Hoppe Audio Mini Installation Instructions & Owner's Manual
Off-road sound system for kawasaki mule pro models
Hide thumbs
Also See for Audio Mini:
- Installation instructions & owner's manual (20 pages) ,
- Installation instructions manual (18 pages) ,
- Installation instructions and owner's manual (18 pages)
Related Manuals for Hoppe Audio Mini
Summary of Contents for Hoppe Audio Mini
- Page 1 INSTALLATION INSTRUCTIONS / OWNER’S MANUAL: AUDIO MINI OFF-ROAD SOUND SYSTEM FOR KAWASAKI MULE PRO MODELS www.hoppeindustries.com 22667 FM 15 Troup, TX 75789 (262) 552-2770...
- Page 2 It is critical that proper eye wear, ear protection, and protective clothing is worn throughout the top installation. When you receive your Audio Mini off-road sound system, please check to ensure that all parts and hardware are included. If there are any parts missing or if you have any questions concerning the system at this time call Hoppe at (262)-552-2770 Mon-Thur.
-
Page 3: Table Of Contents
TABLE OF CONTENTS SECTION 1 – Tools Required .................... 4 SECTION 2 – About your Audio Mini sound system ............4 2.1 Applicable Year Models: ..................4 2.2 Audio Equipment Details: ..................4 2.3 Warranty: ........................5 2.4 Care and Maintenance: ..................... 5 2.5 Warnings: ........................ -
Page 4: Section 1 - Tools Required
SECTION 2 – About your Audio Mini sound system 2.1 Applicable Year Models: This Audio Mini off-road sound system is designed to fit the following Mule Pro models: 2015-2021 Mule Pro-FXT 2018-2021 Mule Pro-FXR ... -
Page 5: Warranty
2.3 Warranty: Your Audio Mini comes equipped with a 1 year limited warranty covering the light, the stereo equipment, and the fiberglass enclosure. The date of warranty coverage will be determined by the registration date of the warranty card or online warranty registration. -
Page 6: Warnings
Figure 2: Chassis harness ignition relay 2.5 Warnings: This off-road system adds up to 25 lbs. to your vehicle and is located up high on the roll cage. This increases the vehicle’s center of gravity and changes the vehicle dynamics and handling characteristics. -
Page 7: Section 3 - Pre-Installation Inspection
SECTION 3 – Pre-Installation Inspection Included in your off-road sound system are the following components: Pre-assembled Audio Mini off-road sound system (All speakers and electronics come preinstalled with interior wire harness.) Chassis wire harness Mounting brackets Hardware bag ... -
Page 8: Section 4 - Installation
Figure 4: Factory roof mounting bolt. 2. Place the bracket on the inside of the cross member. Use the supplied M10 bolts, and loosely tighten them to allow for adjustment of the Audio Mini placement. Verify correct orientation of the mounting bracket. See Figure 5. - Page 9 25 lbs. Since you will have to lift overhead and bolt each end, it is helpful to have an assistant for this step. See Figure 6 and Figure 7. Figure 6: Install the ¼”-20 bolts and washers to mount the Audio Mini to the brackets. Revision B...
- Page 10 Figure 7: Loosely install the sound system on the mounting brackets. 5. Tighten the 4 cross member bolts so that the Audio Mini is evenly spaced away from the front cross member. See Figure 8. REAR FRONT Figure 8: Audio Mini evenly spaced away from cross member.
- Page 11 Figure 9: Up-down positioning of the Audio Mini. 7. Connect the chassis harness and the sound system harness by running the chassis harness above the front cross member. See Figure 10. Figure 10: Connect the chassis harness to the sound system.
- Page 12 HARNESS BEHIND ROUTING SEAT BELT PATH BRACKET FRONT SIDE DOWN TUBE Figure 11: Route the chassis harness on the roll cage. 9. Remove the seat by lifting up on each end. The seat is snapped in place to two rubber grommets that will release with a slight tug. See Figure 12. Revision B 12 of 21...
- Page 13 Figure 12: Remove the seat. 10. Route the harness from the corner opening down the seat frame as shown in Figure 13. Revision B 13 of 21...
- Page 14 DOWN AND BACK TO LOWER CROSS MEMBER LOWER CROSS MEMBER IN OPEN SPACE UNDER FLOOR Figure 13: Route the harness down the seat frame. 11. Secure the harness to the lower cross member in the open space under the floor, behind the seat opening (next to the drive shaft).
- Page 15 FROM SEAT BACK TO FRAME ENGINE COMPARTMENT Figure 14: Secure the harness to the lower cross member. 12. You must tilt the bed to gain access to the engine compartment for the following steps. 13. Remove the battery compartment cover by unlatching the front and side latches. See Figure 15.
- Page 16 LATCHES Figure 15: Remove the battery compartment cover. 14. Route the harness from the lower cross member into the engine compartment, then run the black and red wires (with fuse holder) into the battery compartment through the hole in the black rubber divider. The orange wire will be routed further back in the next steps.
- Page 17 REAR FRONT RED AND BLACK LOOMED WIRES INTO THE BATTERY COMPARTMENT ROUTE ORANGE WIRE UNDER THIS BUNDLE Figure 17: Red and black harness wires go into the battery compartment. HARNESS PULLED TIGHT FROM LOWER CROSS MEMBER ZIP TIED TO LOOM FRONT REAR Figure 18: Secure the harness to the factory loom.
- Page 18 15. Connect the ring terminal on the RED wire of the Audio Mini harness to the + POST of the battery. See Figure 19. RED WIRE TO + POST Figure 19: Red harness wire battery connection. 16. Connect the ring terminal on the BLACK wire of the Audio Mini harness to the –...
- Page 19 TO LOOM Figure 21: Orange (accessory) harness wire routing. 18. Secure the orange wire from the Audio Mini harness to the factory wire loom as shown in Figure 22. Then plug the male bullet connector on the end of the orange wire into the mating female bullet connector on the brown wire with white stripe.
- Page 20 (if applicable), and lock the bed into position with both side latches. 20. You are now ready to enjoy the music and lighting provided by your Audio Mini off-road sound system. Basic operation works as follows: ...
- Page 21 and our extensive line of trike conversions, motorcycle, and power sports accessories. We believe you will be impressed by what you witness and the people you will meet. Revision B 21 of 21...
Need help?
Do you have a question about the Audio Mini and is the answer not in the manual?
Questions and answers