Subscribe to Our Youtube Channel
Related Manuals for Bull 48050
Summary of Contents for Bull 48050
- Page 1 STALLION 4 BURNER GRILL OWNERS MANUAL MODEL # 48050 LIQUID PROPANE (LP) MODEL # 48051 NATURAL GAS (NG)
- Page 2 TABLE OF CONTENTS PAGE # 2 HOW TO REGISTER YOUR GRILL HOW TO ORDER GRILL REPLACEMENT PARTS GRILL DETAILS REPLACEMENT PARTS LIST REPLACEMENT PARTS ILLUSTRATION OPERATIONAL SAFETY SAFETY INSTRUCTIONS CHECKING FOR GAS LEAKS LIQUID PROPANE SAFETY GUIDELINES NATURAL GAS SAFETY GUIDELINES SAFETY GUIDELINES FOR GRILL INSTALLATION GRILL INSTALLATION AND OVER HEAD VENTILATION GRILL VENTILATION FOR OUTDOOR KITCHENS...
- Page 3 HOW TO ORDER REPLACEMENT PARTS The following information is required before contacting your Bull Authorized Dealer to assure getting the correct part(s) for your Grill or Rotisserie. Gas grill model number and type of gas hook up used as stated on your Grill’s data sticker which is located on the right side of the grease tray drawer...
- Page 4 STALLION GRILL PARTS LIST MODELS #48050 LP (LIQUID PROPANE) & #48051 NG (NATURAL GAS) PLEASE NOTE: YOUR GRILL SERIAL NUMBER WILL BE REQUESTED WHEN ORDERING ANY ITEM WITH A NEXT TO IT. WARRANTY PERIOD DWG REF # BULL PART #...
- Page 6 STALLION GRILL OPERATIONAL SAFETY SAFETY INSTRUCTIONS WARNING! FOR YOUR SAFETY, FOLLOW THE GUIDELINES BELOW: BEWARE OF CLOGGED BURNERS DUE TO SPIDER WEBS YOUR GAS GRILL IS ONLY FOR OUTDOOR USE. CAUTION: BURNERS MUST BE INSPECTED AND CLEANED BEFORE FIRST USE PROTECT CHILDREN: DO NOT ALLOW CHILDREN TO Spiders and small insects occasionally spin webs or make nests OPERATE GRILL.
- Page 7 STALLION GRILL OPERATIONAL SAFETY, CONTINUED DANGER! IF YOU SMELL GAS, FOLLOW THE GUIDELINES BELOW: 1) Visually check burner flame status, and pilot burner flame if provided. 2) NEVER test for gas leaks with a lighted match or open flame. 3) Shut off gas source to the appliance. 4) Extinguish any open flame.
- Page 8 PART # 48094) ARE SUPPLIED AND MUST BE USED WITHOUT ALTERATION AND SHOULD ONLY BE USED ON YOUR STALLION GRILL. 15) IF THE HOSE ASSEMBLY OR HOSE CLIP NEED TO BE REPLACED, USE ONLY THE BULL PART NUMBERS SHOWN IN THE PARTS LIST SUPPLIED WITH THIS UNIT.
- Page 9 LIQUID PROPANE GAS TO NATURAL GAS CONVERSION Gas valves are pre-set at the Bull factory to operate on LP Gas or Natural Gas. If you wish to convert to a different gas type, other than LP or NG, be sure to contact your grill dealer, licensed plumber or authorized service center for further details.
- Page 10 Bull purchase last longer. IMPORTANT: Bull Outdoor Products does not recommend the use of any quick connect fittings or lines to the unit. Use of these types of fittings or lines could cause low gas flow and greatly reduce the performance of the unit.
- Page 11 INSTALLATION INSTRUCTIONS REGARDING GRILL VENTILATION PLEASE READ THESE INSTRUCTIONS BEFORE INSTALLING YOUR GAS GRILL In the United States your gas grill must be installed in accordance with local codes or, per the latest edition of the NFPA 54/ANSI (Z223.1) National Fire Prevention Association In Canada, your gas grill must be installed in accordance with local codes or, per the latest edition of the Canadian Standards Association Code CGA B149.2 for Natural Gas and Propane Installation of Gas Burning Appliances and Equipment...
- Page 12 LIQUID PROPANE TANK STORAGE AREA MUST BE ISOLATED FROM GRILL AND VENTED. GRILL VENTILATION INSTRUCTIONS WHEN USING AN OUTDOOR KITCHEN Upper and lower level vents must be provided for combustion air on both sides of built-in cabinet. Vents on Grill insert must remain unobstructed to allow for combustion air and ventilation.
- Page 14 GUIDELINES FOR INSTALLING LP GRILL INTO AN OUTDOOR KITCHEN Vents must be provided for combustion air and ventilation on both sides of built-in cabinet. When choosing a location for your gas grill keep in mind that it should never be located under any overhead combustible construction.
- Page 15 Below are guidelines and illustrations for an LP Tank enclosure and how to install a Tank Retention System which can be obtained through your Bull Dealer: Any Tank Retention system must be secured to the floor using bolts and nuts or lock washers.
- Page 16 A suitable coating of corrosion protection will retard the effects of corrosion and help your Bull purchase last longer. IMPORTANT: Bull Outdoor Products does not recommend the use of any quick connect fittings or lines to the unit.
- Page 17 GRILL ‘FIRST USE’ LIGHTING PROCEDURE • DO NOT SMOKE WHILE LIGHTING GRILL OR CHECKING GAS SUPPLY • CONNECTIONS BECOME FAMILIAR WITH THE SAFETY GUIDELINES AT THE FRONT OF THE MANUAL • DO NOT LEAVE GRILL UNATTENDED DURING USE IMPORTANT! FOLLOW THE STEPS BELOW BEFORE FIRST USE OR AT START OF NEW GRILLING SEASON 1) If your grill fuel source is LP, check the gas cylinder to see if it’s full.
- Page 18 GRILL STANDARD LIGHTING PROCEDURE: Always open lid before lighting. Do not move the appliance when it is in use. DO NOT SMOKE WHILE LIGHTING GRILL OR CHECKING GAS SUPPLY CONNECTIONS! 1) Set ALL BBQ Grill control knobs to “OFF” and open gas supply, LP cylinder or Natural Gas Valve. 2) Ignite only the burners you intend to use, using the same method for each as follows: a.
- Page 23 BURNER SHUTTER CLIP INSPECTION / ADJUSTMENT The burners are set to a factory setting; however, the air to fuel mixture may need to be adjusted to accommodate different gas pressures. In order to adjust the air to fuel mixture, loosen the screw and rotate the shutter clip to the appropriate setting (see illustration on right).
- Page 25 IMPORTANT: DO NOT line the bottom of the grill housing with aluminium foil, sand or any other grease absorbent substance. Grease will not be able to drip down into the grease collector and a grease fire could occur. It is that you use Bull Grease Tray Liners for ease clean up and maintenance.
- Page 27 Bull Outdoor Products, Inc. warrants to the original purchaser at the original site of delivery with proof of purchase of each Outdoor Gas Grill that when subject to normal residential use, it is free from defects in workmanship and materials for the periods specified below.
Need help?
Do you have a question about the 48050 and is the answer not in the manual?
Questions and answers