Page 1
PORTABLE GENERATOR yEAR MODEL NUMBER 40026 LIMITED WARRANTY 10006 Santa Fe Springs Road sAvE THEsE INsTRuCTIONs Santa Fe Springs CA 90670 Important Safety Instructions USA / 1 (877) 338-0999 MADE IN CHINA are included in this manual. REV 40026-20101025 www.championpowerequipment.com...
Page 2
Have questions or need assistance? Do not return this product to the store! WE ARE HERE TO HELP! Visit our website: www.championpowerequipment.com for more info: • Product Info & Updates • Tech Bulletins • Frequently Asked Questions • Product Registration –...
ENGLISH INTROduCTION Introduction Accessories Congratulations on your purchase of a Champion Champion Power Equipment manufactures and sells Power Equipment generator . CPE designs and builds accessories designed to help you get the most from generators to strict specifications . With proper use and your purchase .
. Please call our help line at 1 (877) 338-0999 situation which, if not avoided, could result in death or serious injury . CAuTION CAUTION indicates a potentially hazardous situation which, if not avoided, may result in minor or moderate injury . REV 40026-20101025...
Keep hands and feet away from rotating parts . combustible materials . Tie up long hair and remove jewelry . Operate equipment with guards in place . DO NOT wear loose-fitting clothing, dangling drawstrings or items that could become caught . REV 40026-20101025...
Page 7
A spark arrestor may be required . The operator DO NOT use the generator if: should contact local fire agencies for laws or – Electrical output is lost regulations relating to fire prevention requirements . – Equipment sparks, smokes or emits flames – Equipment vibrates excessively REV 40026-20101025...
Choke – Used to start the engine . Oil Filler Cap – Check and fill engine oil level . Air Cleaner – Protects the engine by filtering dust and debris from the intake air . Power Panel – See “Power Panel” . REV 40026-20101025...
Intelligauge . up to 20 Amps 0r 2400 Watts of power . 120V / 30A Twist-Lock – Protected by a 25 Amp Ground Terminal – Consult an electrician for local Flip-to-reset circuit breaker . This receptacle grounding regulations . REV 40026-20101025...
. DO NOT over tighten the lock nuts . 3 . Slide the bolt through the mount point on the frame . 4 . Fasten securely with the Mx10 nut . 5 . Repeat steps 2-4 to attach the second wheel . REV 40026-20101025...
. 4 . Check engine oil level daily and add as needed . CAuTION The engine is equipped with a low-oil-shutoff and will stop when the oil level in the crankcase falls below the threshold level . REV 40026-20101025...
DO NOT fill fuel tank indoors . DO NOT fill fuel tank when the engine is running or hot . DO NOT overfill the fuel tank . DO NOT light cigarettes or smoke when filling the fuel tank . REV 40026-20101025...
If the generator will be connected to a building electrical system, consult your local utility company or a qualified electrician . Connections must isolate generator power from utility power and must comply with all applicable laws and codes . REV 40026-20101025...
6 . Dispose of used oil at an approved waste excess oil . management facility . 6 . Place the fi lter in the assembly . 7 . Reattach the air fi lter cover and snap in place . REV 40026-20101025...
Contact our help line at 1 (877) 338-0999 to locate the 4 . Carefully remove the carbon deposits from the spark nearest Champion Power Equipment certified service arrester screen with a wire brush . dealer for your generator or engine maintenance needs .
. Crank the engine slowly to distribute the oil and lubricate the cylinder . 8 . Reattach the spark plug . 9 . Store the unit in a clean, dry place out of direct sunlight . REV 40026-20101025...
10% by volume . Use 4-Cycle automotive oil . Oil capacity is 0 .63 qt qt (0 .6 L) . Please reference the following chart for recommended oil types for use in the generator . REV 40026-20101025...
Management” Faulty cords or device Check for damaged, bare or frayed wires . Replace defective device for further technical support: Technical Service Mon – Fri 8:30 AM – 5:00 PM (PST/PDT) Toll Free: 1 (877) 338-0999 tech@championpowerequipment .com REV 40026-20101025...
. Warranty Qualifications Other Exclusions Champion Power Equipment (CPE) will register this This warranty excludes: warranty upon receipt of your Warranty Registration Card – Cosmetic defects such as paint, decals, etc .
Environment Protection Agency (u.s. EPA.) Emission Control system Warranty Your Champion Power Equipment (CPE) engine complies with U .S . EPA emission regulations . yOuR WARRANTy RIGHTs ANd OBLIGATIONs: The US EPA AND CPE are pleased to explain the Federal Emission Control Systems Warranty on your 1997 and later small off-road engine .
Page 26
ECS Warranty and shall be sufficient grounds for disallowing an ECS Warranty claim . CPE shall not be liable hereunder for failures of any warranted parts of a CPE engine caused by the use of such an unapproved add-on or modified part . REV 40026-20101025...
Page 27
Champion Power Equipment dealer who is authorized by Champion Power Equipment, Inc . to sell and service that CPE product during his normal business hours . Claims for repair or adjustment found to be caused solely by defects in material or workmanship will not be denied because the engine was not properly maintained and used .