Table of Contents
Advertisement
PRECAUTIONS AND GENERAL NOTES
PRECAUTIONS AND GENERAL NOTES
GENERAL WARNINGS AND SAFETY INFORMATION
ELECTRICAL
There are no user-serviceable parts in the power adapter or controller. In the event of
a failure, these parts should be replaced.
• All electrical connections must be completed according to local codes.
• Only use AC power adapter supplied with the unit.
• The power outlet must be grounded.
• To disconnect power, unplug the AC adapter from its power source.
MECHANICAL
• Do not use petroleum based lubricants such as Vaseline, oils, or hydrocarbon
based lubricants. Use only 100% silicone lubricants.
• All plastic connections should be hand tightened. Thread sealing tape may be
used on fittings that do not use an O-ring seal. Do not use pliers or pipe wrenches.
• All plumbing must be completed according to local codes.
• Observe drain line requirements.
• Use Teflon* tape on all threaded connections, do not use any other type of thread
sealant.
(*Teflon is a trademark of E.I. DuPont de Nemours.)
GENERAL
• Observe all warnings that appear in this manual.
• All plumbing and electrical codes must be complied with when installing this product.
• Keep the unit in an upright position. Do not turn on its side, upside down, or drop.
• Maximum ambient temperature for the location and operation of the unit is 49°C.
• This system is suitable for installation on a cold water supply. The operating water
temperature is between 5°C and 38°C. Installation of this system on a hot or warm
water supply is not permitted.
• Working water pressure range is 210 – 500 kPa (30 – 73 PSI).
• Do not allow this water filtration system to freeze. Damage from freezing will void
the warranty.
• The Pentair series UV filtration system can be installed outdoors or indoors.
2
Pentair UV Series Water Treatment & Microfiltration System User Manual
FILTER COMPONENTS IN THE PACKAGE
4
Ensure that all parts are included in the box. All water filter models contain
the following:
B
7
8
10
11
9
A
ITEM
DESCRIPTION
1
UV Lamp Ballast
2
Quartz Oring
3
UV Lamp
4
Quartz Sleeve
5
Elbow
4
QF-RD-002-A
6
SS Braided Hose
7
BSPT 01" Housing Cap
8
O-RING, BB, BUNA-N, 70 DURO
9
Housing Sump
10
Pre Filter Cartridge
11
Post Filter Cartridge
PARTS INCLUDED
3
1
2
3
4
6
5
DATE AND TIME
LAST SAVED IN SMARTEAM:
CRITICALITY SYMBOLS PER QPSP-001.2
LEVEL I
LEVEL II
PART NUMBER
THIS DOCUMENT IS SOLELY THE PROPERTY OF PENTAIR
RESIDENTIAL FILTRATION, LLC. REPRODUCTION, USE DISCLOSURE
OR TRANSMISSION OF THIS DOCUMENT OR DETAILS CONTAINED
HEREIN, IN PART OR IN WHOLE, IS PROHIBITED WITHOUT THE
BHML002
WRITTEN CONSENT OF PENTAIR RESIDENTIAL FILTRATION, LLC
ENGINEERING. THIS DOCUMENT AND ANY COPIES SHALL BE
RETURNED TO PENTAIR RESIDENTIAL FILTRATION, LLC UPON
BHML006
WRITTEN REQUEST.
DO NOT SCALE DRAWING. DIMS. ARE IN INCHES [mm]
BHML003
INTERPRET DIMS AND TOLERANCES PER ASME Y14.5M -1994
UNLESS OTHERWISE SPECIFIED:
TOLERANCES:
BHML004
ANGLES :
1
1 PLACE .X:
0.015 [0.38]
2 PLACE .XX:
0.01 [0.3]
BHML009
3 PLACE .XXX:
0.005 [0.13]
3
BHML010
SA11202-9904001
143273
153114
Please refer to Spare Parts list on
page 16 for relavant Cartridge part.
Pentair UV Series Water Treatment & Microfiltration System User Manual
LEVEL III
D
C
A
3
Advertisement
Table of Contents
