Table of Contents
Troubleshooting
Related Manuals for Whisper Power ELITE GV 2
Summary of Contents for Whisper Power ELITE GV 2
- Page 1 USER’S MANUAL ELITE GV 2, GV 3, GV 3+, ELITE GV 8, GV 10, GV 12 and ELITE GV 15 genverters for mobile use WHISPERPOWER BV Kelvinlaan 82 9207 JB Drachten Netherlands Tel.: +31-512-571550 Fax.: +31-512-571599 www.whisperpower.com V3, June 2020...
-
Page 2: Table Of Contents
Documentation ..............................7 Main components to identify ..............................8 2.4.1 ELITE GV 2 and ELITE GV 8, ELITE GV 3 and ELITE GV 10/12 ................8 2.4.2 ELITE GV 3+ and ELITE GV 15 ..........................10 TECHNICAL INFORMATION ............................... 12 Explanation of functional parts ............................ - Page 3 Troubleshooting table for engine ........................22 6.2.3 Warnings ................................25 6.2.4 Service address ..............................25 SPARE PARTS .................................... 26 Maintenance log ....................................27 Supplier’s Declaration of Conformity/Incorporation Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN...
-
Page 4: Introduction
European Community safety regulations. Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN... -
Page 5: General Information
• be familiar with the contents of this manual. This applies in particular to this chapter, Safety Guidelines and Measures. Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN... -
Page 6: Maintenance & Repair
Genverter including the • Do not attempt to operate the Genverter with a capsule. known unsafe condition. Disconnect the battery Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN... -
Page 7: Features
The output of the power from the alternator will be from zero to 300V-400Hz and 400V-500Hz, depending on the engine speed. The engine speed is set to strike a balance between fuel Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN... -
Page 8: Main Components To Identify
GENERAL INFORMATION MAIN COMPONENTS TO IDENTIFY 2.4.1 ELITE GV 2 and ELITE GV 8 Figure 3: ELITE GV 2 and ELITE GV 8, reverse view Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN... - Page 9 49006025 Elite 12 MOBILE 120 V / 60 Hz Kubota D722 Engine Elite 3 + 10 + 12 DATE 7044A184624 PRINTED Figure 4: ELITE GV 3, GV-10 and Elite GV 12, reverse view Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN...
-
Page 10: Elite Gv 3+ And Elite Gv 15
49007025 Elite 15 MOBILE 120 V / 60 Hz Kubota D1105 Engine Elite 3 Plus & 15 DATE 7047A195357 PRINTED Figure 5: ELITE GV 3+ and ELITE GV 15, reverse view Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN... - Page 11 GENERAL INFORMATION Figure 6: DDC box, standard provided with an elite. Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN...
-
Page 12: Technical Information
When using the Genverter in an automatic mode the engine will start when power is demanded, e.g. because of low batteries or another Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN... -
Page 13: Fuel
Do not mix different types of oil. Higher API class oils and synthetic oils are to be avoided. Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN... -
Page 14: Technical Data
Service interval oil change 200 h Oil capacity Approx. 2.1 l Approx. 3.2 l Approx. 3.8 l Approx. 4.0 l Lubricant At least CF Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN... - Page 15 Automotive EMC 2004/104/EC EN (designed to meet) EN 60945 ABYC (designed to meet) American Boat & Yacht Council UL or CSA (designed to meet) UL 458 Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN...
-
Page 16: Operation
(settable); the Fuel valve: open. starter will then crank the engine until it starts. While starting the alarms are blocked (this is achieved by pushing Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN... - Page 17 In order to prolong the genverter’s life expectancy, the drained. nominal electrical demand of the system should not exceed Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN...
-
Page 18: Maintenance
Push the start off and the control system fuse removed. Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN... -
Page 19: Servicing After Break-In
Screw in the cartridge by hand. When the gasket contacts ignite and cause fire. the seal surface, tighten the cartridge not too firmly, by hand. Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN... -
Page 20: Replacing The Fuel Filter
Figure 13: Fuel filter (similar on all models) conditions. This method of preservation will be sufficient for 6 months. Change oil before using the engine again. Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN... -
Page 21: Troubleshooting
650 V. Remove 3 A fuse from the control panel while working on the Genverter in order to prevent the engine from starting. Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN... -
Page 22: Troubleshooting Table For Alternator
• Air in fuel lines Bleed air from fuel system (refer to maintenance section) • Blocked injector Have the injector tested and cleaned if necessary Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN... - Page 23 Readjust valve clearance • Valve clearance incorrect. • Continuous running with very low load. Increase load and have the engine run for a few hours Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN...
- Page 24 • Radiator choked by dirt Clean radiator • Hot air circulation in the radiator. • Exhaust choked with carbon Clean exhaust Contact WhisperPower service • Cooling circuit failure Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN...
-
Page 25: Warnings
WhisperPower Service Centre or WhisperPower Netherlands for an extended service list. Email: service@whisperpower.com For instant and detailed information, we recommend checking our website: www.whisperpower.com. Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN... -
Page 26: Spare Parts
Fuel pump (high pressure) complete 40403160 40404160 40201680 Thermostat (**) 40403145 40403145 40403145 Thermostat gasket (**) 40403138 40403138 40403138 Rocker cover gasket (**) 40403137 40404137 40201637 Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN... -
Page 27: Maintenance Log
2000 h 2200 h 2400 h 1,2,3 2600 2800 h 3000 h 3200 h 1,2,3,4 3400 h 3600 h 3800 h 4000 h 1,2,3 Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN... - Page 28 6800 h 7000 h 7200 h 1,2,3 7400 h 7600 h 7800 h 8000 h 1,2,3,4 8200 h 8400 h 8600 h 8800 h 1,2,3 Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN...
- Page 29 Servicefirma (nur für mit £ markierten Servicearbeiten) *) Cachet et adresse complète du centre de services WhisperPower (seulement pour les travaux marqués £ ). 9000 h Elite GV 2, 3, 3+, 8, 10 and Elite GV 15 — June 2020 — EN...
-
Page 30: Supplier's Declaration Of Conformity/Incorporation
Supplier's Declaration of Conformity/Incorporation 7015001001 Issuer's name: WhisperPower BV Issuer's address: Kelvinlaan 82, NL-9207 JB Drachten Object of the declaration: WhisperPower two and three cylinder Genverters, model Elite 2, Elite 3, Elite 3+ • Elite 8, Elite 10, Elite 12 and Elite 15 mobile genverters. - Page 31 Kelvinlaan 82, 9207 JB Drachten, Netherlands Tel : + 31-512-571550 / Fax : + 31-512-571599 www.whisperpower.com / info@whisperpower.com...