Lincoln Electric 2100 Datasheet

M A T E R I A L S A F E T Y D A T A S H E E T
Conforms to Workplace Hazardous Materials Information System (WHMIS) Rev. November, 1988
The Lincoln Electric Company of Canada LP
179 Wicksteed Avenue
Toronto, Ontario M4G 2B9 CANADA
Phone: (416) 421-2600
I M P O R T A N T !
This section covers the materials from which this product is manufactured. The fumes and gases produced during welding with the normal use of this
product are covered by Section VII; see it for industrial hygiene information.
CAS Number shown is representative for the ingredients listed. All ingredients listed may not be present in all sizes.
(1) The term "hazardous" in "Hazardous Ingredients" should be interpreted as a term required and defined in the Hazardous Products Act and does not
necessarily imply the existence of any hazard.
Ingredients:
Mineral silicates
Titanium dioxides (as Ti)
Chromium and chromium alloys or compounds (as Cr)
Limestone and/or calcium carbonate
Silicates and other binders
Iron oxides (as Fe)
Manganese and/or manganese alloys and compounds (as Mn)
Fluorides (as F)
Quartz
Niobium alloys (as Nb)
Iron
Cobalt
Molybdenum alloys (as Mo)
Lithium compounds (as Li)
Stainless steel core wire
Nominal core wire composition:
Chromium
Nickel
Molybdenum (316 type only)
Manganese
Iron
Notes:
(*) Not listed. Nuisance value maximum is 10 milligrams per cubic
meter. TLV value for iron oxide is 5 milligrams per cubic meter.
(**) As respirable dust.
(#) Crystalline silica (quartz) is on the IARC (International Agency for
Research on Cancer) and NTP (National Toxicology Program) lists
as posing a carcinogenic risk to humans.
Physical data such as odor, vapor pressure, density, evaporation rate and freezing or boiling points are not listed as they are not applicable to
this product and its use.
Non Flammable; Welding arc and sparks can ignite combustibles and flammable products. See CSA W117.2 Section 9.7 as referenced in
Section VIII. Product is inert, no special handling or spill procedures required.
Rev 11/06b
For Welding Consumables and Related Products
Section I & II - Preparation and Product Information
Section III - Hazardous Ingredients (1)
(347 type only)
(316 type only)
Section IV - Physical Data
Section V - Hazard Data
Date:
11/15/06
Trade Name:
Blue Max Manual Electrodes
Sizes: All
Supersedes: 10/8/04
Covered Electrode
Product Type:
Blue Max
Products:
Prepared by The Lincoln Electric Company, Cleveland, Ohio, USA
(216) 481-8100, on the date shown above.
TLV
CAS No. Wt. % mg/m
1332-58-7 5-10
13463-67-7 5-10
7440-47-3 1-5 0.5(b)
1317-65-3 1-5
1344-09-8 1-5
65996-74-9 1-5
7439-96-5 0.1-1
7789-75-5 0.1-1
14808-60-7 0.1-1 #0.05**
7440-03-1 0.1-1
7439-89-6 0.1-1
7440-48-4 0.1-1
7439-98-7 0.1-1
554-13-2 0.1-1
60-100
7440-47-3 20-30 0.5(b)
7440-02-0 10-13
7439-98-7 2.5
7439-96-5 2.0
7439-89-6 bal.
(LDLo, LCLo) Lowest published toxic concentration.
(b) The OSHA PEL for chromium (VI) is 5 micrograms (0.005
milligrams) per cubic meter. The TLV for water soluble
chromium (VI) is 0.05 milligrams per cubic meter and the
TLV for insoluble chromium (VI) is 0.01 milligrams per
cubic meter.
MSDS No.:
CAN-M460-C
308/308L AC-DC, 309/309L AC-DC,
316/316L AC-DC, 347 AC-DC, 2100
LD
50
3
(Route/Species)
590 g/kg LDLo
5**
(oral/rat) reproductive
10
Not Available
2.16 mg/kg LDLo
(intravenous/rat)tumorigenic
10
Not Available
1153 mg/kg
10*
(oral/rat)
5
Not Available
9 g/kg
0.2
(oral/rat)
4250 mg/kg
2.5
(oral/rat)
200 mg/kg LDLo
(intratracheal/rat)
10*
Not Available
10*
Not Available
6170 mg/kg
.02
(oral/rat)
114 mg/kg LDLo
10
(intraperitoneal/rat)
4111 mg/kg LDLo
10*
(oral/human)
2.16 mg/kg LDLo
(intravenous/rat)tumorigenic
50 mg/kg LDLo
1.5
(intravenous/mouse)
114 mg/kg LDLo
10
(intraperitoneal/rat)
9 g/kg
0.2
(oral/rat)
10*
Not Available
(CONTINUED ON SIDE TWO)
3
LC mg/m
50
(Route/Species)
Not Available
Not Available
Not Available
Not Available
Not Available
Not Available
2.3 LCLo
(inhalation/human)
Not Available
300 LCLo
(inhalation/human)
Not Available
Not Available
Not Available
Not Available
Not Available
Not Available
Not Available
Not available
2.3 LCLo
(inhalation/human)
Not Available