Table of Contents
Advertisement
72
REGULAR CHECKS AND MAINTENANCE WORK
BBattery
To avoid the possibility of a battery explosion:
For refillable type battery, follow the instructions
below.
A Do not use or charge the refillable type battery
if the fluid level is below the LOWER (lower limit
level) mark. Otherwise, the battery component
parts may prematurely deteriorate, which may
shorten the battery's service life or cause an
explosion. Check the fluid level regularly and
add distilled water as required so that the fluid
level is between the UPPER and LOWER levels.
To avoid personal injury:
A Never remove the vent caps while the engine is
running.
A Keep electrolyte away from eyes, hands and
clothes. If you are spattered with it, wash it
away completely with water immediately and
get medical attention.
A Wear eye protection and rubber gloves when
working around the battery.
A Before inspection or dismounting the battery,
be sure to turn off the engine and turn the
starter switch to the "OFF" position.
A When removing the battery, always disconnect
the negative ground cable first. When installing
a battery, always connect the ground cable
last. This prevents a possible explosion caused
by sparks.
A Always wear eye protection when working with
the battery.
1. Open the side cover. (See "Opening / Closing of the
Side Cover in "MAINTENANCE" section.)
2. Check the battery fluid level and add distilled water if
necessary.
3. Should battery fluid be spilt, fill with sulphuric acid
solution of the same concentration.
4. Clean the battery caps (ventilation holes).
(1) Battery
(A) "Upper level"
(B) "Lower level"
Advertisement
Table of Contents
