Triton T60X Installation And Operating Instructions Manual

Triton T60X Installation And Operating Instructions Manual

Electric shower

Advertisement

Quick Links

T60X
electric shower
REGISTER ONLINE
ENTER A PRIZE DRAW
WIN
£100
R E TA I L V O U C H E R S
VISIT OUR WEBSITE TODAY
TRITONSHOWERS.CO.UK/REGISTER
THIS OFFER IS NOT VALID OUTSIDE THE UK
FOR YOUR SERVICE REFERENCE
NOTE DOWN THE PRODUCT CODE BELOW
(FROM THE FRONT OR TOP OF THE BOX)
ALTERNATIVELY REGISTER BY TEL: 024 7637 8321
INSTALLATION AND OPERATING INSTRUCTIONS
Please read this book thoroughly and familiarise yourself with all instructions before commencing
installation and keep it for future reference.
The shower installation MUST be carried out by a suitably qualified person, in the sequence of
this instruction book.
IMPORTANT SAFETY ADVICE
The shower unit MUST BE switched off at the
isolating switch when not in use. This is a
safety procedure recommended for all
electrical appliances.
The shower head and hose supplied with this
product are a safety critical part of your shower.
Failure to use genuine Triton parts may cause
injury and invalidate your guarantee.
2180800J - October 2022

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the T60X and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for Triton T60X

  • Page 1 The shower head and hose supplied with this product are a safety critical part of your shower. Failure to use genuine Triton parts may cause injury and invalidate your guarantee. ALTERNATIVELY REGISTER BY TEL: 024 7637 8321 INSTALLATION AND OPERATING INSTRUCTIONS Please read this book thoroughly and familiarise yourself with all instructions before commencing installation and keep it for future reference.
  • Page 2: Important Safety Information And Guideance Notes

    INTRODUCTION - PLEASE READ T60X PLEASE READ THIS IMPORTANT SAFETY INFORMATION Products manufactured by Triton are safe and without risk provided they are installed, used and maintained in good working order in accordance with our instructions and recommendations. WARNING: DO NOT operate the appliance if frozen, or suspected of being frozen.
  • Page 3 WARNING: If restarting the shower immediately after stopping, be aware that a slug of hot water will be expelled for the rst few seconds. IMPORTANT - PLEASE READ THESE T60X GENERAL GUIDANCE NOTES BEFORE PROCEEDING GENERAL 2.3 DO NOT solder pipes or ttings within 300mm...
  • Page 4: Specifications

    T60X ADVICE TO USERS This book contains all the necessary fitting and operating instructions for your electric shower. The following points will help you understand Please read them carefully. how the shower operates: The shower installation must be carried out by a suitably qualified person and in the sequence of this a.
  • Page 5: Table Of Contents

    Fault finding ..................20 – 20 Water/Cable entry points diagram ............22 Guarantee, service policy, etc............rear cover To check the product suitability for commercial and multiple installations, please contact Triton’s speci cation advisory service before installation. Telephone: 024 7637 2222 Email: technical@tritonshowers.co.uk...
  • Page 6: Key To Main Components

    T60X MAIN COMPONENTS Fig. Top pipe/cable entry 217 mm 2. Bottom pipe/cable entry 3. Area for rear pipe and cable entry 4. Water inlet 5. Wall screw fixings 230 mm 6. Cover screw fixings 7. Terminal block 8. Power selector assembly 9.
  • Page 7: Electrical Requirements

    Fig.3 - Illustrative purposes only Fig.2 WARNING! W-006-A Triton Showers, THIS APPLIANCE MUST BE EARTHED Triton Road, Nuneaton, Warwickshire, CV11 4NR xxxx The installation, supply cable and circuit protection must conform with BS 7671 (IEE wiring regulations) and be suf cient for the amperage required.
  • Page 8 T60X 9.3 In any event, it is essential that individual A 45 amp double pole isolating switch with a minimum contact gap of 3mm in both site conditions are assessed by a competent poles must be incorporated in the circuit.
  • Page 9: Water Requirements

    T60X WATER REQUIREMENTS Mains electric supply (via double pole switch) The installation must be in accordance with Water Regulations/Bylaws. To guarantee activating the heating elements, Double the shower must be connected to a mains water pole supply with a minimum running pressure of...
  • Page 10: Siting Of The Shower

    T60X SITING OF THE SHOWER WARNING! IMPORTANT: If installing onto a tiled wall THE SHOWER MUST NOT BE POSITIONED always mount the unit on the surface of the WHERE IT WILL BE SUBJECTED TO tiles. NEVER tile up to the unit.
  • Page 11: Fixing The Shower To The Wall

    T60X FITTING THE SHOWER TO THE WALL Fig. WARNING! Check there are no hidden cables or pipes before drilling holes for wall plugs. Use great care when using power tools near water. The use of a residual current device (RCD) is recommended.
  • Page 12 T60X NOTE: Deviations from the designated entry Fig. points will invalidate product approvals. If installing a feed pipe from the back or bottom, the centre of the inlet valve to the wall surface is 20mm (fig.9). NOTE: If entry is from the back, the nut of the compression fitting will be partially behind the surface of the wall (fig.9).
  • Page 13: Plumbing Connections

    T60X PLUMBING CONNECTIONS Fig. Plumbing to be carried out before wiring. DO NOT use jointing compounds on any pipe fittings for the installation. DO NOT solder fittings near the area of the shower unit as heat can transfer along the pipework and damage components.
  • Page 14: Electrical Connections

    T60X ELECTRICAL CONNECTIONS Fig. SWITCH OFF THE ELECTRICITY SUPPLY AT THE MAINS. Fig.12 shows a schematic wiring diagram. The cable entry points are shown in Water/ Cable Entry Points diagram. The cable can be surface clipped, hidden or via 20mm conduit.
  • Page 15: Replacing The Cover

    T60X REPLACING THE COVER Fig. Position the power selector on the cover to the ECONOMY position (fig.14). Make sure the power selector spindle is aligned with the screw at the 6 o'clock position as shown in fig.15. Economy position To make sure that the temperature control is correctly...
  • Page 16: Commissioning

    T60X COMMISSIONING Fig. WARNING! Before normal operation of the shower, it is essential the following commissioning procedure is completed correctly. The first operation of the shower is intended to flush out any unit debris and to guarantee that the heater unit contains water before the elements are switched on.
  • Page 17: Operating The Shower

    T60X OPERATING THE SHOWER Fig. The flow of water is controlled by the START/STOP temperature control. To obtain warm water turn the control slowly anti-clockwise to the mid position, i.e. numbers 5 or 6 (fig.19). If the water is too hot, turn the temperature control slowly clockwise towards the lower numbers (fig.20).
  • Page 18: Operating Functions

    T60X OPERATING FUNCTIONS Fig. Low Water Pressure Cut-out If the water pressure falls below the minimum Power selector required for correct operation of the shower, power will be switched off to the heating elements preventing any maintained temperature rises - water will continue to flow. Power will automatically be restored when adequate water pressure returns.
  • Page 19: Spare Parts

    T60X SPARE PARTS Ref. Description Part No. 1. Selector switch assembly ..S25711020 2. Thermal cut-out (can) ..22012250 3. Heater can assembly (8.5kW) ......P25910700 (9.5kW) ......P25910701 (10.5kW) ......P25910702 4. Stabiliser valve assembly (incl. inlet elbow) (8.5Kw & 9.5Kw) ....82600720 (10.5Kw) ......
  • Page 20: Fault Finding

    4.4.2 Power cut. Check other appliances and if necessary, contact local Electricity Supply Co. 4.5 Electrical 4.5.1 Have unit checked by suitably qualified malfunction or safety electrician or contact Triton Customer cut-out operated. Experience.
  • Page 21 T60X FAULT FINDING Problem Cause Action 5 Shower varies 5.1 Water pressure has 5.1.1 Wait until the water pressure resumes to from normal dropped below minimum normal. temperature to cold required during use. 6.1.1 Clean or replace blocked sprayplate in 6 Pressure relief 6.1 Blocked shower...
  • Page 22: Water/Cable Entry Points Diagram

    Cable Entry Points WEEE Directive – Policy Statement As a producer and a supplier of electric showers, Triton Showers is committed to the protection of the environment via our own environmental policy and compliance with the WEEE directive. Triton Showers is fully registered with the Environment Agency under the following schemes:...
  • Page 23 T60X...
  • Page 24 Trade Installer Hotline: 024 7637 8344 Nuneaton www.tritonshowers.co.uk Warwickshire, CV11 4NR E-mail: serviceenquiries@tritonshowers.co.uk E-mail: technical@tritonshowers.co.uk Triton is a division of Norcros Group (Holdings) Limited Triton reserve the right to change product specifi cation without prior notice. E&OE. © TRITON SHOWERS 2022...

Table of Contents