Table of Contents
Advertisement
Safety-related information
1
Safety-related information
Before using this product, carefully read these instructions for use and those
of the associated products.
Strictly follow the instructions for use. The user must fully understand and
strictly observe the instructions. Use the product only for the purposes
specified in the intended use section of this document.
Do not dispose of the instructions for use. Ensure that they are retained and
appropriately used by the product users.
Only trained and competent users are permitted to use this product.
Comply with all local and national rules and regulations associated with this
product.
Only trained and competent personnel are permitted to inspect, repair and
service the product. Dräger recommends taking out a service contract with
Dräger and having all maintenance work carried out by Dräger.
Use only genuine Dräger parts and accessories for maintenance work.
Otherwise, the proper functioning of the product may be impaired.
Do not use a faulty or incomplete product. Do not modify the product.
Notify Dräger in the event of any product or component fault or failure.
2
Conventions used in this document
Definition of alert icons
The following alert icons are used in this document to denote and highlight areas
of warning text that require greater awareness from the user. The meanings of
the alert icons are defined as follows:
WARNING
!
Indicates a potentially hazardous situation. If not avoided, it could
result in death or serious injury.
CAUTION
!
Indicates a potentially hazardous situation. If not avoided, it could
result in physical injury, or damage to the product or environment. It
may also be used to alert against unsafe practices.
NOTICE
i
i
Indicates additional information on how to use the product.
Brand names
This document uses the following brand names:
®
®
FPS
, HPS
, Panorama Nova
trademarks of Dräger.
®
Zytron
is a registered trademark of Kappler, Inc.
3
Description
The Dräger CPS 5900 is a type 1a, gas-tight chemical protective suit.
For the breathing air supply, self-contained (open-circuit) breathing apparatus
(SCBA) with a suitable full face mask is required. The breathing air supply and
protective helmet are worn under the chemical protective suit.
The chemical protective suit can be equipped with the Dräger Air-Connect
ventilation unit. This allows the suit to be connected (via automatic changeover
switch, Y-piece or directly) to an external breathing air source and to the SCBA
to provide the person wearing the chemical protective suit with additional
breathing air.
The gas-tight zip runs from the head to the lower leg on the left side of the front
and has a cover flap.
The chemical protective suit is equipped with a glove combination. It consists of
a foil and a butyl glove. Kevlar overgloves can be worn over the glove
combination.
The chemical protective suit also features sewn-in socks made from the same
suit material. The socks by themselves do not provide any protection from
mechanical stresses. The user must also wear suitable protective boots. A cuff
prevents the penetration of substances between the socks and protective boots.
If the chemical protective suit is used in accordance with NFPA 1990 (1994) -
class 2, the following personal protective equipment must be worn:
SCBA in accordance with NFPA 1981 with CBRN approval in accordance
with NIOSH
Nomex/leather flight glove, Kappler RM 80612 overgloves
OnGuard Hazmax protective boots #87012 or Tingley protective boots
#82330.
4
®
®
®
®
, PAS
, PSS
and X-plore
are registered
Marking with a waterproof pen is possible.
3.1
Intended use
The chemical protective suit protects against gaseous, liquid, aerosol and solid
chemicals. It also protects against the incorporation of radioactive particles.
3.2
Limitations on the intended use
The chemical protective suit must no longer be used if it has been contaminated
or, for reasons of hygiene, had to be cleaned.
The chemical protective suit does not offer any protection against radiation of
radioactive particles or radiation damage.
The chemical protective suit must not be used if it is damaged or worn.
Certain chemicals (e.g. short-chain ketones and halogenated hydrocarbons) are
subject to incident time restrictions depending on concentration, state of matter
and ambient conditions. For information on mechanical and chemical resistance
as well as on temperature resistance, see section 8 on page 7.
Avoid heat and open flames. The chemical protective suit is not suitable for fire
fighting. For permissible application temperatures, see section 8 on page 7.
WARNING
!
This chemical protective suit does not provide protection against all
chemical and hazardous substances in any situation and environment.
All decisions relating to gas and chemical protective clothing and its
use must be made by trained and qualified safety experts. It is the
responsibility of the user to assess the degree of exposure as well as
the need for necessary personal protective equipment. Most of the
performance characteristics of a chemical protective suit cannot be
tested in practical use.
3.3
Approvals
The chemical protective suit is approved according to the following standards
and directives:
NFPA 1990 (1994) - class 2, 2022 edition
Declaration of conformity: see www.draeger.com/product-certificates
3.4
Tested personal protective equipment
NOTICE
i
i
Only the following combinations of protective equipment are
recommended.
For
independently determine whether such combination is appropriate.
3.4.1 Full face masks
Dräger FPS 7000 RA
Dräger FPS 7000 P
Panorama Nova series
f2 series
3.4.2 SCBA
PSS N series
PSS P series
3.4.3 Protective helmets
Dräger HPS 4000 series
Dräger HPS 6000 series
Dräger HPS 7000 series
3.4.4 Ventilation system
Dräger Air-Connect
Dräger has tested the Dräger Air-Connect with hydrogen chloride based on
ISO 16602 (permeation measurement) and achieved class 6.
3.5
Explanation of symbols
The following symbols and text appear on the name plate:
Symbol/text
other
combinations,
the
operator
Explanation
Caution! Follow the instructions
for use.
Protective
clothing
gaseous, liquid, aerosol and
solid chemicals
Dräger CPS 5900
must
against
Advertisement
Table of Contents
