Page 1
F14 and 48000 SERIES Service and Installation Manual Please read this manual completely before attempting to install or operate this equipment! Notify carrier of damage! Inspect all components immediately. See page 3. Effective May 2003...
This should be done within 10 days from receipt of the equipment. For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com SERIAL NUMBER LOCATION The serial number on all 14 Series and 48000 Series hot food tables is printed on the tag located on the plate shelf.
Connections must be made in accordance with all applicable local codes and/or the National Electrical Code. Refer to the wiring diagrams on page 10. For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com NUMBER OF GAS BURNERS...
Page 4
Always place covers on pans when not serving to prevent food from drying out and to reduce your operating cost. For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com Wet operation 1) Fill food well with two inches of water. For quicker pre-heating, use hot water to fill the well.
Hard water stains and lime scaling may require a special cleaning product. Never use steel wool. For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com table which is located behind the control panel, and light the pilot.
Complete assembly, 208V, thermostat w/o drain XMK00103 DRAIN OPTIONAL NOTE: If you need four or more component parts, you must buy a complete assembly. For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com WITH THERMOSTATIC CONTROL THERMOSTATIC CONTROL PART NAME...
Polyethlene board, model 48362 ....130-1398 Polyethlene board, model 48376 ....130-1399 DELFIELD PART # For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com DELFIELD PART #...
Page 10
PILOT LIGHT HEATER 4 PILOT LIGHT HEATER 5 PILOT LIGHT HEATER 6 PILOT LIGHT For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com pilot light (furnished) line wires infinite control with “OFF” position to additional food warmers 208-240V 3 PHASE MODELS "INFINITE"...
Page 11
BLUE 219-4095 FLOAT WATER FILL SOLENOID THREE PHASE IMMERSION WHITE HEATER OPTIONAL For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com GREEN-GROUND TO CASE POWER RELAY 120VAC COIL 219-4095 THERMAL OVERLOAD ON HEATER HEATER GREEN-GROUND TO CASE...
Page 12
F14 AND 48000 Series Service and Installation Manual STANDARD LABOR GUIDELINES TO REPAIR OR REPLACE PARTS ON DELFIELD EQUIPMENT Advice and recommendations given by Delfield Service Technicians do not constitute or guarantee any special coverage. • A maximum of 1-hour is allowed to diagnose a defective component.
Page 13
Unit or any exhaust system. Delfield shall not be liable in any manner for any default or delay in performance hereunder caused by or resulting from any contingency beyond Delfield’s control, including, but not limited to, war,...
Page 14
Unit manufacturer, repaired or altered by anyone other than Delfield in any way so as, in Delfield’s sole judgment, to affect its quality or efficiency or if the serial number has been altered, defaced or removed.
Page 15
F14 AND 48000 Series Service and Installation Manual NOTES: For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com...
980 S. Isabella Rd., Mt. Pleasant, MI 48804-0470, U.S.A. • (989) 773-7981 or (800) 733-8821 • Fax (800) 669-0619 • www.delfield.com Delfield reserves the right to make changes in design or specifications without prior notice. 2003 The Delfield Company. All rights reserved. Printed in the U.S.A.