Adjusting The Clutch Lever Free Play; Cleaning The Air Filter Element - Yamaha WR450FN 2022 Owner's Service Manual

ECA26740
NOTICE
If the engine oil level does not decrease after
the engine has been started, immediately
turn the engine off. Otherwise, the engine
could seize.
c. If the engine oil level does not decrease at
the specified level mark, check the engine
oil system for leaks, and the engine oil
passages and oil pump for damage.
d. Check the oil pressure again.
EAM30216
ADJUSTING THE CLUTCH LEVER FREE
PLAY
1. Check:
• Clutch lever free play "a"
Out of specification  Regulate.
Clutch lever free play
7.0–12.0 mm (0.28–0.47 in)
2. Adjust:
• Clutch lever free play
Handlebar side
a. Turn the adjuster "1" until the specified
clutch lever free play is obtained.
TIP
If the clutch lever free play cannot be obtained
on the handlebar side, use the adjuster on the
clutch cable side.
Clutch cable side
a. Slide the clutch cable cover.
1
3-16
b. Loosen the locknut "1".
c. Turn the adjuster "2" until the specified
clutch lever free play is obtained.
d. Tighten the locknut "1".
Clutch cable locknut
4.3 N·m (0.43 kgf·m, 3.2 lb·ft)
e. Return the clutch cable cover to its original
position.
EAM30219

CLEANING THE AIR FILTER ELEMENT

1. Remove:
• Fuel tank cap cover "1"
Refer to "FUEL TANK CAP" on page 1-21.
• Air filter case cover "2"
TIP
• Loosen the quick fastener screw "3" and re-
move the air filter case cover.
• Remove the two ribs "a" located on the left and
right sides of the projections "b" on the air
scoop, and slide the air filter case cover toward
the front of the vehicle to remove it.
a
b
2. Turn the plates "1" in direction "a".
ENGINE
1
2
3
2
1