Table of Contents
Advertisement
Quick Links
WL22000VE/B
WL22000VE/C
WL22000VE-03/B
WL22000VE-03/C
WL25000VE-03/A
INSTALLATION & OPERATORS
MANUAL
COPY YOUR MODEL AND SERIAL NUMBER HERE
No other WINCO generator has the same serial number as
yours. If you should ever need to contact us concerning this
unit, it will help us to respond to your needs faster.
MODEL
SERIAL NUMBER
16200-011
PURCHASE DATE
DEALER NAME
DEALER PHONE #
www.wincogen.com
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Winco WL25000VE-03/A
Summary of Contents for Winco WL25000VE-03/A
- Page 1 MANUAL COPY YOUR MODEL AND SERIAL NUMBER HERE No other WINCO generator has the same serial number as yours. If you should ever need to contact us concerning this unit, it will help us to respond to your needs faster.
-
Page 2: Table Of Contents
TABLE OF CONTENTS SAFETY INFORMATION SAVE THESE INSTRUCTIONS SPECIFICATIONS GENERATOR ENGINE INTRODUCTION TESTING POLICY Rated output of generator is based on engineering tests of typical units, and is subject to, and limited by, the temperature, altitude, fuel, and other conditions specified by the manufacturer of applicable engines. INTENDED USES RESTRICTED USES UNIT CAPABILITIES... -
Page 3: Safety Information
SAFETY INFORMATION WARNING: FIRE HAZARD Gasoline and other fuels present a hazard CALIFORNIA PROPOSITION 65 of possible explosion and/or fire. A. Do not refuel when the engine is running or This product contains crude oil, gasoline, diesel fuel hot. and other petroleum products, Antifreeze to which B. -
Page 4: Save These Instructions
Read and understand all instructions in the manual before starting and operating the generator. USING THIS MANUAL Congratulations on your choice of a WINCO generator. You have selected a high-quality, precision-engineered generator designed and tested to give you years of satisfactory service. -
Page 5: Specifications
SPECIFICATIONS GENERATOR GENERATOR Model WL25000VE-03/A Model WL22000VE/B Surge Watts 24,960 WL22000VE/C Continuous Watts 20,000 Surge Watts 22,000 Volts 120/240 Continuous Watts 19,000 Amps 208/104 Volts 120/240 Generator Manufacturer Mecc Alte Amps 166.6/83.3 Generator Model Number AME3 Generator Manufacturer Mecc Alte... -
Page 6: Introduction
INTRODUCTION TESTING POLICY Before any generator is shipped from the factory, it is fully checked for performance. The generator is loaded to its full capacity, and the voltage, current, and frequency are carefully checked. Rated output of generator is based on engineering tests of typical units, and is subject to, and limited by, the temperature, altitude, fuel, and other conditions specified by the manufacturer of applicable engines. -
Page 7: Unit Capabilities
UNIT CAPABILITIES GENERATOR CONNECTIONS WL22000VE: 120 Volt and 240 Volt receptacles are provided for connection to various loads. The following diagram represents this 19,000 watt (rated output) generator. A & B represent the 120 volt output legs of this generator. Up to 9500 watts at 120 volts (79 Amps) can be drawn from the receptacles attached to either A or B output legs. -
Page 8: Preparing The Unit
If any damage is noted, it is always easiest to shutdown system is designed to prevent severe damage refuse the shipment and let WINCO take care of the freight caused by an insufficient amount of oil in the crankcase. -
Page 9: Battery Installation
BATTERY INSTALLATION This engine generator set is shipped with a bungee cord for installation of the customer supplied battery in the unit’s WARNING battery tray. 1. Never smoke when near batteries. 2. Do not cause a If you intend to use the unit’s electric start system, you will flame or spark in the battery area. -
Page 10: Initial Start Up
INITIAL START UP STARTING HINTS 1. COLD WEATHER WARNING: PERSONAL INJURY A. Use the proper oil for the temperature expected. B. Use fresh winter grade fuel. Winter grade gasoline is Improper maintenance, or failure to fix any problems during blended to improve starting. Do not use summer grade operation, could cause equipment damage and possible gasoline. -
Page 11: Connecting The Loads
DO NOT operate this unit inside a home Your WINCO portable generator ships with a bonded or garage, near vents or windows, or anywhere neutral. You can safely use this generator without external carbon monoxide gas could accumulate. - Page 12 must be installed. The transfer switch must be compatible with GFCI protected generators. WINCO recommends Reliance manual transfer switches. The transfer switch prevents damage to the generator and the other circuit components if main line power is restored while the...
-
Page 13: Yourgen
For normal usage, the speed setting should The WINCO YourGen meter allows you to see useful not be changed. If the generator is being run continuously information about your generator from the front panel... - Page 14 120 Volt and 120/240 Volt receptacles are provided for spark plug wire and then open the receptacle panel. Locate connection to various loads. the backside of the YourGen meter. Gently pry the back plate off using the slot located on top. The following diagram represents this 19,000 watt (rated output) generator.
-
Page 15: Engine Care
and the retainer Outdoor temperatures determine the proper oil viscosity for 3. Remove the air filter the engines. Winco recommends our 5W-30 fully synthetic oil to give you excellent protection in cold temperatures 4. Remove the pre-cleaner while maintaining excellent performance in warmer weather from the air filter... -
Page 16: Spark Plug
SPARK PLUG Replace annually or every 300 hours of operation. Always replace with the same spark plug that came in the engine and check gap before installing. Spark plug gap is 0.030”. Poor spark will also occur if spark plug wire does not fit firmly on spark plug. -
Page 17: Generator Care
GENERATOR CARE AVR WIRING AUTOMATIC VOLTAGE REGULATOR Proper care and maintenance of the generator is necessary to ensure a long trouble free life. The following is a list of connections on the AVR. These EXERCISING THE GENERATOR have been factory set and other than voltage adjustment, should never be changed. -
Page 18: Troubleshooting
2020 generator. In California, new equipment that uses small off-road engines must be designed, built, and equipped to meet the State’s stringent anti-smog standards. WINCO must warrant the evaporative emission control system on your generator for the period listed below provided there has been no abuse, neglect or improper maintenance of your equipment leading to the failure of the evaporative emission control system. -
Page 19: Receptacle Wiring Diagram
RECEPTACLE WIRING DIAGRAM WL22000VE/B, WL22000VE/C, WL22000VE-03/B OPM-140/H... -
Page 20: Receptacle Wiring Diagram
RECEPTACLE WIRING DIAGRAM WL22000VE-03/C OPM-140/H... -
Page 21: Ca Evap Emission Control
RECEPTACLE WIRING DIAGRAM WL25000VE-03/A OPM-140/H... -
Page 22: Limited Warranty
Air cooled units purchased for stock have 1 year to be sold. The warranty to the original retail customer commences on the date of sale of the product to them. All liquid cooled units have 180 days from the Winco invoice to submit a start up date. If no startup form is submitted, then warranty period starts on the Winco invoice date unit was sold. -
Page 23: General Information
Note 2: 3rd Year warranty coverage is parts only/no labor. Note 3: Round trip mileage is limited to 200 miles per trip and a total of 2 trips per repair unless authorized in writing by the WINCO Service Dept. - Page 24 225 S. CORDOVA AVE • LE CENTER, MN 56057 Sales: 507-357-6821• sales@wincogen.com Service: 507-357-6831 • service@wincogen.com www.wincogen.com OPM-140/H...
Need help?
Do you have a question about the WL25000VE-03/A and is the answer not in the manual?
Questions and answers