ALLIANCE DR7004WE Installation Instructions Manual

Hide thumbs

page of 25

/ 25
Bookmarks

Quick Links

Download this manual

Installation Instructions

for Dryers

Original Instructions

Keep These Instructions for Future Reference.

CAUTION: Read the instructions before using the machine.

(If this machine changes ownership, this manual must accompany machine.)

Part No. D518518ENR3

April 2024

Need help?

Do you have a question about the DR7004WE and is the answer not in the manual?

Questions and answers

Summary of Contents for ALLIANCE DR7004WE

Page 1 Installation Instructions for Dryers Original Instructions Keep These Instructions for Future Reference. CAUTION: Read the instructions before using the machine. (If this machine changes ownership, this manual must accompany machine.) Part No. D518518ENR3 April 2024...
Page 3 Installation and service must be performed by a appliance. qualified installer, service agency or the gas sup- plier. W053 W052 This product uses FreeRTOS V7.2.0 (www.freertos.org). © Copyright, Alliance Laundry Systems LLC - Part No. D518518ENR3 DO NOT COPY or TRANSMIT...
Page 4 A “T-Handle” type gas shut-off valve must be installed in the gas supply line to this appliance. • This appliance must not be installed in a bedroom or bath- room. EPA EST. NO.:101050-WI-1 © Copyright, Alliance Laundry Systems LLC - Part No. D518518ENR3 DO NOT COPY or TRANSMIT...
Page 5 Installer Checklist.................25 © Copyright 2024, Alliance Laundry Systems LLC All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher.
Page 6 28 in. [711 mm] 23.5 in. [597 mm] NOTE: Exhaust openings are 4 inch [102 mm] metal * With leveling legs turned into base. ducting. © Copyright, Alliance Laundry Systems LLC - Part No. D518518ENR3 DO NOT COPY or TRANSMIT...
Page 7 28 in. [711 mm] 23.5 in. [597 mm] NOTE: Exhaust openings are 4 inch [102 mm] metal * With leveling legs turned into base. ducting. © Copyright, Alliance Laundry Systems LLC - Part No. D518518ENR3 DO NOT COPY or TRANSMIT...
Page 8 An accessories bag has been shipped inside your dryer. It in- 9. Recheck steps. cludes: 10. Start and run the dryer in a heat setting to verify dryer is heat- • Product literature. ing. © Copyright, Alliance Laundry Systems LLC - Part No. D518518ENR3 DO NOT COPY or TRANSMIT...
Page 9 3. Place the dryer in position, and adjust the legs until the dryer is level from side to side and front to back. The dryer must Figure 2 not rock. © Copyright, Alliance Laundry Systems LLC - Part No. D518518ENR3 DO NOT COPY or TRANSMIT...
Page 10 Front View (Closet Door) 2 (G) DRY2637N_SVG 1. Closet Door 2. Centered Air Openings (G) (2 Openings minimum) 3. Outer Wall of Enclosure Figure 3 © Copyright, Alliance Laundry Systems LLC - Part No. D518518ENR3 DO NOT COPY or TRANSMIT...
Page 11 10. If installing new washing machine, connect hose to unit. Re- washer for Y-Connector are not included with the dryer. fer to washing machine install instructions. 1. Turn off water at shut-off valve. © Copyright, Alliance Laundry Systems LLC - Part No. D518518ENR3 DO NOT COPY or TRANSMIT...
Page 12 Any hose showing the signs of deterioration listed above should be re- placed immediately. All hoses should be replaced ev- ery five years. © Copyright, Alliance Laundry Systems LLC - Part No. D518518ENR3 DO NOT COPY or TRANSMIT...
Page 13 The free area of any opening for outside air must be at least 40 in. [25806 mm ] per unit. • Failure to exhaust dryer properly will void warranty. © Copyright, Alliance Laundry Systems LLC - Part No. D518518ENR3 DO NOT COPY or TRANSMIT...
Page 14 7.87 ft. [2.4 m] , as required to meet UL2158, clause 7.3.2.A. Gas Dryers - Connect Gas Supply Pipe © Copyright, Alliance Laundry Systems LLC - Part No. D518518ENR3 DO NOT COPY or TRANSMIT...
Page 15 Orifice Size Part feet [m] inches [mm] 3000 [915] 0.0890 [2.26] D503778 6000 [1830] 0.0860 [2.18] 58719 8000 [2440] 0.0820 [2.08] D503779 Table 3 continues... © Copyright, Alliance Laundry Systems LLC - Part No. D518518ENR3 DO NOT COPY or TRANSMIT...
Page 16 Refer to Table 4 . accordance with all local codes and ordinances. © Copyright, Alliance Laundry Systems LLC - Part No. D518518ENR3 DO NOT COPY or TRANSMIT...
Page 17 Longer than 15 ft. (4.5 m) – use 8 AWG Wire Length Wire Less than 15 ft. [4.5 m] Listed No. 10 AWG Copper wire only Table 5 continues... © Copyright, Alliance Laundry Systems LLC - Part No. D518518ENR3 DO NOT COPY or TRANSMIT...
Page 18 15. Direct Connection 16. Power Cord Connection Figure 8 1. Disconnect power to dryer. 2. Remove access cover from rear of dryer. D695I_SVG Figure 9 © Copyright, Alliance Laundry Systems LLC - Part No. D518518ENR3 DO NOT COPY or TRANSMIT...
Page 19 Connecting Power Cord with Four-Wire Plug NOTE: Four-wire cord is required for new branch-cir- cuit installations, mobile homes or where codes do not permit grounding through neutral. © Copyright, Alliance Laundry Systems LLC - Part No. D518518ENR3 DO NOT COPY or TRANSMIT...
Page 20 10. Reinstall access cover and screw. Reverse Door, if Desired NOTE: Doors with windows cannot be reversed. © Copyright, Alliance Laundry Systems LLC - Part No. D518518ENR3 DO NOT COPY or TRANSMIT...
Page 21 DRY1918N_SVG Figure 22 7. Reinstall nine screws removed in Step 2. DRY1916N_SVG Figure 19 4. Rotate door panel 180 degrees as shown. DRY1919N_SVG Figure 23 © Copyright, Alliance Laundry Systems LLC - Part No. D518518ENR3 DO NOT COPY or TRANSMIT...
Page 22 Figure 26 W521 When plugging in the dryer: © Copyright, Alliance Laundry Systems LLC - Part No. D518518ENR3 DO NOT COPY or TRANSMIT...
Page 23 Check Heat Source Do not operate other appliances on the same circuit when this ap- pliance is operating. © Copyright, Alliance Laundry Systems LLC - Part No. D518518ENR3 DO NOT COPY or TRANSMIT...
Page 24 W158 6. After the dryer has operated for approximately three minutes, exhaust air or exhaust pipe should be warm. © Copyright, Alliance Laundry Systems LLC - Part No. D518518ENR3 DO NOT COPY or TRANSMIT...
Page 25 Start and Run Dryer in Heat Setting to Verify Dryer is Heating. • Connect Electrical Cord. CHECK CHECK D699I_SVG1 Refer to the manual for more detailed information. © Copyright, Alliance Laundry Systems LLC - Part No. D518518ENR3 DO NOT COPY or TRANSMIT...

This manual is also suitable for:

Dr7004be Dr5103wg Dr5103we