Manufacturer Reserves The Right To Discontinue, Or Change At Any Time, Specifications Or Designs Without Notice And Without Incurring Obligations - Carrier AQUASNAP 30RB060-390 Controls, Start-Up, Operation, Service And Troubleshooting Instructions

Operating limitations
44
Flow rate requirements
45
Minimum and maximum cooler flow rates
(sizes 060-300)
45
Minimum and maximum cooler flow rates
(sizes 315-390)
45
Minimum fluid loop volume
Password
3, 4
Voltage
44
Plug components
52
Recommended maintenance schedule
Every 12 months
57
Every 3 months
57
Monthly
57
Routine
57
Refrigerant circuit
56
Refrigerant feed components
Electronic expansion valve
Relief devices
56
High-side protection
56
Low-side protection
56
Safety considerations
2
Safety devices
56
Compressor protection
56
Crankcase heaters
56
Scrolling marquee display
3
Alarms mode
93
Configuration mode
88, 89
Display menu structure
4
Inputs mode
86
Operating mode
93
Outputs mode
87
Password
3
Pressure mode
85
Run status mode
82, 83
Service test mode
84
Set points mode
86
Temperature mode
85
Time clock mode
90-93
Service
49-57
Coil maintenance and cleaning
Compressors
56
Condenser fans
55
Cooler protection
51
Electronic expansion valve (EXV)
MCHX (microchannel)
55
Refrigerant circuit
56
Relief devices
56
RTPF (round tube, plate fin)
Safety devices
56
Copyright 2009 Carrier Corporation

Manufacturer reserves the right to discontinue, or change at any time, specifications or designs without notice and without incurring obligations.

Catalog No. 04-53300028-01
44
57
49
53-55
49
53
Printed in U.S.A. Form 30RB-3T
Start-up
44,45
Actual start-up
44
Operating limitations
44
Pre-start-up
43,44
System check
43
Start-up and operation. See Start-up Checklist
Start-up checklist
CL-1 to Cl-9
Switch control
32
System check
43
Temperature limits
for standard units
44
Low ambient operation
44
Temperature reset
33
4 to 20mA temperature reset
4 to 20mA temperature reset configuration
table
40
Chilled water temperature control
Outdoor air temperature reset
Outdoor air temperature reset configuration
table
37
Space temperature reset
38
Space temperature reset configuration
Water temperature difference reset
configuration
36
Thermistors
71
Compressor return gas temperature
Cooler entering fluid sensor
Cooler leaving fluid sensor
Dual chiller LWT
71
Outdoor air temperature
72
Remote space temperature
Typical space temperature sensor
wiring
74
Time schedule
32
Troubleshooting
57-81
Sensors
71
Service test
74
Thermistors
71
Tube plugging
51
Pg 114
38
35
35
39
71
71
71
72
12-09 Replaces: 30RB-2T