Rear Cover And Ac Cover Removal; Appendix A - Removing The Rear Cover - Sony KDL-40NX725 Service Manual

REAR COVER AND AC COVER REMOVAL

CAUTIONS:
Do not damage the Power Board Connector and Power Supply Cord when removing the Rear Cover.
(Refer to "Appendix A - Removing the Rear Cover" on page
The Rear Covers on the models listed have sharp edges. Use caution when handling the Rear Cover
to avoid injury. (Refer to "Appendix B - Attaching the Rear Cover" on page
NOTE:
The Label (BAT-L Metal Side), Label (BAT-L Metal Bottom) and Sheet, Ant(C EL) are not included
with the Rear Cover and must be replaced when replacing the Rear Cover.
A Remove 8 screws from Rear Cover
B Remove 6 screws from Rear Cover
C Remove 1 screw from Side Jack position
D Remove screws from Terminal Area position
1 from KDL-40NX725 Only
2 from KDL-46NX725Only
E Remove 2 screws from Rear Cover
F Remove 1 screw and release clips from AC Cover to detach from Rear Cover
(Refer to "Removing the Power Cord from the Rear Cover" on page ?)
G Remove 4 screws from Rear Cover
H Gently peel-off Antenna Sheet to detach from Rear Cover
I Release 1 clip and lift up Antenna Cover to detach from Rear Cover
J Gently lift up Rear Cover from bottom side to detach from Center Cabinet
A
B
E
F
G
KDL-40NX725/46NX725
SECTION 6 - DISASSEMBLY/PART NUMBER INFORMATION
A-1.)
B-1.)
C
D
J
H I
NOTE: The components identified by shading
and mark are critical for safety. Replace only
!
with part number specified.
51
52
REF. NO. PART NO. DESCRIPTION [ASSEMBLY INCLUDES]
51 4-268-422-02 REAR COVER (40 EL) A
(KDL-40NX725 ONLY)
51 4-268-424-01 REAR COVER (46 EL) A
(KDL-46NX725 ONLY)
52 4-266-269-01 COVER, AC(M)
53 4-268-431-11 SHEET, ANT(C EL)
ORDER THIS PART WHEN REPLACING THE REAR COVER
54 4-263-659-01 COVER, ANT(L EL)
NOTE: The components identified by a red outline and a mark contain
confidential information. Specific instructions must be adhered to whenever
these components are repaired and/or replaced.
See Appendix A: Encryption Key Components in the back of this manual.
56
55
53 54
REF. NO. PART NO. DESCRIPTION [ASSEMBLY INCLUDES]
55 4-265-069-11 LABEL (BAT-L METAL BOTTOM)
ORDER THIS PART WHEN REPLACING THE REAR COVER
56 4-256-433-02 LABEL, (BAT-L METAL SIDE)
ORDER THIS PART WHEN REPLACING THE REAR COVER
4-256-393-01 SCREW, +PSW M3X6 W12
2-580-639-01 SCREW, +BVTP 4X12 TYPE2 IT-3
4-257-907-01 JOINT, STAND
4-268-126-02 SCREW, ORNAMENTAL M6X12
4-258-272-01 SCREW, +PWH M3X8
7-685-646-79 SCREW, +BVTP 3X8 TYPE2 IT-3
43