Table of Contents
Advertisement
IMPORTANT
IMPORTANT
SCAN THE QR CODE OR VISIT THE
WEBSITE TO VIEW THE MOST RECENT
VERSION OF THE MANUAL
WWW.MONTIGO.COM/PRODUCT-GUIDES
WARNING:
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly could result in serious injury,
death, or property damage.
— Do not store or use gasoline or other flammable vapors and
liquids in the vicinity of this or any other appliance.
— WHAT TO DO IF YOU SMELL GAS
•
Do not try to light any appliance.
•
Do not touch any electrical switch; do not use any
phone in your building.
• Leave the building immediately.
• Immediately call your gas supplier from a neighbour's
phone. Follow the gas supplier's instructions.
• If you cannot reach your gas supplier, call the fire
department.
— Installation and service must be performed by a qualified
installer, service agency or the gas fitter.
DANGER
HOT GLASS WILL CAUSE BURNS.
DO NOT TOUCH GLASS UNTIL
NEVER ALLOW CHILDREN
A barrier designed to reduce the risk of burns
from the hot viewing glass is provided with this
appliance and must be installed for the protection
of children and other at-risk individuals.
Installation & Maintenance Manual
C
COOLED.
TO TOUCH GLASS.
DelRay Square
INDOOR DIRECT VENT GAS FIREPLACE
DRSQ42NI
DRSQ42LI
DRSQ42NI-2
DRSQ42LI-2
®
Installation and service must be performed by a qualified installer,
US
service agency or the gas fitter. Check local codes and read all
FOR THE MOST RECENT VERSION OF THIS MANUAL PLEASE VISIT
WWW.MONTIGO.COM/PRODUCT-GUIDES
Installer: Leave this manual with the appliance. Please refer to the
Montigo website for the most current version of the fireplace manual
Consumer: Retain this manual for future reference. Please refer to the
Montigo website for the most current version of the fireplace manual
Some materials used in the manufacturing process of this product can
expose you to Benzene which is known in the State of California to
cause cancer and birth defects or other reproductive harm. For more
information go to www.P65warnings.ca.gov
DRSQ46NI
DRSQ46LI
DRSQ46NI-2
DRSQ46LI-2
instructions prior to installation.
NOTICE
WARNING
XG0232 - 043021
Advertisement
Table of Contents
Related Manuals for Montigo DelRay Square DRSQ46NI-2
Summarization of Contents
Safety Alert Key
Introduction
Overview of the fireplace and manual, emphasizing safety.
Unit Specs and Efficiency
Details on fireplace models, BTU, and energy efficiency ratings.
Section A: Before You Begin
Installation Checklist
Pre-installation steps and checks required before starting the fireplace setup.
Section 1: Dimensions
DelRay Square 42 Dimensions
Detailed measurements and diagrams for the DRSQ42 fireplace model.
DelRay Square 46 Dimensions
Detailed measurements and diagrams for the DRSQ46 fireplace model.
Section 2: Framing
Wall framing Dimensions
Guidelines for framing openings for fireplace installation, including diagrams.
Recommended flooring considerations
Advice on selecting and installing flooring near the fireplace for heat resistance.
Elevated surface temperatures
Vented installation (Cool Wall Release)
Temperature data for vented installations to manage surface heat.
Recess installation
Guidelines for recessing the fireplace and managing surrounding temperatures.
Section 3: Venting
Clearances
Required safety clearances for combustible materials around the fireplace venting.
Section 3-3: Installing a Wall Mounted Termination
Procedure for installing wall-mounted direct vent terminations.
Section 3-1: Converting top/rear vent
Instructions for changing the vent configuration from top to rear.
Flexmaster as alternate venting
HORIZONTAL FLEX RUN REQUIREMENTS
Specifications for installing horizontal Flexmaster vent runs.
Section 4: Wiring
DRSQ (N/L) I Wiring Diagram
Wiring schematic for basic DRSQ models with SIT Proflame ignition.
DRSQ (N/L) I-2 Wiring Diagram
Wiring schematic for full load DRSQ models with SIT Proflame ignition.
Section 5: Installing the gas line
Gas Pressure
Required gas pressures for natural gas and propane operation.
Section 5-3: GAS CONNECTION
Steps for connecting the gas line to the fireplace unit.
Section 6: Finishing
DRSQ42, DRSQ46 Mantels
Guidelines for installing mantels around the fireplace opening.
Sidewall clearances
Required clearances to combustible materials on the sides of the fireplace.
Cement Board Install
STONE FACINGS
Recommendations for using stone facings around the fireplace to avoid cracking.
Section 8: Removing & Installing the Screen / Door
Removing the door
Step-by-step instructions for safely removing the fireplace door.
Reinstalling the door
Step-by-step instructions for safely reinstalling the fireplace door.
Section 9: Installing the Accessories
Installing glass media
Instructions for placing decorative glass media in the fireplace.
Installing a contemporary scene (glass and stone)
Guidance for arranging glass and stone for optimal flame appearance.
Remote Operation (Full Load Units)
Initializing the System for the first time
Steps to set up and initialize the Proflame 2 remote control system.
Remote-Flame Control
How to adjust the main burner flame height using the remote control.
Room Thermostat (Remote Control Operation)
Using the remote control as a room thermostat to regulate fireplace operation.
LIGHTING INSTRUCTIONS
TO TURN OFF GAS TO APPLIANCE
Procedure for safely shutting off the gas supply to the fireplace.
Section 10: Cleaning and Maintenance
General
Overview of yearly inspection requirements for safe fireplace operation.
Pilot Burner Adjustment
Procedure for adjusting the pilot flame size for optimal performance.
POD - Pilot on Demand
Remote Continuous Pilot (CPI) Selection
Instructions for enabling or disabling continuous pilot ignition mode.
Indoor fireplace in protected outdoor applications
See through fireplace
Guidelines for installing see-through fireplaces in protected outdoor locations.
Appendix B: Warranty
Appendix B: Warranty Continued
Further details on warranty coverage, exclusions, and claims process.
Need help?
Do you have a question about the DelRay Square DRSQ46NI-2 and is the answer not in the manual?
Questions and answers