Subscribe to Our Youtube Channel
Related Manuals for Winco Home power HPS6000HE
Summary of Contents for Winco Home power HPS6000HE
- Page 1 TRI-FUEL PORTABLE GENERATORS OWNERS MANUAL MODELS HPS6000HE HPS9000E HPS12000HE HPS 6000HE HPS 9000E HPS12000HE INSTALLATION, OPERATION, and MAINTENANCE INSTRUCTIONS...
-
Page 2: Table Of Contents
COPY YOUR MODEL AND SERIAL Engine Care NUMBER HERE Generator Care No other HOME POWER generator has the same serial Cleaning number as yours. It is important that you record the Troubleshooting - Things To Check BEFORE number and other vital information here. If you should... -
Page 3: Guide To Product Safety
3. DEADLY EXHAUST GAS - Exhaust fumes from any GUIDE TO PRODUCT SAFETY gasoline engine contain carbon monoxide, an invisible, odorless and deadly gas that must be mixed with fresh air. This engine generator set has been designed and manufactured to allow safe, reliable performance. Poor a. -
Page 4: Specifications
SPECIFICATIONS MODEL HPS12000HE MODEL CSAHPS6000HE Generator Surge Watts* 12000 Generator Continuous Watts* 10800 Surge Watts* 6000 Volts 120/240 Continuous Watts* 5500 AMPs @ 240 Volts 45.0 Volts 120/240 AMPs @ 120 Volts 90.0 AMPs @ 240 Volts 22.9 * Derate 10% for LP and 20% for NG AMPs @ 120 Volts 45.8 * Derate 10% for LP and 20% for NG... -
Page 5: Unit Capabilities
The figures given above are for an average load such as a UNIT CAPABILITIES blower or fan. If the electric motor is connected to a hard Generator Connections - The diagram below represents a starting load such as an air compressor, it will require more typical 5500 watt generator. -
Page 6: Unit Preparation
UNIT PREPARATION Model BCI Group Capability (minimum) Before your engine generator was shipped from our factory HPS6000HE 235 CCA it was fully checked for performance. The generator was HPS9000E 235 CCA load tested to its full capacity, and the voltage and... -
Page 7: Battery Charging
oil level in the crankcase can fall below a safe limit, the Oil DANGER – Explosive Fire Risk Alert system will automatically shut down the engine (the engine switch will remain in the ON position). Never smoke when near batteries Do not cause a flame or spark in the battery area GASOLINE FUEL Always discharge static electricity from your body... -
Page 8: Installing The Fuel Line
incorrect fuel pressure. Power and performance of the INSTALLING THE FUEL LINE engine is in direct relation to the correctness of the fuel system. Shown below is a block diagram of a typical L.P. DANGER: PERSONAL INJURY or N.G. installation. Units that are intended to be run unattended MUST have an electric fuel solenoid installed. -
Page 9: Tank Sizing
3. If you are using LP or NG besure the fuel is turned Temp 60 deg f. 30 deg f. 0 deg f. -20 deg f. on and all connection are tight. HPS6000HE 40 gal 50 gal 125 gal 350 gal HPS9000E 70 gal... -
Page 10: Starting Hints
1. Turn on the fuel supply. doesn’t deteriorate and clog the fuel system. Note: 2. Move the choke to the full "on" position. A warm The use of a fuel additive, such as STA-BIL, or an engine will require less choking than a cold engine. equivalent, will minimize the formation of gum 3. -
Page 11: Connecting The Loads
CONNECTING THE LOADS MODEL NEMA SPEC SIZE WINCO FOR PLUG PART # Applying The Load HPS6000HE L14-30P 30 AMP 64492-000 HPS9000E L14-30P 30 AMP 64492-000 Allow the engine to warm up for two or three minutes before HPS12000HE L14-30P 30 AMP 64492-000 applying any load. -
Page 12: Operator Care And Maintenance
Many homes and construction sites are wired for at least 60 2. Checking the Oil Level: The oil level must always be to 100 Amp entrance service, much greater than the capacity checked before the engine is started. Take care to of these portable generators. -
Page 13: Cleaning
2. Generator Maintenance - Any major generator TROUBLESHOOTING HINTS service including the installation or replacement of parts should be performed only by a qualified PROBLEM (SYMPTOMS) POSSIBLE CAUSES electrical service technician. USE ONLY FACTORY —————————————————————————— APPROVED REPAIR PARTS. Won’t Start *Low Oil Level. - Page 14 DATE ITEM WORK PERFORMED 6190-00 Page 12 60707-115...
-
Page 15: Warranty
24 MONTH Limited Warranty WINCO warrants to the original purchaser that the alternator is free from defects in workmanship and material for a period of two years*, provided it is installed, operated and maintained in accordance with WINCO written instructions. *NOTE: Units used for rental, demonstrations, commercial or prime power applications such as construction or utility, are warranted for 90 days. - Page 16 225 S. Cordova Ave. Phone (507) 357-6831 LeCenter, Mn 56057 FAX - (507) 357-4857 www.wincogen.com...
Need help?
Do you have a question about the Home power HPS6000HE and is the answer not in the manual?
Questions and answers