Page 2
The use of non-OEM replacement parts will void (or negate) agency certifications, including CE, ATEX, CSA, 3A and EC1935 compliance (Food Contact Materials). Warren Rupp, Inc. cannot ensure nor warrant non-OEM parts to meet the stringent Use safe practices when lifting requirements of the certifying agencies.
Page 4
Materials Material Profile: Operating Polypropylene: A thermoplastic polymer. Moderate tensile 180°F 32°F and flex strength. Resists stong acids and alkali. Attacked by 82°C 0°C Temperatures: chlorine, fuming nitric acid and other strong oxidizing agents. CAUTION! Operating temperature limitations are as follows: Max.
Page 5
SERVICE AND OPERATING INSTRUCTIONS Read these safety warnings and instructions in this manual completely, before This Warren Rupp Tranquilizer is a completely automatic diaphragm fitted ® installation and start-up surge suppressor to reduce the flow and pressure pulsations in a pumping system of the pulsation dampener.
Page 6
Recommended Installation Guide Available Accessories: 1. Surge Suppressor Unregulated Air 2. Filter/Regulator Supply to Surge Surge Suppressor Suppressor 3. Air Dryer Pressure Gauge Shut-Off Valve Pipe Connection Note: Surge Suppressor and (Style Optional) Piping must be supported after Flexible Connector Discharge the flexible connection Check...
Page 7
Troubleshooting Guide Symptom: Potential Cause(s): Recommendation(s): Pump Cycles Once Deadhead (system pressure meets or exceeds air Increase the inlet air pressure to the pump. Pump is designed for 1:1 pressure ratio at zero flow. supply pressure). (Does not apply to high pressure 2:1 units). Air valve or intermediate gaskets installed incorrectly.
Page 9
Composite Repair Parts List ITEM PART NUMBER DESCRIPTION QTY. 070.014.170 Bearing, Sleeve 095.078.156 Body 165.023.000 170.005.330 Capscrew, Hex Hd - 5/16-18 X 7/8 170.024.330 Capscrew, Hex Hd - 7/16-14 X 1 170.060.330 Capscrew, Hex Hd - 7/16-14 X 2 196.194.156 Chamber, Inner 196.195.156 Chamber, Outer - NPT...
Page 10
Material Codes - The Last 3 Digits of Part Number 000..Assembly, sub-assembly; 364..EPDM Rubber • Delrin and Hytrel are registered tradenames of E.I. DuPont. and some purchased items Color coded: BLUE 010..Cast Iron 365..Neoprene Rubber • Nylatron is a registered tradename 015..Ductile Iron Color coded: GREEN of Polymer Corp.
Page 11
Warren Rupp, Inc. (“Warren Rupp”) warrants to the original end-use purchaser that no product sold by Warren Rupp that bears a Warren Rupp brand shall fail under normal use and service due to a defect in material or workmanship within five years from the date of shipment from Warren Rupp’s factory.
Page 12
A Unit of IDEX Corporation 800 North Main Street Mansfield, OH 44902 USA Warren Rupp, Inc. declares that Air Operated Double Diaphragm Pumps (AODD) and Surge Suppressors listed below comply with the requirements of Directive 2014/34/EU and all applicable standards. Applicable Standards •...
Page 13
Declaration of Conformity Manufacturer: Warren Rupp, Inc., 800 N. Main Street, Mansfield, Ohio, 44902 USA certifies that SANDPIPER Air-Operated Double Diaphragm Food Processing Pump Models ® and Tranquilizer Surge Suppressor Models comply with the European Community Regulations: ® (EC) No 1935/2004 for Food Contact Materials...