Page 1
Usage and Maintenance Instructions Titan Mobility Scooter - MS03039 Product Code: MS03039 Thank you for purchasing your Titan Scooter. We are delighted you have chosen CareCo (UK) Ltd for your mobility needs. Standard Packing List: 1 Owner’s Manual • 1 Battery Pack •...
Page 2
We ask that you read this manual completely before operating your new TITAN scooter. CareCo (UK) Ltd is not, and cannot be held responsible for, any damage or injury incurred due to improper or unsafe use of the CareCo TITAN scooter.
Our scooters have been designed and manufactured to provide a comfortable and secure yet affordable solution for some mobility requirements. Suggestion To maximise the efficiency and service life of your batteries, please fully charge before their first use. CareCo, Hubert Road, Brentwood, Essex, CM14 4JE www.careco.co.uk...
Do not drive your vehicle in an ‘S’ pattern or make erratic turns. • Do not take the scooter onto escalators. Under no circumstances should the scooter be used as a seat in a motor vehicle (e.g. Cars, buses, trains, etc). CareCo, Hubert Road, Brentwood, Essex, CM14 4JE www.careco.co.uk...
Page 6
Refer to section entitled ‘MAX. USER WEIGHT’ in ‘7. SPECIFICATION ‘. Overloading past the weight limit may lead to damage of your scooter or cause it to malfunction which could endanger your safety. The warranty does not cover this type of damage. CareCo, Hubert Road, Brentwood, Essex, CM14 4JE www.careco.co.uk...
Serious harm or injury can occur. The manufacturer disclaims all responsibility for any personal injury or property damage which may occur as a result of improper use of its products. CareCo, Hubert Road, Brentwood, Essex, CM14 4JE www.careco.co.uk...
Page 8
(Note: There is no easy way to evaluate their effect on a powered scooter.) 5. Report all incidents of unintended movement or brake release to CareCo, and note whether there is a radio wave source nearby.
• The remaining power indicated by the battery indicator will vary by the actual driving time incurred and how you drive. Repeated starting, stopping, climbing will consume the power more quickly. CareCo, Hubert Road, Brentwood, Essex, CM14 4JE www.careco.co.uk...
Page 11
When the batteries’ range is approximately 50% of that when new, it is time for replacements. Please contact CareCo regarding replacement batteries. If you continue to use the old batteries, the performance of your scooter may be affected.
Page 12
When the voltage in your scooter’s batteries becomes low, or the scooter is under strain due to excessive loads or steep inclines, the main circuit breaker may trip to protect the motor and electronics from damage. CareCo, Hubert Road, Brentwood, Essex, CM14 4JE www.careco.co.uk...
There is a red LED present on the charger to illustrate operation. If this LED does not illuminate the charger is • defective - please contact CareCo Customer Service on 0845 611 8022 or email: cs@careco.co.uk Attention When returning the battery pack to the battery pack cavity of the shroud, again, beware of trapping fingers or •...
Attention- Please follow the rules below to avoid accidents while charging. Please use the CareCo charger only, and recharge the battery to its full capacity every time. You may damage the battery and scooter if you use a charger, which is not to the correct specification.
Page 15
Be sure the battery wires are connected to their correct battery terminal. Suggestion If necessary, ask for help from CareCo for advice about maintaining and replacing the battery. Contact Customer Services on 0845 611 8022 or email: cs@careco.co.uk ...
6.2 Regular checking record To make sure your scooter is correctly serviced, contact CareCo regarding regular maintenance checks. This should be at intervals of six months following an initial inspection after one month. These checks may be chargeable.
If the battery charger is turned on and no LEDs are lit, check the fuse. Suggestions Ask for help from CareCo to inspect or replace the fuse, as the tiller shroud has to be removed before the fuse can be replaced. Contact Customer Services on 0845 611 8022 or email: cs@careco.co.uk Tyres The condition of the tyres depends on how you drive and use your scooter.
Store your Titan scooter out of direct sunlight, rain, and damp conditions. When storing for a length of time, please charge the batteries to full power and then disconnect the battery terminal. For details contact CareCo Customer Services on 0845 611 8022 or email: cs@careco.co.uk 6.5 Manually moving the scooter...
Recharge the batteries. • If problem persists contact CareCo. The LED lights will ‘blink’ if there is a problem with your Titan scooter. The list below will assist you in identifying any possible malfunction. CareCo, Hubert Road, Brentwood, Essex, CM14 4JE www.careco.co.uk...
Page 20
15sec. Park brake fault Check park brake connection. Speed pot neutral fault Calibrate speed pot neutral. Speed pot error Check speed pot connection. Motor error Check motor connection. Other errors Internal error. CareCo, Hubert Road, Brentwood, Essex, CM14 4JE www.careco.co.uk...
Page 21
Note: Maximum driving distance is based on an ambient temperature of 20°C, a 75kg driver and brand new fully charged batteries; with a constant driving speed of 8 mph on a flat surface. CareCo, Hubert Road, Brentwood, Essex, CM14 4JE www.careco.co.uk...
6. Warranty Quality / Warranty Declaration Products are to be fit for purpose and of excellent quality and performance. For valid warranty claims CareCo (UK) Ltd will, at their discretion, replace / repair / refund items mutually agreed to be defective.
Need help?
Do you have a question about the Titan MS03039 and is the answer not in the manual?
Questions and answers