Radiant tube heater with pneumatic gas-/air ratio control (57 pages)
Summary of Contents for Schwank 4003 series
Page 1
INSTALLATION / OWNER’S MANUAL SERIES 4403 SERIES 4003 INFRA-RED PORTABLE INFRA-RED PORTABLE PATIO HEATER PATIO HEATER FOR YOUR SAFETY: FIELD CONVERTIBILITY: Do not store or use gasoline or other flammable vapours liquids in the vicinity of this or any other “The conversion shall be carried out in accordance with appliance.
1. GENERAL This appliance is an infrared transportable patio, deck and garden heater for operation with LPG (Liquefied Petroleum Gas). The burner is controlled and adjusted by the gas control knob, and the gas supply is controlled by the valve on the portable gas cylinder. These installation and operating instruc- tions are intended for the Series 4003 / 4403 Heaters.
GAS REQUIREMENTS AND LEAK TESTING: NEVER CONNECT AN UNREGULATED GAS SUPPLY TO THE HEATER. PRECAUTIONS: • Periodically check the whole system for leaks or if the smell of gas is detected. • Extinguish all open flames. Perform ALL leak testing outdoors. •...
4. MAIN COMPONENTS AND TOOLS REQUIRED FOR ASSEMBLY Tools Needed: Adjustable Wrench, Slip Joint Pliers, Phillips Screwdriver, Medium Blade (#2 or #3 blade) Spray Model 4003 / 4403 Bottle of Soapy Water or Paint Brush and soapy water (to check leaks) Parts Supplied: 4003 / 4403 •...
5. ASSEMBLY INSTRUCTIONS Place the 3 post mounting brackets on the Cylinder Base as shown. Use 3-M8 x 15 mm bolts to secure brackets to the base Place the post onto the top of the post brackets, aligning pre-drilled holes as shown. Use 6-M6 x 35 mm bolts, washers &...
Page 9
ASSEMBLY..CONTINUED Slide the cylinder cover onto the post Slide the hose through inside of post. Then fasten burner onto post with the 4 Phillips 10 mm mechanical screws provided. GP-M403-BX-04B 4003 / 4403 Manual RD: March 2006 R.L. 4B Page 8...
Page 10
5 piece Sectional Reflector one piece option (32”dia) Assemble the reflector pieces to the centre piece using the small washers and the acorn nuts 5 piece section 1pc or 5pcs reflector (32”dia) Place a steel washer over each bolt on the burner top.
5.1 CONNECTION AND TESTING: • Lift the cylinder cover up from the base of the heater. • Connect the regulator hose to the hose coming down through the post. • Install a full gas cylinder on to the base • Connect the gas regulator hose to the QCC 1 cylinder valve by turning the knob manually in a clockwise direction.
6. A SAFE LOCATION FOR THE HEATER When objects are left under a heater in operation, such objects will be subject to radiant heat Caution: and could be damaged. The main application of this heater is to provide radiant heat comfort in the outdoors, at poolside, spa areas, terraces, patios and work areas, etc.
7. OPERATION AND LIGHTING INSTRUCTIONS 1. Open cylinder valve. Turn control knob fully to the right. Then turn it back toward the left 1/4 turn. (one quarter turn) 3. Fully depress control knob to allow gas flow to the burner, keeping this knob depressed while repeatedly pressing the “Piezo”...
8. TROUBLE SHOOTING WARNING: IMPROPER ADJUSTMENTS, BAD MAINTENANCE OR SER- VICING PROCEDURES CAN CAUSE SEVERE PROPERTY DAMAGE, SERIOUS INJURY OR FATALITIES THIS SECTION IS FOR, CERTIFIED AND LICENSED GAS TECHNICIANS ONLY PROBLEM PROBABLE CAUSE SOLUTION Burner will not light Gas valve may be in OFF position Turn the gas valve ON Fuel cylinder empty Replace LPG gas cylinder .
8.1 STORAGE When heater is not in use for a prolonged period of time, remove gas cylinder. Verify that the gas valve is fully and tightly closed. Do not store the gas cylinder indoors. Store gas cylinder in a well ventilated area. For more compact storage and to avoid damage, the reflector may be removed 8.2 PREVENTATIVE CARE AND MAINTENANCE The burner area is likely to attract spiders, especially inside orifices.
GP-M403-BX-04B 4003 / 4403 Manual RD: March 2006 R.L. 4B...
Page 17
This warranty gives you specific legal rights. You may also have other rights which vary by each jurisdiction. 5285 BRADCO BLVD. MISSISSAUGA, ON, L4W 2A6 2 SCHWANK WAY, WAYNESBORO, GEORGIA. 30830-8336 GP-D403-BX-03B 4003 / 4403 WARRANTY...