Summary of Contents for Schwank SchwankAir 4000 Series
Page 1
SchwankAir Installation Manual SchwankAir 4000 Series The air curtains shown herein are licensed to bear the AMCA Seal. The ratings shown are based on tests and procedures performed in accordance with AMCA Publication 211 and AMCA Publication 311 and comply with the requirements of the AMCA Certified Ratings Program.
Page 4
The introduction pages consist mainly of pictures. For translation of the English texts used, see the respective language pages. Les pages de présentation contiennent principalement des images. Pour la traduction des textes en anglais, consultez la page correspondante à la langue souhaitée.
Page 5
Dimensions Valve [3/4"], outside thread A / B / C / D 72" & 96" Models Mounting bracket E / F 3.3 ft: 4 x M8 Controller 4.9 ft: 4 x M8 6.6 ft: 6 x M8 8.2 ft: 6-8 x M8 [inch] Model [inch]...
Page 6
Fig. 1A: Open the unit by raising the front panel. The front is Fig. 1B: When the front has been removed it it important to blocked in open position with the front hatch hook. be sure it is firmly seated in the front locks again. Controller Fig.
All Models: 36” & 60” D / E [inch] Model [inch] Model 5.08 All Models All Models 4.08 All Models All Models All Models All Models AC-VA36-23 29.8 AC-VA96-23 AC-VE36-20[48][60] 29.8 AC-VE96-48[60] AC-VW36-23 29.8 AC-VW96-23 50.4 AC-VA60-23 30.8 AC-VA96-23 50.4 AC-VE60-20[48][60] 30.8 AC-VE96-48[60]...
Page 10
Accessories Nozzle Extensions Models Model All 36” Models JC-0725-10 All 60” Models JC-0725-15 All 72” Models JC-0725-20 All 96” Models JC-0725-25 Fig. 10 JC-0712-XX Single Piece Design Kit Ceiling Design Kit Ceiling Length Kit Height Model [inch] [ft] 8.00-12.00 0.6-1.0 JC-0712-10 12.00-20.00 1.0-1.6...
Page 11
Accessories NOTE: The air curtain must be secured in the wall or ceiling. JC-0724-XX Vertical (Floor) Mounting Kit • Used to adapt a horizontal unit for vertical installation. • Includes floor frame and mounting parts to support the top. • Vertical kit allows two units to be installed on top of each other.
Page 12
Accessories JC-0745-XX JC-0749-XX - 4000 Series Return Water Temp. Sensor Controller - Ambient Models JC-0750-XX - 4000 Series Controller - Heated Models JC-0732 JC-0742-XX RJ12 Cable next to JC-0732-XX Temperature Sensor [Different Lengths Available] JC-0751-XX - 3/4 Plumbing Kit Includes: •...
Page 13
Wiring Diagram - SchwankAir 4000 Series Ambient & Water Heated All Ambient & Water Heated AC-VA36/VW36 Models [except 36"] Air Curtain PCB Trafo PE L1 L2 208V1~ schwankgroup.com/schwankair...
Page 14
Wiring Diagram - SchwankAir 4000 Series - 36” & 60” Electric Heated 208V Actuator 230VSupply 230V Room schwankgroup.com/schwankair...
Page 15
Wiring Diagram - SchwankAir 4000 Series - 72” & 96” Electric Heated 208V Supply 2 30V Room schwankgroup.com/schwankair...
Page 16
Wiring Diagram - SchwankAir 4000 Series - 36” & 60” Electric Heated 600V A ctuato r 230V S upply 230V R oom schwankgroup.com/schwankair...
Page 17
Wiring Diagram - SchwankAir 4000 Series - 72” & 96” Electric Heated 480V/600V Actuator 230VSupply 230V Room schwankgroup.com/schwankair...
Page 18
Replacement parts list SchwankAir 4000 Series - Ambient Item Description Part # Model # 4000 Air Curtain Screws [Surface] JC-0601-XX AC-VA36-23 AC-VA60-23 AC-VA72-23 AC-VA96-23 4000 Air Curtain Front Cover 36” [Surface] JC-0602-10 AC-VA36-23 4000 Air Curtain Front Cover 60” [Surface]...
Page 19
4000 Air Curtain EC Motor JC-0605-XX AC-VA36-23 AC-VA60-23 AC-VA72-23 AC-VA72-23 4000 Air Curtain Discharge Nozzle 36” JC-0606-10 AC-VA36-23 4000 Air Curtain Discharge Nozzle 72” JC-0606-15 AC-VA60-23 4000 Air Curtain Discharge Nozzle 60” JC-0606-20 AC-VA72-23 4001 Air Curtain Discharge Nozzle 96” JC-0606-25 AC-VA96-23 4000 Air Curtain Nozzle Holder...
Page 20
Replacement parts list SchwankAir 4000 Series - Electric Item Description Part # Model # 4000 Air Curtain Screws [Surface] JC-0601-XX AC-VE36-20 AC-VE36-48 AC-VE36-60 AC-VE60-20 AC-VE60-48 AC-VE60-60 AC-VE72-20 AC-VE72-48 AC-VE72-60 AC-VE96-48 AC-VE96-60 schwankgroup.com/schwankair...
Page 21
4000 Air Curtain Front Cover 36” [Surface] JC-0602-10 AC-VE36-20 4000 Air Curtain Front Cover 36” [Surface] JC-0602-10 AC-VE36-48 4000 Air Curtain Front Cover 36” [Surface] JC-0602-10 AC-VE36-60 4000 Air Curtain Front Cover 60” [Surface] JC-0602-15 AC-VE60-20 4000 Air Curtain Front Cover 60” [Surface] JC-0602-15 AC-VE60-48 4000 Air Curtain Front Cover 60”...
Page 25
Replacement parts list SchwankAir 4000 Series - Hot Water Item Description Part # Model # 4000 Air Curtain Screws [Surface] JC-0601-XX AC-VW36-23 AC-VW60-23 AC-VW72-23 AC-VW96-23 4000 Air Curtain Front Cover 36” [Surface] JC-0602-10 AC-VW36-23 4000 Air Curtain Front Cover 60” [Surface]...
Page 26
4000 Air Curtain Bottom Cover 72” [Surface] JC-0603-20 AC-VW72-23 4001 Air Curtain Bottom Cover 96” [Surface] JC-0603-25 AC-VW96-23 4000 Air Curtain Filter Holder JC-0632-XX AC-VW36-23 AC-VW60-23 AC-VW72-23 AC-VW96-23 4000 Air Curtain HW Coil Filter 36” JC-0633-10 AC-VW36-23 4000 Air Curtain HW Coil Filter 60” JC-0633-15 AC-VW60-23 4000 Air Curtain HW Coil Filter 72”...
Page 27
AC-VW96-23 4000 Air Curtain Inlet Grill 36” [Surface] JC-0611-10 AC-VW36-23 4000 Air Curtain Inlet Grill 60” [Surface] JC-0611-15 AC-VW60-23 4000 Air Curtain Inlet Grill 72” [Surface] JC-0611-20 AC-VW72-23 4000 Air Curtain Inlet Grill 96” [Surface] JC-0611-25 AC-VW96-23 schwankgroup.com/schwankair...
Page 28
• Read the safety instructions before performing installation and/or maintenance activities on the unit. • Installation and/or maintenance activities on the unit may only be performed by qualified technical staff. • The unit shall not be installed and used outdoors or in environments that are aggressive, or potentially explosive.
Installation and operating instructions General Instructions Horizontal mounting Read these instructions carefully prior to The air curtain unit is installed horizontally with the installation and use. Keep this manual for future supply air grille facing downwards as close to the reference.
Note! If you want to divide the Vertical mounting JC-0724-XX output between two connection Units from 4.9 feet and longer may be used points, the series cabling must first vertically. For vertical mounting, all units must be removed [72" & 96" Electric be supplemented with a vertical kit containing Heated, 2x480V3~/600V3~].
The connections to the heating coil must be Filter [VW] equipped with shut off valves [included in The water coil is protected against dirt and SchwankAir valve kits] to allow problem free blockage by an air filter which covers the coil removal.
Overheating Troubleshooting The air curtain unit with electrical heating is If the fans are not working or do not blow properly, equipped with an overheat protection. If it is check the following: deployed due to overheating, reset as follows: • That the intake grille/filter is not dirty.
Page 33
Packaging Safety Packaging materials are chosen with • For all installations of electrically heated consideration to the environment and are products a residual current circuit breaker 300 therefore recyclable. mA for fire protection should be used. • Keep the areas around the air intake and exhaust grilles free from possible obstructions! Handling of product at end of •...
Consignes de montage et mode d’emploi Généralités Montage horizontal Lisez attentivement les présentes consignes Le rideau d'air est monté horizontalement, avec avant d'installer et d'utiliser l'appareil. Conservez la grille de sortie vers le bas aussi près que possible ce manuel afin de pouvoir le consulter de la porte.
Appareil avec chauffage électrique Montage vertical JC-0724-XX Le raccordement électrique s'effectue sur la Les appareils mesurant 4.9 pieds et plus peuvent partie supérieure de l'appareil. Voir Fig.2. 208V3~/ être utilisés à la verticale. Pour pouvoir être 480V3~/ 600V3~ commande et puissance [*1 *2] montés verticalement, tous les appareils doivent doivent être connectées aux borniers dans la être équipés d'un kit de montage vertical...
La batterie à eau chaude ne doit pas être Réglage initial de la vitesse de branchée sur un circuit hydraulique à pression ventilation standard, ni sur un circuit ouvert. La vitesse de ventilation lorsque la porte s'ouvre Noter que l'appareil doit être précédé d'une est réglée à...
1. Déconnecter l'alimentation électrique. Remplacement d'un ventilateur 2. Desserrer les vis et soulever la face avant. La 1. Déterminer quel ventilateur ne fonctionne pas. face est bloquée en position ouverte à l'aide du 2. Débrancher ses câbles d'alimentation. crochet de la trappe avant. Voir Fig. 1A. 3.
Page 38
Pour les appareils à batterie à eau chaude, Sécurité contrôler également les points suivants : • Un disjoncteur à courant résiduel de 300 mA • Purge de la batterie à eau chaude. doit être utilisé contre les risques d'incendie • Débit d'eau suffisant. dans les installations de produits avec •...
Traduction des pages de présentation • Outside thread Filetage extérieur Quantité inclue • Quantity included Pièces • Accessoires • Accessories • See separate manual for xxx Voir le manuel de la référence XXX. • Wiring diagrams for XXX and XXX, see manual for Schémas de raccordement pour xxx et xxx, voir le the controller manuel de la référence.
Page 40
Tableaux de dimensionnement • Supply water temperature Température de l'eau d'alimentation • Room temperature Température ambiante • Outlet air temperature*1 Température de l'air de sortie • Water temperature Température de l'eau • Fan position Position ventilateur • Airflow Débit d'air •...
Page 41
LIMITED WARRANTY CERTIFICATE Warranty SchwankAir 4000 Series Air Curtains The Manufacturer warrants that this product is free from defects in material or workmanship under normal use and service subject to the terms of this document. Five Year Limited Warranty Subject to the conditions and limitations stated herein, during the term of this limited warranty, we will supply any component part [at our option a new or repaired component part] of the air curtain as defined below, which the Manufacturer’s exami-...
Need help?
Do you have a question about the SchwankAir 4000 Series and is the answer not in the manual?
Questions and answers