • Page 19: Loading The Rotisserie Using Chicken Racks (Accessory)

    ONE accessory fewer than the maximum allowed quantity. See to it that accessories of the same type are placed consecutively. Example For both TDR 5 and TDR 5 + 5: 1 meat fork + 2 meat baskets consecutively 19-48 9123872 / 1205...
  • Page 20: Grilling Time

    TDR-P Models 4.4. Grilling time Grilling time depends on a number of factors:  The ambient temperature and draft in the direct vicinity of the unit.  Grilling temperature.  The initial product temperature.  The sort of meat (fat or lean) and with or without additives. ...
  • Page 21: Taking Out The Meat Basket (Accessory)

    4.5.3. Taking out the meat basket (accessory) For the TDR 5 you can use the same principal as described in section 4.5.2. For both the TDR 7 and TDR 8 it is preferred to act as follows: 1. Slightly lift both ends of the meat basket.
  • Page 22: Operation

    For Quick Start refer to the Quick Reference Card supplied with the unit. Buttons are lit when functional. 5.1. Operation of the rotisserie 1. Press Start. 2. Display shows Fri-Jado logo. 3. Display shows software version. Interface P Electronic Version x.x.x.x 4. Display shows latest cooking Drumstick program.
  • Page 23 TDR-P Models 7. Confirm the selected program. 8. Display shows pre-heat 180°C Preheat (when pre-heat is defined). 9. Pre-heat ready LOAD (unit returns a sound signal). START Display shows the next step of the program. Note: Screen 9 and 11 alternate each 5 seconds.
  • Page 24 TDR-P Models 14. (Optional) Press OK button for the actual temperature and time (shows about 2 seconds). 1 Chicken 15. During the last minute the time blinks. 230° P123 0:60 16. Display show the remaining time, the 1 Chicken interval is 5 seconds. 230°...
  • Page 25 TDR-P Models 21. Program ready, open door. UNLOAD 22. Press the rotor button to rotate the rotor. 23. Close the door (if required clean the unit). 24. Display shows the last operated Chicken program. 98 99 25-48 9123872 / 1205 EN /...
  • Page 26: Operation Options

    TDR-P Models 5.2. Operation options 5.2.1. To end a running program. 1. Press and hold start for 3 seconds. Stop? 2. Make a choice with the arrow buttons. Note: Select NO to abort ending the program. 3. Confirm the selection. (Within 5 seconds).
  • Page 27: Check The Remaining Time In A Program

    TDR-P Models 5.2.3. Check the remaining time in a program 1. Use the arrow buttons to show the 1 Chicken remaining time pro step. 230° P123 0:05 1 Chicken 2. Time left at step 1 230° P123 0:01 (first digit blinks). 3.
  • Page 28: Eco Function

    TDR-P Models 6. Press the OK button to go back. 1 Chicken 7. Display returns to the original 180° P123 0:20 operating display. 5.2.5. Eco function Optional: only available when activated 1 Chicken in the service menu. 180° P123 0:20 In the ECO mode the accumulated heat in the cavity will be used to cook the product.
  • Page 29: Display Information

    TDR-P Models 5.2.7. Display information 180°C 1. Display shows the programmed 0:20 temperature and time. 2. Press the list button. 3. Display shows after 3 seconds 1 Chicken cooking step + temperature + time. 180° P123 0:20 Note: the current cooking step is underlined.
  • Page 30: Manager Menu

    TDR-P Models MANAGER MENU 6.1. Manager menu items Programming Parameters Change pin code Language Clock Change Large digits Store Delete Pre-Heat Copy Holding Reading recipes Preheat temperature Store recipes Holding temperature Sound step 1 Sound step 2 Sound step 3 6.2.
  • Page 31 TDR-P Models code. 8. Press the arrow right button to Pin 1 - - - change the first digit. Give User PIN code 9. Press the OK button to confirm. 10. The next digit is activated. Change as required using the arrow Pin * 0 - - button.
  • Page 32 TDR-P Models 16. Press the OK button to confirm. 17. Enter the recipe name. 10 A-------------- for other Use the arrow button to change the character. Note: ABC can be changed with the use of the arrow buttons into lower / higher case or special characters.
  • Page 33 TDR-P Models 23. Set the “step 1” temperature. 10 Step 1 Starting with the first digit. Temp 1 - - ° C 24. Use the arrow buttons to increase/decrease the value of the selected digit. 25. Press the OK button to confirm. 26.
  • Page 34 TDR-P Models 32. Press the OK button to confirm. 33. Set the second digit. 10 Step 1 Temp 215 ° C Time 2:1 - 34. Press the OK button to confirm. 35. Set the last digit. 10 Step 1 Temp 215 ° C Time 2:10 36.
  • Page 35 TDR-P Models 41. Press the OK button to confirm. 42. The screen returns to the RECIPES RECIPES menu. 1EDIT 43. Press back to enter the manager menu. 44. Manager menu appears. MANAGER MENU USB Programming 1Para. 45. Press back to enter the user menu. 46.
  • Page 36: Options Manager Menu: Usb

    TDR-P Models 6.3. Options manager menu: USB MANAGER MENU 1. Manager menu. USB Programming 1Para. 2. Use the arrow buttons to select the USB function. 3. Screen shows the USB function. MANAGER MENU Place the USB stick into the USB- USB Programming 1Para.
  • Page 37: Programming Parameters

    TDR-P Models 6.4. Programming parameters 1. Press the list button. Pin * * * * 2. Enter your user PIN code. Give User PIN code 3. Press the OK button to confirm. 4. Use the arrow buttons to select MANAGER MENU Parameters.
  • Page 38 TDR-P Models 9. Current value is shown Language: Dutch 10. Use the arrow buttons to change the Language: English setting. 11. Press the OK button to confirm. Language: Dutch Change Next 1Previous 12. Use the arrow buttons to select Change, Next or Previous. Press back to enter the manager menu.
  • Page 39: Cleaning And Maintenance

    TDR-P Models CLEANING AND MAINTENANCE WARNING Never use a water hose for cleaning. Water can seep into the unit through the ventilation holes of the unit. WARNING Do not touch the halogen lamps with bare hands. Protect hot lamps from cold water. Because of hygiene aspects and optimum condition of the unit it is of...
  • Page 40: Weekly Cleaning

    TDR-P Models The interior Clean the interior with cleaning agent or hot water combined with an appropriate cleaning agent. Dry the interior thoroughly by using a dry cloth. Make sure no water or detergent stays behind in the unit. 7.3. Weekly Cleaning WARNING The control panel may only be cleaned using a damp...
  • Page 41: Monthly Cleaning

    TDR-P Models 7.4. Monthly Cleaning WARNING Remove the power plug from the wall socket. Prior performing the weekly cleaning first execute the daily and weekly cleaning. Clean the fan plate and the fan blade thoroughly as described below. Fan plate: Remove the fan plate by loosening two winged nuts (see Figure 18).
  • Page 42: Malfunctions And Service

    TDR-P Models MALFUNCTIONS AND SERVICE Before you contact your supplier/dealer in case of a malfunction, there are some items you can check yourself:  Is the power supply working properly? Check fuses and differential switch.  Has the timer clock been properly set? Item Malfunction Possible action...
  • Page 43: Replace A Lamp

    TDR-P Models 8.2. Replace a lamp WARNING Remove the power plug from the wall socket. WARNING Do not touch the lamps with bare hands. Use a clean cloth or paper tissues when replacing the lamp. Remove any moisture with alcohol or methyl spirits after the lamp has cooled down.
  • Page 44: Technical Specifications

    The electrical data may vary from country to country. The technical specifications of the different models in the TDR-P -series, are shown in the next tables. European Models Model TDR 5 TDR 8 TDR 5+5 TDR 8+8 Dimensions Width...
  • Page 45: 10. Accessories And Options

    10. ACCESSORIES AND OPTIONS For all rotisserie models in the TDR-series mentioned in this manual, the following accessories are available: Figure 21 For the TDR 5 specifically: Figure 22 For the TDR 7 and TDR 8 specifically: Figure 23 45-48...
  • Page 46 TDR-P Models 46-48 9123872 / 1205 EN /...
  • Page 47 TDR-P Models 47-48 9123872 / 1205 EN /...
  • Page 48 TDR-P Models Fri-Jado BV Oude Kerkstraat 2 4878 AA Etten-Leur The Netherlands Tel: +31 (0) 76 50 85 400 Fax: +31 (0) 76 50 85 444 48-48 9123872 / 1205 EN /...

This manual is also suitable for:

Tdr 7

Table of Contents