Ford TOURNEO COURIER Owner's Manual page 106

Filling the AdBlue® Tank Using a
Fuel Station Pump
WARNING: Do not allow diesel
exhaust fluid (AdBlue) to come into
contact with eyes, skin or clothing.
Should the fluid come into contact with
eyes, flush them with plenty of water and
seek medical attention. Clean affected
skin with soap and water. If swallowed,
drink plenty of water and seek medical
attention immediately.
WARNING: Refill the diesel exhaust
fluid (AdBlue) tank in a well-ventilated
area. When removing the tank cap or a
container cap, ammonia vapor may
escape. Ammonia vapor is an irritant to
the eyes, skin and mucous membranes.
Inhaling ammonia vapor can cause
burning to the eyes, throat and nose
resulting in watering eyes or severe
coughing.
Filling the AdBlue® tank using a fuel
station pump is similar to refueling your
vehicle.
1. Fully open the fuel filler door.
E268809
2. Remove the AdBlue® tank filler cap.
3. Fully insert the AdBlue® pump nozzle.
Tourneo Courier/Transit Courier (C4A) Vehicles Built From: 16-09-2021, CG3822en enGBR, Edition date: 202106, First-Printing
Engine Emission Control
102
E268817
4. Operate the AdBlue® pump nozzle
within the area shown.
Note: The pump nozzle shuts off when the
tank is full.
5. Slightly raise the AdBlue® pump nozzle
and then slowly remove it.
6. Replace the AdBlue® tank filler cap.
Turn it clockwise until you feel a strong
resistance and it clicks.
Do not attempt to start the engine if you
have filled the AdBlue® tank with incorrect
fluid. Incorrect fluid use could cause
damage not covered by the vehicle
Warranty. Have your vehicle checked as
soon as possible.
Filling the AdBlue® Tank Using a
Container
WARNING: Do not allow diesel
exhaust fluid (AdBlue) to come into
contact with eyes, skin or clothing.
Should the fluid come into contact with
eyes, flush them with plenty of water and
seek medical attention. Clean affected
skin with soap and water. If swallowed,
drink plenty of water and seek medical
attention immediately.