Advertisement
Quick Links
Ontario, California 91761
_________________________________________________________________________________________________________
ASSEMBLY & OPERATING INSTRUCTIONS
MODEL 57568 5 Burner Stainless Steel Built-In, L.P. (Propane) Gas with Rotisserie Back Burner and Grill lights
MODEL 57569 5 Burner Stainless Steel, Built-In, Natural Gas with Rotisserie Back Burner and Grill lights
MODEL 1568X 5 Burner Stainless Steel Built-In, L.P. (Propane) Gas with Rotisserie Back Burner
MODEL 1569X 5 Burner Stainless Steel, Built-In, Natural Gas with Rotisserie Back Burner
TABLE OF CONTENTS
SAFETY INSTRUCTIONS ..............................................................................................................
INSTALLATION INSTRUCTIONS .....................................................................................................
LIGHTING & OPERATING INSTRUCTIONS ........................................................................................
CLEANING & MAINTENANCE ..........................................................................................................
TROUBLESHOOTING ....................................................................................................................
PARTS LIST .................................................................................................................................
WARRANTY...................................................................................................................................
READ THE FOLLOWING INSTRUCTIONS CAREFULLY AND BE SURE YOUR GRILL IS PROPERLY INSTALLED, ASSEMBLED
AND CARED FOR. FAILURE TO FOLLOW THESE INSTRUCTIONS MAY RESULT IN SERIOUS BODILY INJURY AND/OR
PROPERTY DAMAGE. IF YOU HAVE QUESTIONS CONCERNING ASSEMBLY OR OPERATION, CONSULT YOUR DEALER,
GAS APPLIANCE SERVICE REPRESENTATIVE OR YOUR GAS COMPANY
NOTE TO INSTALLER:
LEAVE THESE INSTRUCTIONS WITH THE CONSUMER AFTER INSTALLATION.
NOTE TO THE CONSUMER
RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE.
THIS OUTDOOR COOKING GAS APPLIANCE IS NOT INTENDED TO BE INSTALLED IN OR ON RECREATIONAL VEHICLES
AND/OR BOATS.
SAFETY INSTRUCTIONS
Read carefully before assembling and operating your gas grill
1
PAGE
2
4
9
12
13
14
16
Revision 11/08
Advertisement
Subscribe to Our Youtube Channel
Related Manuals for Bull BRAHMA 1568X
Summary of Contents for Bull BRAHMA 1568X
-
Page 1: Table Of Contents
Ontario, California 91761 _________________________________________________________________________________________________________ ASSEMBLY & OPERATING INSTRUCTIONS MODEL 57568 5 Burner Stainless Steel Built-In, L.P. (Propane) Gas with Rotisserie Back Burner and Grill lights MODEL 57569 5 Burner Stainless Steel, Built-In, Natural Gas with Rotisserie Back Burner and Grill lights MODEL 1568X 5 Burner Stainless Steel Built-In, L.P. - Page 2 This gas grill must be installed in accordance with local codes or, if in an area without local codes, with the latest edition of the National Fuel Gas Code ANSI Z223.1. In Canada, installation must conform to the standard CAN/ CGA 1-b149.1 and/or .2 (Installation Code for Gas Burning Appliances and Equipment) and any local codes.
-
Page 3: Installation Instructions
Check with your gas utility or with local building codes for instructions to install gas supply line, or call a licensed and knowledgeable installer. It is recommended that an “ON-OFF” shutoff valve be installed at the gas supply source: Outdoors after gas line piping exits outside wall and before quick-disconnect or before gas line piping enters ground. Indoors in the branch fuel line in an accessible location near the supply line. - Page 4 NOTE TO INSTALLER: Leave these instructions with the consumer for future reference. Your grill must be installed in accordance with all local building codes. SPECIFICATIONS FOR BARBECUE STRUCTURE 1. Masonry of your choice can be used for cabinet construction for the built-in gas grill. It must be non- combustible material. Keep in mind when choosing a location for your grill that it should NOT be located under any overhead combustible construction.
- Page 5 MODEL 5 BURNER 38” OUTDOORS PROPANE GAS BBQ INSTALLATION SPECIFICATIONS NOTE: Vents must be provided for combustion air on both sides of built-in cabinet. When choosing a location for your gas grill keep in mind that it should never be located under any overhead combustible construction.
- Page 6 MODEL 5 BURNER 38” INSPECTING I CLEANING BURNERS AND GAS VALVE ORIFICES By following these cleaning procedures on a timely basis, your grill will be kept clean and working properly with minimum effort. BURNER CLEANING...
- Page 7 1. Remove burner from the grill bowl (See drawing on right). Bend a stiff wire (a light-weight coat hanger works well) into a small hook as shown below. Run the hook through each burner tube and burner several times. 2. Use a narrow bottlebrush with a flexible handle. Run the hook through each burner tube and burner several times. 3.
-
Page 8: Lighting & Operating Instructions
1. Place stainless steel heat shields on lowest ledge under / between burners in grill bowl. (See illustrated drawing on PAGE 16) 2. Place stainless steel flame tamers on lower ledge above burners in grill bowl. 3. Place cooking grids in grill bowl on ledge above flame tamers. NOW YOUR GAS GRILL IS READY TO USE. - Page 9 FLAME. (Gas Leak Check instructions are on page 2). 5. Always open lid before lighting. 6. Set ALL BBQ Grill control knobs to “OFF” and open gas supply, LP cylinder or Natural Gas Valve. 7. Ignite only the burners you intend to use, using the same method for each: Push in control knob fully and rotate slowly (3 to 4 seconds) about 1/4 turn to the left (counter clockwise) until a click is heard.
- Page 10 Preheating: It is necessary to preheat the grill for a short time before cooking certain foods, depending on the type of food and the cooking temperature. Food that requires a high cooking temperature needs preheat for five minutes; food that requires a lower cooking temperature needs only a period of two to three minutes.
-
Page 11: Cleaning & Maintenance
Since indirect heat is often used in cooking on a rotisserie, a foil or aluminum drip pan is advisable to prevent excessive flare-ups. The cooking grills are removed to allow for the swing of the rotisserie. A basting pan is placed under the rotisserie area on top of the flame tamer(s) to catch the drippings. -
Page 12: Troubleshooting
IMPORTANT: Gas control knobs should be in the “OFF” position, and the fuel line should be disconnected from the gas valve manifold. To reduce the chance of FLASHBACK, the procedure below should be followed at least once a month or when your grill has not been used for an extended period of time. -
Page 13: Parts List
pliers. Carefully lift each burner up and away from gas valve orifice. Remove the orifice from each burner up and away from gas valve and gently clear any obstruction with a fine wire. Re-install each orifice, reinstall burners over orifices and seat each burner peg into mounting bracket at bottom of grill bowl. - Page 14 Steel Burner Flame Tamer Grill Light Lens Clip 10. Cooking Grid Light Bulb – 20 W Max. 11. Warming Rack Grill Light Switch 12. Lid Handle Grill Light Fixture - Right 13. Warming Rack Transformer Support 14. Flame Tamer SWITCH BOX Support 15.
-
Page 15: Warranty
LIMITED WARRANTY Bull Outdoor Products, Inc. warrants to the original purchaser at the original site of delivery with proof of purchase of each Outdoor Gas Grill that when subject to normal residential use, it is free from defects in workmanship and materials for the periods specified below. This warranty excludes grills used in rental or commercial applications. - Page 16 Our obligation under this warranty is limited to repair or replacement, at our option, of the product during the warranty period. The extent of any liability of Bull Outdoor Products, Inc., under this warranty is limited to repair or replacement. This warranty does not cover normal wear of parts, damage resulting from any of the following: negligent use or misuse of the product, use on improper fuel/gas supply, use contrary to operating instructions, or alteration by any person other than our factory service center.
Need help?
Do you have a question about the BRAHMA 1568X and is the answer not in the manual?
Questions and answers