TABLE OF CONTENTS Page Introduction Dimension of wood stove Warning Creosote Wood Lighting Glass Glass Replacement Refractory Brick Replacement Maintenance Chimney Maintenance Ashes Expansion Noises Security Requirements Combustible Materials Installation in mobile home Type of Chimney Chimney Minimum height of chimney Fresh air intake &...
Take time to attentively read all information in this instruction manual and keep it for reference it contains all the necessary information for installation and efficient use of the Diamond wood stove. Before installing the wood stove consult the local authorities to obtain a construction permit. Take note of all the lawful requirements in force.
WARNING It is prohibited to use gasoline, oil or other flammable liquids to light a fire Never use your wood stove with oil waste, naphtha, and gasoline or engine oil. The fire might get out of control and may cause a chimney fire. During combustion, the walls of the stove become very hot;...
GLASS Never slam the door and never strike the glass. When you close the doors, make sure that the logs are placed in order not to fall against the glass, or to burn to close to the glass. Never clean the glass with abrasive products. The scratches could be transformed into cracks and the glass could break.
REFRACTORY BRICK REPLACEMENT Do not use the stove when there is a missing or broken brick. If a refractory brick is broken replace it by a similar one. 1-You can purchase replacement refractory brick at your retailer or at Nordic Steel Products Int. REFRACTORY BRICK...
MAINTENANCE DOOR Before heating the stove for the first time, it is necessary to remove all the labels and wash the door with soapy water (soft soap). Because, the least traces on the door will remain forever when heating your stove Clean your stove regularly by removing the ashes.
With this intention, uses ignited newsprint and maintain it in direction of the chimney. INSTALLATION IN MOBILE HOMES The Diamond stove models are approved for mobile home. They are easy to install and must be equipped with a surrounding air contribution’s kit.
TYPE OF CHIMNEY The type of chimney must have a minimal diameter of 6’’ (152 mm) and must be approved for residential use (Can.: ULC S629; EU. UL 103HT), the evacuation duct must never pass through an attic, cupboard, closet or any other enclosed area, as well as a floor, ceiling or a partition made of combustibles materials.
FRESH AIR INTAKE & BACK DRAFTING Diamond wood stove installed properly should not produce smoke in the house. If the stove continues to produce smoke, it will probably be for one of the following reasons: 1) The chimney’s external installation is defective or incorrect, engaging in problems of return of air and, consequently, of difficult lightings 2) The heating of the chimney is insufficient.
CHIMNEY FIRE Communicate with the municipal or provincial fire prevention services to obtain information on the way of controlling chimney fires. If a chimney fire is declared, they will know exactly what measures to take. If you presume the existence of a chimney fire it is recommended to: Close the doors and combustion control key of the stove Advise all family members Call the fire department if help is needed...
STANDARD INSTALLATIONS The Diamond stove model should be placed so that there is an open space with any combustible surface as ceiling or wall, see table of release. 48'' to the front B-16’’ to the sides A-50’, to the selling STANDARD INSTALLATION The releases can only be reduced by approval of the authorities.
PARTS DESCRIPTION DESCRIPTION PARTS Floor Protector (Non combustible) 6’’ single or double pipe Certified Chimney 2100 Attic Radiation shield Decorative Ceiling Support Adaptor Plaster Filling of roof REFER TO PAGES 12-13 FLOOR PROTECTION If your floor is made of concrete, you can install your stove directly on it. For the installation and use in conformity with the manufacturer’s instructions and the local building codes, the stove, must be installed on a 3/8'' (9.5 mm) thick concrete plate (Duroc) or an equivalent, extending 18 '' (457 mm) in front and 8'' (203 mm) in the back and on the sides.
Note: Each complaint must be accompanied by proof of purchase Nordic Steel Products Int. offers to the original purchaser of a Nordica wood stove, a limited warranty of twenty-five years from the date of purchase of the wood stove, against any defects in materials or workmanship.
7What other brand of wood stove have you thought of before purchasing? ____ Nordica is so confident in the quality of materials and the manufacture of each unit, that we offer a reliable and complete guarantee to you. Please see your instruction manual or your retailer for more information.