Important Safety Instructions For All Battery Packs - Stanley XR DCD700D2 Original Instructions Manual

When the charger detects a battery that is cold, it
automatically delays charging until the battery has
warmed.
The red light will continue to blink, but a yellow
indicator light will be illuminated during this operation.
Once the battery has cooled, the yellow light will turn
off and the charger will resume the charging procedure.
XR Li-Ion tools are designed with an Electronic
Protection System that will protect the battery against
overloading, overheating or deep discharge.
The tool will automatically turn off if the Electronic
Protection System engages. If this occurs, place the
Li-Ion battery on the charger until it is fully charged.
LI-ION BATTERY PACKS ONLY
Li-Ion batteries are designed with an Electronic
Protection System that will protect the battery against
overloading, overheating or deep discharge.
The tool will automatically turn off if the Electronic
Protection System engages. If this occurs, place the
Li-Ion battery on the charger until it is fully charged.
Important Safety Instructions for All
Battery Packs
When ordering replacement battery packs, be sure to
include catalog number and voltage.
The battery pack is not fully charged out of the carton.
Before using the battery pack and charger, read
the safety instructions below. Then follow charging
procedures outlined.
READ ALL INSTRUCTIONS
• Do not charge or use battery in explosive
atmospheres, such as in the presence of
flammable liquids, gases or dust. Inserting or
removing the battery from the charger may ignite
the dust or fumes.
• Never force battery pack into charger. Do not
modify battery pack in any way to fit into a
non-compatible charger as battery pack may
rupture causing serious personal injury.
• Charge the battery packs only in D
chargers.
• DO NOT splash or immerse in water or other
liquids.
• Do not store or use the tool and battery pack in
locations where the temperature may reach or
exceed 40 ˚C (105 ˚F) (such as outside sheds or
metal buildings in summer).
WARNING: Never attempt to open the
battery pack for any reason. If battery
pack case is cracked or damaged, do not
insert into charger. Do not crush, drop or
damage battery pack. Do not use a battery
pack or charger that has received a sharp
blow, been dropped, run over or damaged
SPECIFIC SAFETY INSTRUCTIONS FOR LITHIUM ION
(Li-Ion)
• Do not incinerate the battery pack even if it is
• If battery contents come into contact with the
• Contents of opened battery cells may cause
Transportation
D WALT batteries comply with all applicable shipping
e
regulations as prescribed by industry and legal
standards which include UN Recommendations on
the Transport of Dangerous Goods; International
Air Transport Association (IATA) Dangerous Goods
Regulations, International Maritime Dangerous Goods
(IMDG) Regulations, and the European Agreement
Concerning The International Carriage of Dangerous
WALT
e
Goods by Road (ADR). Lithium-ion cells and
batteries have been tested to section 38.3 of the UN
Recommendations on the Transport of Dangerous
Goods Manual of Tests and Criteria.
In most instances, shipping a D
be excepted from being classified as a fully regulated
Class 9 Hazardous material. In general, the two
instances that require shipping Class 9 are:
1. Air shipping more than two D
2. Any shipment containing a lithium-ion battery with
in any way (i.e., pierced with a nail, hit with
a hammer, stepped on). Electric shock or
electrocution may result. Damaged battery
packs should be returned to service centre
for recycling.
CAUTION: When not in use, place tool
on its side on a stable surface where
it will not cause a tripping or falling
hazard. Some tools with large battery
packs will stand upright on the battery
pack but may be easily knocked over.
severely damaged or is completely worn out.
The battery pack can explode in a fire. Toxic fumes
and materials are created when lithium ion battery
packs are burned.
skin, immediately wash area with mild soap
and water. If battery liquid gets into the eye, rinse
water over the open eye for
15 minutes or until irritation ceases. If medical
attention is needed, the battery electrolyte
is composed of a mixture of liquid organic
carbonates and lithium salts.
respiratory irritation. Provide fresh air. If
symptoms persists, seek medical attention.
WARNING: Burn hazard. Battery liquid
may be flammable if exposed to spark or
flame.
battery packs when the package contains only
battery packs (no tools), and
an energy rating greater than 100 watt hours (Wh).
E NG LI S H
WALT battery pack will
e
WALT lithium-ion
e
7