Off-Season Storage - TOHATSU MFS 2.5C Owner's Manual

54
INSPECTION AND MAINTENANCE
ENOM00100-A

3. Off-season storage

ENOW00934-0
Be sure to disconnect fuel connector
except when operating engine.
Fuel leakage is a fire or explosion hazard,
which can cause serious injury or death.
ENOW00097-0
Be sure to use cloth to remove fuel remain-
ing in the cowl and dispose of it in accor-
d an c e w i t h l o c a l f ir e pr e ve n t i o n an d
environment protection regulations.
Before you put your outboard motor in
storage, it is a good opportunity to have
it serviced by your dealer.
Be sure to use fuel stabilizer while run-
ning the motor before storage. (See
page 55)
ENOM00101-1C
Engine
1. Wash the engine exterior and flush
the cooling water system thoroughly
10
with fresh water. Drain the water
completely.
Wipe off water with a cloth.
2. Remove the fuel hose from the out-
board motor or close the fuel cock.
3. Drain all fuel from the fuel hoses, fuel
pump, fuel filter (see page 56) and
carburetor (See page 56), and clean
these parts.
WARNING
WARNING
Keep in mind that if gasoline is kept in
the carburetor for a long time, gum
and varnish will be developed, causing
the float valve to stick, restricting the
fuel flow.
4. Remove the spark plugs and put a
teaspoon of engine oil or spray stor-
age oil into the combustion chamber
through the spark plug holes.
5. Pull the recoil starter several times to
lubricate inside the cylinder.
ENOW00930-1
WARNING
Be sure to remove stop switch lock to
prevent the spark plugs from igniting.
Put a cloth to spark plug hole and wipe up
any spilled engine oil, when cranking the
outboard motor.
6. Change the engine oil (See page 47).
7. Change the gear oil in the gear case
(See page 49).
8. Apply grease to grease point (See
page 53).
9. Place the outboard motor in the ver-
tical position under a dry condition.
ENOF01614-1