Table of Contents
Advertisement
Quick Links
CONSUMER: READ AND RETAIN THESE INSTRUCTIONS FOR FUTURE USE
Locating Your Serial Number:
Your serial number can be found on a white label on the right side cover of your heater. It will begin
with the letter "G" followed by 9 digits. For Example: G123456789. Have your Serial Number ready
before calling customer service at 800-641-6996.
DANGER
BODILY INJURY AND PROPERTY LOSS OR DAMAGE FROM HAZARDS OF FIRE, EXPLOSION, BURN.
ASPHYXIATION, CARBON MONOXIDE POISONING AND / OR ELECTRIC SHOCK.
ONLY PERSONS WHO CAN UNDERSTAND AND FOLLOW THE INSTRUCTIONS SHOULD USE OR
SERVICE THIS HEATER. IF YOU NEED ASSISTANCE OR HEATER INFORMATION SUCH AS AN IN-
STRUCTIONS MANUAL, LABEL, ETC. CONTACT THE MANUFACTURER.
WARNING
BOARD, A SAFE DISTANCE AWAY FROM THE HEATER AS RECOMMENDED
BY THESE INSTRUCTIONS. NEVER USE THE HEATER IN SPACES WHICH
DO OR MAY CONTAIN VOLATILE OR AIRBORNE COMBUSTIBLES, OR
PRODUCTS SUCH AS GASOLINE, SOLVENTS, PAINT THINNERS, DUST
PARTICLES OR UNKNOWN CHEMICALS.
Master is a registered trademark of Pinnacle Climate Technologies, Inc.
MODEL NUMBERS:
60VMHD-GFA / 150VMHD-GFA
GENERAL HAZARD WARNING:
FAILURE TO COMPLY WITH THE PRECAUTIONS AND INSTRUCTIONS
PROVIDED WITH THIS HEATER, CAN RESULT IN DEATH, SERIOUS
FIRE, BURN, INHALATION, AND EXPLOSION
HAZARD. KEEP SOLID COMBUSTIBLES, SUCH
AS BUILDING MATERIALS, PAPER OR CARD-
Fax: 320-251-2922 • Web:
PROPANE FORCED AIR HEATER
User's Manual &
Operating Instructions
Sauk Rapids, MN 56379 USA • Toll Free
www.masterindustrialproducts.com
© 2023 Pinnacle Climate Technologies, Inc. MAGB-445
Factory ID: 500
(800) 641-6996
• Email: info@pinnacleclimate.com
Advertisement
Table of Contents
Related Manuals for Master 60VMHD-GFA
Summary of Contents for Master 60VMHD-GFA
- Page 1 PRODUCTS SUCH AS GASOLINE, SOLVENTS, PAINT THINNERS, DUST PARTICLES OR UNKNOWN CHEMICALS. Sauk Rapids, MN 56379 USA • Toll Free (800) 641-6996 Fax: 320-251-2922 • Web: www.masterindustrialproducts.com • Email: info@pinnacleclimate.com Master is a registered trademark of Pinnacle Climate Technologies, Inc. © 2023 Pinnacle Climate Technologies, Inc. MAGB-445...
-
Page 2: Table Of Contents
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE TABLE OF CONTENTS Safety Information............2-5 Wiring Diagrams.............10 Unpacking.................5 Storage/Maintenance............11 Specifications..............6 Troubleshooting Guide..........11 Features................6 Exploded View...............12 What’s in the Box.............6 Parts List................12 Operation...............7-9 Limited Warranty.............13 Ventilation................9 SAFETY INFORMATION Carbon Monoxide Hazard This heater produces carbon monoxide, which DANGER has no odor. -
Page 3: Safety Information
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE SAFETY INFORMATION (CONT.) RISK OF INDOOR DANGER WARNING PROPANE IS AN EXPLOSIVE GAS. AIR POLLUTION! The products described in this manual are pro- WHAT TO DO IF THE SMELL OF GAS IS PRESENT: pane direct-fired, forced air heaters. - Page 4 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE SAFETY INFORMATION (CONT.) WARNING AIR QUALITY HAZARD – Do not use this heater for heating human living – Periodically monitor levels of CO, CO₂ and NO₂ existing at the construction site – at the quarters minimum at the start of the shift and after 4 –...
-
Page 5: Unpacking
Manifold, Minimum, and Maximum Inlet Pressure ALWAYS install the heater so that it is not directly exposed 60VMHD-GFA 150VMHD-GFA to water spray, rain, dripping water, or wind. Use heater in accordance with all local codes. In –... -
Page 6: Specifications
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE SPECIFICATIONS Model # 60VMHD-GFA 150VMHD-GFA 40 / 50 / 60,000 120 / 135 / 150,000 1.9 / 2.3 / 2.8 5.5 / 6.2 / 6.9 Fuel Consumption - Lb./hr (kg/hr) (0.9 / 1.04 / 1.27) -
Page 7: Operation
– The temperature of the LP tank and its Use only an approved propane cylinder. surroundings. LP Characteristics Minimum Number of LP Cylinders – Flammable, explosive under pressure, heavier 60VMHD-GFA 150VMHD-GFA Average Temp than air and pools in low areas. 100 lb. (45 kg) 100 lb. (45 kg) (ºF / ºC) - Page 8 NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE OPERATION (CONT.) Fasten full propane tank and connect proper – CAUTION The disconnected fitting to LP cylinder valve by turning COUNTER- tank must never CLOCKWISE (See Figure 2 & 3). be stored in a With heater gas valve knob still in OFF position –...
-
Page 9: Ventilation
MAY LEAD TO DEATH! DANGER Not for use in residential living areas or in non-adequately ventilated enclosed spaces. 60VMHD-GFA / 150VMHD-GFA Valve Knob VENTILATION – Risk of indoor air pollution and Carbon Monoxide Poisoning. Use heater only in well Minimum Ventilation Opening Needed ventilated areas. -
Page 10: Wiring Diagrams
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE WIRING/SCHEMATIC DIAGRAMS 60VMHD-GFA / 150VMHD-GFA IGNITOR SPARK BLUE MODULE CONDENSER BLUE WHITE BLUE MOTOR WHITE BLACK WHITE BLACK FUSE POWER CORD GREEN PCB ASS’Y BLUE THERMAL SWITCH... -
Page 11: Storage/Maintenance
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE STORAGE / MAINTENANCE Always disconnect the heater from the LP cylinder NOTE: Installation and repair of this heater should before putting the heater into storage. If for any be done by a qualified service person. -
Page 12: Exploded View
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE EXPLODED VIEW PARTS LIST Item # Description 60VMHD-GFA 150VMHD-GFA Height Controller 22-512-0006 22-512-0008 Base Cover 22-508-0003 22-508-0004 Inner Shell Cap 22-505-0010 22-505-0008 Multi Bracket Assembly 22-504-0002 22-504-0002... -
Page 13: Limited Warranty
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE LIMITED WARRANTY Pinnacle Climate Technologies, Inc. warrants this product If Pinnacle Climate Technologies, Inc. finds the item to to the original retail purchaser only, to be free from defects be in normal operating condition, or not defective the item in material and workmanship for a period of one (1) year will be returned freight collect.
Need help?
Do you have a question about the 60VMHD-GFA and is the answer not in the manual?
Questions and answers