Rear Cover And Ac Cover Removal - Sony KDL-40NX725 Service Manual

REAR COVER AND AC COVER REMOVAL

CAUTIONS:
Do not damage the Power Board Connector and Power Supply Cord when removing the Rear Cover.
Refer to "Removing the Power Cord from the Rear Cover" on page A-4
The Rear Covers on the models listed have sharp edges. Use caution when handling the Rear Cover
to avoid injury. Refer to "Rear Cover Caution" on page A-1
NOTE: The Label (BAT-L Metal Side), Label (BAT-L Metal Bottom) and Sheet, Ant(C EL) are not
included with the Rear Cover and must be replaced when replacing the Rear Cover.
A Remove screws from Rear Cover
8 from KDL-40NX725Only
11 from KDL-55NX725 Only
12 from KDL-60NX725 Only
B Remove 2 screws from Rear Cover (KDL-60NX725 Only)
C Remove 6 screws from Rear Cover
D Remove 1 screw from Side Bracket position
E Remove screws from Terminal Area position
1 from KDL-40NX725 Only
2 from KDL-55NX725/60NX725 Only
F Remove 2 screws from Rear Cover
G Remove 1 screw and release clips from AC Cover to detach from Rear Cover
(Refer to "Removing the Power Cord from the Rear Cover" on page
H Remove screws from Rear Cover
4 from all models except KDL-60NX725
5 from KDL-60NX725 Only
I
Gently peel-off Antenna Sheet to detach from Rear Cover
J Release 1 clip and lift up Antenna Cover to detach from Rear Cover
K Gently lift up Rear Cover form bottom side to detach from Center Cabinet
A
B
G
KDL-40NX725/55NX725/60NX725
SECTION 6 - DISASSEMBLY/PART NUMBER INFORMATION
for complete instructions.
for complete instructions.
A-4)
C
D
E
F
K
I J
H
NOTE: The components identified by shading
and mark are critical for safety. Replace only
!
with part number specified.
51
52
REF. NO. PART NO. DESCRIPTION [ASSEMBLY INCLUDES]
51 4-268-423-22 REAR COVER (40 EL) A
(KDL-40NX725 ONLY)
51 4-268-427-22 REAR COVER (55EL) A
(KDL-55NX725 ONLY)
51 4-268-428-22 REAR COVER (60EL) A
(KDL-60NX725 ONLY)
52 4-259-168-01 COVER, AC(M)
53 4-268-431-01 SHEET, ANT(C EL)
ORDER THIS PART WHEN REPLACING THE REAR COVER
54 4-256-676-01 COVER ANT (L EL)
NOTE: The components identified by a red outline and a mark contain
confidential information. Specific instructions must be adhered to whenever
these components are repaired and/or replaced.
See Appendix A: Encryption Key Components in the back of this manual.
56
55
53 54
REF. NO. PART NO. DESCRIPTION [ASSEMBLY INCLUDES]
55 4-265-069-01 LABEL (BAT-L METAL BOTTOM)
ORDER THIS PART WHEN REPLACING THE REAR COVER
56 4-256-433-12 LABEL, (BAT-L METAL SIDE)
ORDER THIS PART WHEN REPLACING THE REAR COVER
4-256-393-01 SCREW, +PSW M3X6 W12
2-580-639-01 SCREW, +BVTP 4X12 TYPE2 IT-3
4-257-907-01 JOINT, STAND
4-268-126-02 SCREW, ORNAMENTAL M6X12
4-258-272-01 SCREW, +PWH M3X8
7-685-646-79 SCREW, +BVTP 3X8 TYPE2 IT-3
43