Page 1
Heated Stone Shelves GRSS & GRSSB Series Operating Manual This manual contains important safety information concerning the maintenance, use and operation of this product. Failure to follow the instructions contained in this manual may result in serious injury. If you’re unable to understand the contents of this manual, please bring it to the attention of your supervisor.
Serial No. ________________________________ Voltage __________________________________ Date of Purchase __________________________ INTRODUCTION The Hatco Glo-Ray Heated Stone Shelf is designed to safely hold food hot while blending into your décor. The Glo-Ray Heated Stone Shelf safely keeps all food at proper serving temperatures without affecting quality.
MODEL DESCRIPTIONS ALL MODELS All Hatco Heated Stone Shelves are ideal for pass through areas, buffet lines and as hors d’ oeuvre displays. The unique Heated Stone Shelf is constructed of Swanstone ® , available in several stock colors including Sawgrass, Gray Granite, Night Sky, and Bermuda Sand.
If the plug and receptacle do not match, contact a qualified electrician to determine the proper voltage and size and install the proper electrical outlet. DIMENSIONS - GRSS MODELS Width Depth Model GRSS-2418 24" (610 mm) (457 mm) GRSS-3018 30" (762 mm) (457 mm) GRSS-3618 36"...
GRSS MODELS 1. Remove unit from box. 2. Remove information packet. To prevent delay in obtaining warranty coverage, fill out and mail in the warranty card to Hatco. 3. Remove tape and protective packaging from all surfaces of unit. INSTALLATION...
Page 8
INSTALLATION Trim Mounting Ring Countertop Trim Mounting Ring MODEL MINIMUM WIDTH GRSSB-2418 24-1/2" (622 mm) GRSSB-3018 30-1/2" (775 mm) GRSSB-3618 36-1/2" (927 mm) Form No. GRSSM-0106 Figure 6. GRSSB Countertop Installation COUNTERTOP CUTOUT MAXIMUM WIDTH MINIMUM DEPTH 24-3/4" (629 mm) 18-1/2"...
Page 9
9. Locate the remote control box assembly in an area that is convenient for operation. If necessary, remove the end brackets from the control box, rotate and reposition them. The control box will require a hole mounting pattern of 7-5/8" x 1-1/4" (194 mm x 32 mm). See Figure 7 for mounting distances.
OPERATION WARNING Plug unit into a properly grounded electrical outlet of the correct voltage, size and plug configuration. If the plug and receptacle do not match, contact a qualified electrician to determine the proper voltage and size and install the proper electrical outlet. CAUTION Some exterior surfaces on the unit will get hot.
Some aftermarket or generic replacement characteristics that will allow them to operate safely in Hatco equipment. It is essential to use Hatco Replacement Parts when repairing Hatco equipment. Failure to use Hatco Replacement Parts may subject operators of the equipment to hazardous electrical voltage, resulting in electrical shock or burn.
TROUBLESHOOTING WARNING To avoid any injury or damage, the Heated Stone Shelf must only be serviced by qualified personnel. Symptom Unit too hot. Unit not hot enough. Unit not working at all. Form No. GRSSM-0106 To avoid any injury or damage to the unit turn the power switch OFF, unplug the unit and allow to cool before performing any maintenance or cleaning.
Hatco reserves the right to accept or reject any such claim in whole or in part. Hatco will not accept the return of any Product without prior written approval from Hatco, and all such approved returns shall be made at Buyer’s sole expense.
Cone’s Repair Service Flanders Moline 309-797-5323 P.O. Box 340500, Milwaukee, WI 53234-0500 U.S.A. Parts & Service Fax (800) 690-2966 Printed in U.S.A. January 2006 HATCO AUTHORIZED PARTS DISTRIBUTORS NEW YORK Acme American Repairs, Inc. 317-545-9655 Brooklyn Alpro Service Co. Brooklyn...