Volkswagen PASSAT 2004 Owner's Manual page 48

SERVICE SCHEDULE
Service at 40,000 miles (64,000 km) - continued
1
Air cleaner: Replace filter element
1
Cooling system: Check coolant level; add if necessary
1
Dust and pollen filter (where applicable): Replace
1
Ribbed belt: Check condition
1
Power Steering: Check fluid level
1
Drive shafts: Check boots
1
Front axle: Check dust seals on ball joints. tie rod ends; check tie rods
1
On-Board diagnostic system: Check fault memory; purge if necessary
1
Roof frame: Clean and lubricate
1
Automatic transmission: Check ATF
1
Rear spoiler: Lubricate (New Beetle only)
1
Airbag system: Visual check every 12 months regardless of mileage (kilometres)
1
Road test: Check kickdown. braking, steering, heating and ventilation. air condition-
ing, power accessories and electrical systems
1
12V starter and auxiliary battery: check (where applicable)
1
Convertible top: Check function and check roll-over protection with convertible top
open (New Beetle Convertible only)
Next Service:
Date: .......... . ......... . .. . .
Miles/ km: ..... . .. . . . .... . .. . .
whichever occurs first
Today's date and
Volkswagen Dealer stamp
13