Subscribe to Our Youtube Channel
Related Manuals for TLV DC3-H
Summary of Contents for TLV DC3-H
- Page 1 172-65217MA-06 (DC3-H) 7 October 2021 Cyclone Separator DC3-H Copyright © 2021 by TLV CO., LTD. All rights reserved...
-
Page 2: Table Of Contents
If detailed instructions for the special order specifications or options not contained in this manual are required, please contact TLV for full details. This instruction manual is intended for use with the model(s) listed on the front cover. -
Page 3: Safety Considerations
The three types of cautionary items above are very important for safety: be sure to observe all of them as they relate to installation, use, maintenance, and repair. Furthermore, TLV accepts no responsibility for any accidents or damage occurring as a result of failure to observe these precautions. - Page 4 Use only under conditions in which no water hammer will occur. The impact of water hammer may damage the product, leading to fluid discharge, which may cause burns or other injury. 172-65217MA-06 (DC3-H) 7 Oct 2021...
-
Page 5: Specifications
Outlet Outlet Cover Separator Body Gasket Cover Nut Guide Pin Body Bolt Cover Bolt Cover Gasket Wave Spring Body Nut Float Cover Float Cover Bolt Spring Washer Air/Steam Trap Condensate Nameplate Condensate Outlet Outlet Outlet 172-65217MA-06 (DC3-H) 7 Oct 2021... - Page 6 Separator Body Separator Guide Pin Body Bolt Body Nut Body Gasket Baffle* Baffle Bolt Baffle Nut Nameplate *Cannot be detached as the baffle nuts and bolts are welded on. Air/Steam Trap Condensate Condensate Outlet Outlet Outlet 172-65217MA-06 (DC3-H) 7 Oct 2021...
-
Page 7: Installation
4. Install the product so the arrow on the product is pointing in the direction of flow. 5. The product should be inclined no more than 10° horizontally and front-to-back. 6. Install an air trap or steam trap at the condensate outlet. Use of the TLV free float type trap is advised. -
Page 8: Maintenance
Align with bolts and set on float cover Float Cover Bolt Remove with a socket wrench Consult the table of tightening torques and (Spring Washer) tighten to the proper torque Float Cover Remove by lifting up and off Place it into position 172-65217MA-06 (DC3-H) 7 Oct 2021... - Page 9 , 3) (15) (1 Nm 10 kgcm) NOTE: -Coat all threaded portions with anti-seize. -If drawings or other special documentation were supplied for the product, any torque given there takes precedence over values shown here. 172-65217MA-06 (DC3-H) 7 Oct 2021...
- Page 10 15 – 50 mm ( – 2 in) Body Cover Bolt Separator Wave Spring Body Gasket Guide Pin Separator Body Body Nut Body Bolt Float Cover Float Cover Bolt Spring Washer Cover Gasket Guide Pin Cover Cover Nut 172-65217MA-06 (DC3-H) 7 Oct 2021...
- Page 11 Body Cover Bolt Separator Wave Spring Body Gasket Guide Pin Separator Body Body Nut Body Bolt Cover Gasket Baffle Nut Baffle Float Cover Bolt Baffle Bolt Spring Washer Float Cover Guide Pin Cover Cover Nut 172-65217MA-06 (DC3-H) 7 Oct 2021...
- Page 12 150 mm (6 in) Body Body Bolt Separator Body Gasket Guide Pin Separator Body Body Nut 172-65217MA-06 (DC3-H) 7 Oct 2021...
-
Page 13: Troubleshooting
Water is mixed in Steam/air flow velocity is too high Take steps necessary to lower with the steam or the steam/air flow velocity air from the Improper installation Correct the installation separator outlet 172-65217MA-06 (DC3-H) 7 Oct 2021... -
Page 14: Tlv Express Limited Warranty
TLV; or 4. disasters or forces of nature or Acts of God; or 5. abuse, abnormal use, accidents or any other cause beyond the control of TLV, TII or TLV group companies; or 6. improper storage, maintenance or repair; or 7. - Page 15 WARRANTY NOT NEGATED HEREBY, AND ANY IMPLIED WARRANTY NOT NEGATED HEREBY, INCLUDING THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE, DO NOT COVER, AND NEITHER TLV, TII NOR ITS TLV GROUP COMPANIES WILL IN ANY EVENT BE LIABLE FOR, INCIDENTAL OR...
-
Page 16: Service
Service For Service or Technical Assistance: Contact your TLV representative or your regional TLV office. In Europe: Tel: [49]-(0)7263-9150-0 Daimler-Benz-Straße 16-18, 74915 Waibstadt, Germany Fax: [49]-(0)7263-9150-50 Tel: [44]-(0)1242-227223 Units 7 & 8, Furlong Business Park, Bishops Cleeve, Gloucestershire GL52 8TW, U.K.
Need help?
Do you have a question about the DC3-H and is the answer not in the manual?
Questions and answers