Subscribe to Our Youtube Channel
Related Manuals for Tufline LAND PLANES LP2-84
Summary of Contents for Tufline LAND PLANES LP2-84
- Page 1 O P E R A T O R ' S M A N U A L LAND PLANES LP2-84S LP2-84 LP2-96S LP2-96 LP2-120S LP2-120 LP2-144S LP2-144 LP2_15812_05/11...
- Page 2 Use only genuine Tufline service parts. Substitute parts will void the warranty and may not meet stan- dards required for safe and satisfactory operation. Record the model number and serial number of your...
-
Page 3: Table Of Contents
TABLE OF CONTENTS INTRODUCTION / GENERAL INFORMATION......... . ii SPECIFICATIONS. -
Page 4: Introduction / General Information
SPECIFICATIONS Model # Width Weight LP2-84 7’ 785# LP2-96 8’ 895# LP2-120 10’ 955# LP2-144 12’ 1225# Model # Width # Of Weight Shanks LP2-84S 7’ 825# LP2-96S 8’ 955# LP2-120S 10’ 1035# LP2-144S 12’ 1325# GENERAL INFORMATION The purpose of this manual is to assist you your particular situation. -
Page 5: Safety & Instructional Decals
SAFETY & INSTRUCTIONAL DECALS ATTENTION! BECOME ALERT! YOUR SAFETY IS INVOLVED! FAILURE TO FOLLOW THESE INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH Check that all safety decals Replace Decals Immediately If Damaged! are installed and in good con- dition. Replace if decals are worn or damaged. -
Page 6: Safety Rules
SAFETY RULES ATTENTION! BECOME ALERT! YOUR SAFETY IS INVOLVED! Safety is a primary concern in the design and Wear sturdy, rough-soled work shoes and protec- manufacture of our products. Unfortunately, our tive equipment for eyes, hair, hands, hearing, efforts to provide safe equipment can be wiped out and head;... - Page 7 SAFETY RULES ATTENTION! BECOME ALERT! YOUR SAFETY IS INVOLVED! OPERATION (cont’d) Always operate down slopes; never across the blocked and secured. Never place any part of face. the body underneath equipment or between • Use extreme care and reduce ground speed on moveable parts even when the engine has been slopes and rough terrain.
- Page 8 SAFETY RULES ATTENTION! BECOME ALERT! YOUR SAFETY IS INVOLVED! MAINTENANCE(cont’d) chart specifications. Check that the equipment is properly attached to the power source and Failure to do so can cause serious injury or that the equipment is in a safe condition before death.
-
Page 9: Dealer Instructions 6
DEALER INSTRUCTIONS Pre-Assembly ____It is important for the dealer to visually check and make sure all parts are in tact prior to Top Link Mast Assembly delivery to customer. ____ Show customer the safe, proper proce- Reference Figure 6 (Pg. 13). dures to be used when mounting, dismounting, The top link mast should be centered evenly and storing equipment. -
Page 10: Operation
Operation • NEVER GO UNDERNEATH EQUIPMENT. Safety is a primary concern in the design and manufacture of our products. Unfortunately, our Never place any part of the body underneath efforts to provide safe equipment can be wiped equipment or between moveable parts even out by an operator’s single careless act. - Page 11 Connecting Land Plane to the Tractor LP2-84, LP2-84S, Top Link Bushing LP2-96 & LP2-96S The LP2-84, LP2-84S, LP2-96 & LP2-96S are compatible with tractors equipped with Category 1 or Category 2, 3-point hitch systems that use side-swing type lower lift arms. These Land Planes will fit Category 1, and Category 2 Quick Hitch systems.
- Page 12 Connecting Land Plane to the Tractor (cont’d.) Replacing Cutting Edge Category 2 Standard (Page 9,Figure 3) LP2-120, LP2-120S, LP2-44 & LP2-144S To service the land plane when attached to the tractor, it must be blocked up off the ground. 1. Use Category 2 Standard instructions except use lower set of holes.
-
Page 13: Owner Service 10
Owner Service WARNING WARNING • Keep all persons away from operator control • NEVER GO UNDERNEATH EQUIPMENT. area while performing adjustments, service, or Never place any part of the body underneath maintenance. equipment or between moveable parts even • Before dismounting power unit or performing when the engine has been turned off. -
Page 14: Parts Catalog
PARTS CATALOG Figure 6 11 Parts Catalog... - Page 15 Parts Catalog(cont'd.) ITEM NO. PART NUMBER DESCRIPTION MAST CAT I 15748 15795 MAST CAT II 15750 LP2-84 FRAME NO SHANKS 15747 LP2-84S FRAME W/SHANKS 15752 LP2-96 FRAME NO SHANKS 15751 LP2-96S FRAME W/SHANKS 15754 LP2-120 FRAME NO SHANKS LP2-120S FRAME W/SHANKS 15753 15756 LP2-144...
-
Page 16: Bolt Size And Bolt Torque Chart
Bolt Size Chart SAE Torque Chart 13 Bolt Size and Bolt Torque Chart... -
Page 17: Warranty
Monroe-Tufline’s obligation under this Warranty is limited to, at Monroe-Tufline’s option, the repair or replacement, free of charge, of the product if Monroe-Tufline, in its sole discretion, deems it to be defective or in noncompliance with this Warranty. Such parts shall be provided by the selling dealer to the user during regular working hours. If... - Page 18 Monroe-Tufline’s obligation under this Warranty is limited to, at Monroe-Tufline’s option, the repair or replace- ment, free of charge, of the product if Monroe-Tufline, in its sole discretion, deems it to be defective or in noncompliance with this Warranty. The selling dealer shall provide such parts to the user during regular work- ing hours.
-
Page 19: Notes
________________________________________ ________________________________________ ________________________________________ ________________________________________ ________________________________________ ________________________________________ ________________________________________ FILL OUT REGISTRATION CARD BELOW AND MAIL TO: MONROE TUFLINE Attn; Owner Registration PO BOX 7755 Columbus, MS 39705 ------------------------------------------------------------------- OWNER WARRANTY REGISTRATION NAME___________________________ ADDRESS / CITY / STATE__________________________ _________________________ DEALER NAME ______________________________ CITY / STATE_________________________... - Page 20 PART NO. 15812 MONROE TUFLINE MFG. CO., INC. PO BOX 7755 / 2219 TUFLINE LANE COLUMBUS, MS 39705-0004 (662)328-8347 www.monroetufline.com © 2008 Monroe Tufline Manufacturing, Inc. All Rights Reserved...
Need help?
Do you have a question about the LAND PLANES LP2-84 and is the answer not in the manual?
Questions and answers