Table of Contents
Advertisement
Tribute
Model (8040)
Woodstove
OWNER'S MANUAL
INSTALLATION
&
OPERATING
INSTRUCTIONS
PLEASE READ THIS ENTIRE OWNER'S MANUAL BEFORE YOU INSTALL AND USE
YOUR NEW Tribute WOOD STOVE. To reduce the risk of fire, follow the installation
instructions. Failure to follow these instructions may result in property damage,
bodily injury, or even death.
Never Burn Manufactured Wood Products in this Stove! Use Cord Wood Only.
SAVE THESE INSTRUCTIONS FOR FUTURE REFERENCE!
CONTACT LOCAL AUTHORITIES HAVING JURISDICTION (BUILDING DEPARTMENT or FIRE
OFFICIALS) ABOUT PERMITS REQUIRED, RESTRICTIONS AND INSTALLATION INSPECTION IN
YOUR AREA.
Tribute Model # 8040
Manual: 6400-40447
R: 12/18/12
Advertisement
Table of Contents
Troubleshooting
Related Manuals for HearthStone Tribute 8040
Summary of Contents for HearthStone Tribute 8040
- Page 1 Tribute Model (8040) Woodstove OWNER'S MANUAL INSTALLATION & OPERATING INSTRUCTIONS PLEASE READ THIS ENTIRE OWNER’S MANUAL BEFORE YOU INSTALL AND USE YOUR NEW Tribute WOOD STOVE. To reduce the risk of fire, follow the installation instructions. Failure to follow these instructions may result in property damage, bodily injury, or even death.
- Page 2 Intentionally Blank Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040...
-
Page 3: Table Of Contents
EMOVAL ..............................21 ................................21 TONE ................................ 22 ASKETS ................................22 LASS TROUBLESHOOTING ......................24 ..........................25 ROUBLESHOOTING UIDE REPLACEMENT PARTS & OPTIONAL ACCESSORIES ............ 26 SAFETY LABEL ........................27 Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040... -
Page 4: Introduction
Hearthstone family with our Premier SAFETY NOTICE: A HOUSE FIRE MAY RESULT IF Soapstone Wood-Burning Stove. -
Page 5: Safety And Good Practices
Empty ashes from the firebox sooner if the chimney, as recommended. firebox begins to fill up. Follow these safety precautions: Never modify this stove in any way, especially the primary air control system. Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040... -
Page 6: Emergency Procedures
(Refer to page 22.) To enhance the combustion efficiency and reduce At the End of Every Season: the emissions of the fire in your stove Hearthstone Dismantle the chimney connector and clean it QHHP, Inc. has developed an advanced THERMO- thoroughly. -
Page 7: Specifications
Polished gray soapstone is a natural product and will vary from stone to stone. Various amounts of gray, charcoal, blue and green will be evident according to the natural composition of the stone. Figure 1 Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040... -
Page 8: Installation
2” (51 mm) If you use a close clearance connector pipe, it must beyond each side. be tested to UL standards and listed. Check the Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040... - Page 9 If the overall R-value of your setup is greater than the R-value of the specified floor protector, then your According to Intertek Testing Services, Inc. setup is acceptable. According to ASHRAE Handbook of Fundamentals 1977 Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040...
-
Page 10: Outside Air Supply
¼” x ¼” mesh rodent screen and be covered with a rain/wind proof hood (flex pipe, Figure 3: Door Handle Detail outside termination, mesh, and hood supplied by others) Contact your dealer for availability). Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040... -
Page 11: Clearances T O Combustibles
Single wall stove pipe with heat shield 27.5 5 22.5 59.75 Double wall pipe w/ optional heat shield 10 13 27.5 5 18.5 Figure 5: Tribute 8040 Allowable Minimum Alcove Clearances Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040... - Page 12 Figure 6: Tribute 8040 Fireplace Mantle and Trim Minimum Clearances Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040...
- Page 13 Figure 7: Chimney Connector Clearances Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040...
-
Page 14: Venting Components And Configuration
6" (152 mm) well as allow you to easily dismantle the stovepipe diameter, 24 MSG or 25 MSG blued steel connector pipe. Do not use aluminum or Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040... -
Page 15: Connecting Your Woodstove
An exterior chimney’s draft is not as strong and may Figure 8: Typical Masonry Fireplace Connection experience increased creosote accumulation. Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040... - Page 16 Minimum thickness of 5/8" (16 mm). feet (4 m). The maximum allowable chimney height Installed with refractory mortar. is 30 feet (9m). At least 1" (25 mm) air space. Figure 9: Chimney Height Requirements Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040...
- Page 17 Figure 10: Typical Allowable Chimney Configurations Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040...
-
Page 18: Installing I N A Mobile Home
WARNING: DO NOT INSTALL IN A SLEEPING ROOM CAUTION: MAINTAIN STRUCTURAL INTEGRITY OF THE MOBILE HOME WALLS, FLOOR, CEILING, AND ROOF WHILE YOUR STOVE IS INSTALLED AND IN USE. Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040... -
Page 19: Operation
IREWOOD Juniper, Rocky Mtn 3,150 21.8 Burn only natural firewood (known as cordwood) Elm, Red 3,112 21.6 in the Tribute 8040 Woodstove. This stove is not Coffeetree, Kentucky 3.112 21.6 designed, or certified to burn other fuels. Hackberry 3,247 20.8... -
Page 20: Buildinga Fire
Avoid the following conditions that can cause the position. Pull lightly on the door handle to ensure it soapstone or cast iron pieces to break: is properly latched. Do not throw wood into the stove. Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040... -
Page 21: Normal Operation
A good hot fire will reduces smoking time and will bring fresh fuel clean it. We recommend a visual inspection up to a high temperature rapidly. Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040... -
Page 22: Burn Rate
It is recommended that the blower is not turned on for the first 30 minutes of operation. Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040... -
Page 23: Removal And Disposal O F Ashes
Do not place any other items or ashes can remain hot for several days once trash into the metal container. Replace the lid on removed from the firebox. Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040... -
Page 24: Maintenance
Contact your dealer dealer for service. for the name of a certified chimney sweep in your area (your dealer may be a certified sweep!). Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040... -
Page 25: Gaskets
Do not use any replacement glass other than the 5mm thick ceramic glass manufactured and supplied for use in this woodstove. Replacement glass is available through your local dealer. Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040... - Page 26 3. Apply penetrating oil to the screws in the glass retainer clips. Remove the screws to 7. Screw the glass retainer clips (6) back on separate the glass from the door. the door. 8. Install the door. Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040...
-
Page 27: Troubleshooting
– especially if a reverse draft within the building can be exacerbated if exhaust has established in the chimney. fans, such as clothes dryers, bathroom fans or Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040... -
Page 28: Troubleshooting Guide
Do not over-fire the stove. Monitor stove temperatures. ENAMEL Use seasoned wood only. CASTING Excessive Draft Check the DRAFT. A damper may be required. Operate the stove at a LOW BURN range. Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040... -
Page 29: Replacement Parts & Optional Accessories
Enamel, 2061 for Seafoam Enamel, 2081 for Moss Enamel, and 2083 for Basil Enamel. Stove finish offerings will vary by stove model. Tribute Woodstove Model 8040. Manufactured and Warranted by: Hearthstone Quality Home Heating Products, Inc. 317 Stafford Ave, Morrisville, VT 05661 www.hearthstonestoves.com inquiry@hearthstonestoves.com Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040... -
Page 30: Safety Label
SAFETY LABEL Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040... - Page 31 Hearthstone Quality Home Heating Products, Inc. Warranty Department 317 Stafford Avenue Morrisville, VT 05661 NOTE: SENDING IN THE SIGNED WARRANTY REGISTRATION FORM IS NOT REQUIRED AS A CONDITION OF WARRANTY COVERAGE OR HEARTHSTONE’S PERFORMANCE. Hearthstone Quality Home Heating Products, Inc. ® Tribute Model 8040...