INDEX GENERAL SAFETY WARNINGS .... 5 3 TECHNICAL CHARACTERISTICS ..22 HANDLING AND STORAGE ..9 TECHNICAL DATA ....... 22 PACKAGING CONTENTS ... 11 OVERALL DIMENSIONS..... 22 PRIOR CHECKING 4 INSTRUCTIONS FOR USE ....23 AFTER RECEIPT ......11 POSITIONING ......12 SWITCHING ON ......
WARNINGS wilfully, etc., the putting back into ser- vice.must.be.carried.out.by.qualified. This manual is an integral part of the persons or out Carimali Service Cen- machine. tre. Before proceeding with installation, use and maintenance of the machine,...
Page 6
Keep packaging parts (box, inner pro- For more detailed information about tections, etc.) out of reach of children recycling of this product, contact the since they are potentially dangerous. local authority or the local waste dis- Do not dump those parts into the en- posal service.
Page 7
In case of fault or malfunctioning of the electric socket. machine, switch it off, unplug it and contact the Carimali Service Centre. Access to the service areas is re- stricted to those persons with the rel- evant practical experience, especially in terms of safety and hygiene.
Page 8
Service Centre or of.the.official.Carimali. the Manufacturer. website. The Manufacturer reserves the right NOTE to carry out technical and aesthet- The machine can be ic.
HANDLING AND STORAGE WARNING COFFEE MACHINES COFFEE MACHINES Made in Italy Made in Italy COFFEE MACHINES Made in Italy COFFEE MACHINES COFFEE MACHINES Made in Italy Made in Italy NOTE Handle the packaging by means of the apposite carrying han- dles.
Page 10
WARNING In case of prolonged storage at temperatures below 2°C, the water circuit in the machine must be drained. Do not switch the machine on before having reconditioned it for at least 1 hour at a suitable room temperature. If it is installed in areas with room temperature above 30°C, malfunctioning may occur.
PACKAGING CONTENTS Machine User’s manual Brush Doser Coffee press Single-coffee filter.holder Double-coffee filter.holder. C O F F E E M A C H IN M a d e in It a Blind.filter Double-coffee.filter Single-coffee.filter CARIpure100.filter. (optional) PRIOR CHECKING AFTER RECEIPT NOTE In case damages or Check the integrity of:...
POSITIONING WARNING Position the machine: consents ●. Indoor with temperature ranging the procedures de- from 5° and 30°C. scribed below must ●. At a minimum distance of 150 be performed by a mm from walls or other objects, to skilled technician. facilitate ventilation.
WATER MAINS CONNECTION WARNING connection power mains must be done by a skilled technician in com- pliance with applica- ble regulations. Use the. certified. Carimali. External softener power cord. Liquid filter.to.be. discharge installed by the Customer Equipotential bonding In case of installation of the machine...
WARNING NOTE If your version envis- data plate ages the connection shows the letter “J”, to the water mains, it the machine is ver- must be performed by sion JOLLY (water a skilled technician in mains + tank). If it is compliance with the missing, the machine applicable standards.
NOTE IDENTIFICATION Carry out this opera- tion only when install- ing the machine. CARIMALI S.p.A. - www.carimali.com Via Industriale, 1 - 24040 Chignolo d’Isola - ITALY MADE IN ITALY s/n XXXXXXXX In the next starts, the 05/2018 GENIUS 1EL...
Skilled operator in charge severe injury or death. of installation, adjustment, advanced use, and routine ATTENTION maintenance. CARIMALI TECHNICIAN It indicates a poten- Skilled operator authorized tially dangerous situ- by the Manufacturer, in ation for the operator charge of complex opera- that may cause se- tions.
INTENDED USE REASONABLY FORESEEABLE This machine was designed and MISUSE manufactured for dispensing: ● Coffee WARNING ● Hot water ● Steam In order to ensure safety of the operator The machine is intended for profes- and the machine, it is sional use, such as: strictly forbidden to ●...
2 DESCRIPTION OF THE MACHINE GENERAL DESCRIPTION OF THE MACHINE NOTE The following image is only an example and may differ in col- our from the machine purchased. Programming display Steam tap Dosed hot water button 5-LED touchpad Steam wand water spout Coffee group Drip...
This operation starts automatically display loads the software and shows when switching the machine on and the version. stops when the boiler is filled up to the max. level. CARIMALI Genius E1 1.04d Filling Boiler NOTE During this phase the buttons flash slowly.
COUNTER MENUS The heating phase is shown on the display and the buttons flash from To access the menu, keep the button right to left. pressed for 5 seconds CARIMALI GENIUS Heating Doses Counter TXX: XXXXX Steam heating... ENJOY NOTE...
2.4.2 Washing cycles DOSE SETTINGS Cleaning Cycle To access dose programming, keep pressed the button for 10 It shows the number of washing pro- seconds. cesses carried out. 2.4.3 Dose counter reset Reset dose count It allows to reset the counters of the dispensed doses.
3 TECHNICAL CHARACTERISTICS TECHNICAL DATA UNIT OF DESCRIPTION DATA MEASURE Power supply 220-240 Electric power 3250 Frequency 50-60 Power consumption 14,3 Coffee boiler capacity Coffee boiler power Steam boiler capacity Steam boiler power Pressure (water mains version) 8 - 9 Water tank capacity Drip tray capacity Type of pump...
Filling Boiler BOILER HEATING Then, the filling phase of the boilers is shown. 1. Dispense 1.5 l water from each in- take point. CARIMALI GENIUS Heating 2. Dispense steam for 1 minute. Steam heating ENJOY...
Programmed doses dispensing up before proceeding with drink dis- pensing. Once the machine reaches the work- ing temperature, it is possible to pro- ceed with drink dispensing. CARIMALI GENIUS ENJOY NOTE continuous 4.5.1 Coffee dispensing dispensing, press the Add the amount and the dose of...
4.5.2 Hot water dispensing 4.5.3 Steam dispensing Position a container underneath the hot water spout. NOTE Before using steam wand, the con- densation must drained out for at least 2 seconds. Position a container underneath the steam wand. Press the hot water dispensing but- ton.
At the end, rotate the tap clockwise to SWITCHING OFF stop dispensing of steam. Press the switching on button situat- ed on the rear side of the machine in position “0” to switch the machine off. Remove the steam wand from the container.
5 ROUTINE WARNING MAINTENANCE Do not pull the pow- er cord or the ma- DANGER chine itself to unplug The intervention of the machine from the routine maintenance electric power socket. and cleaning must be performed by the op- erator only after: WARNING ● having switched Each operation re-...
Page 28
TYPE OF OPERATION FREQUENCY PARAGRAPH OPERATION Display cleaning Manual Daily 5.1.1 External cleaning of chrome-plated sur- Manual Daily 5.1.2 faces External cleaning of Manual Daily 5.1.3 machine surfaces Emptying and clean- Daily or ing the liquid grounds Manual before, container if necessary Coffee dispensing Manual...
EXTERNAL CLEANING WARNING 5.1.1 Cleaning the display cleaning chrome-plated sur- faces, use a damp cloth, an antistatic cloth or similar. Do abrasive agents to carry out this operation. 5.1.3 Cleaning of machine surfaces Proceed with the daily external clean- ing of the machine using a cloth dampened with water and then dry WARNING thoroughly.
CLEANING OF LIQUID Insert the blind filter into the filter GROUNDS CONTAINER holder and a detergent pad. NOTE NOTES If necessary, use a For washing oper- brush to remove any ations, use the Ca- residues. rimali detergent pads NOTE (06.00133). Wash with care to prevent the prolifera- tion of bacteria.
Page 31
Insert the filter holder into the coffee Press to turn the machine off after the group. coffee group washing cycle. Remove the filter holder, wash it un- der running water and remove any coffee residues with a soft cloth. To access the washing mode, hold the dispensing buttons of single short coffee and double long coffee at the same time.
STEAM WAND WASHING NOTE If washing is not per- NOTE fect, repeat this oper- Carry out washing af- ation several times. ter each dispensing or every day at the HOT WATER end of the work shift. SPOUT WASHING Immerse the steam wand in hot water Dispense a small dose of water and and open the tap for a short period.
OTHER OPERATIONS OF MANUAL WASHING To remove other coffee residues, use the brush supplied to wipe the cof- fee group shower head and the filter holder.
6 TROUBLESHOOTING FAULT POSSIBLE CAUSE POSSIBLE SOLUTION USER Wrong connection Check and repair to the power mains. wiring. The machine does not turn on (display off). General electric Contact the Service failure. centre. Perform a washing Obstructed cycle of the coffee dispensing group.
ATTENTION For any other type of message or in case of alarms that dis- able the machine functions, please contact the Carimali Ser- vice Centre. 7 DISPOSAL This machine is compliant with the Directive 2012/19/EU.
Need help?
Do you have a question about the GENIUS and is the answer not in the manual?
Questions and answers