Summary of Contents for Kärcher LANDA ECOS 7000 Series
Page 1
TRAILER - ECOS 7000 SERIES ® Hot Water - Gasoline Powered - Diesel/Oil Heated Service Manual Pressure Washer MODELS: ECOS-7000 1.103-825.0 ECOS-7000 1.103-838.0 ECOS-7000 1.103-839.0 For the Landa Dealer nearest you, consult our web page at www.landa.com U.S. DESIGN PATENT NO. 701,357 OR PAT. NO. D701,357 U.S.
Machine Data Label Introduction Thank you for purchasing this Pressure Washer. We reserve the right to make changes at any time without incurring any obligation. Owner/User Responsibility: The owner and/or user must have an understanding of the manufacturer’s operating instructions and warnings before using this pressure washer.
Safety Important Safety Information WARNING: Risk of fire — Do not WARNING add fuel when the product is WARNING: To reduce the risk of operating or still hot. WARNING injury, read operating instructions WARNING: Do not use gasoline carefully before using. crankcase draining or oil 1.
Page 5
Safety WARNING: Risk of injury. Hot WARNING: Risk of asphyxiation. WARNING WARNING surfaces can cause burns. Use Use this product only in a well only designated gripping areas of ventilated area. spray gun and wand. Do not place 16. Running this product indoors hands or feet on non-insulated can result in death due to areas of the pressure washer.
Important Trailer Safety Information Referencing the Utility Trailer in this • The maximum weight the trailer is designed to carry. Manual • Gross vehicle weight rating of the trailer. All references to the trailer or component parts to either • Gross axle weight rating of the trailer.
Page 9
Important Trailer Safety Information If you have been towing your trailer and think that a tire • Wheel lugs* is under inflated, fill it to the recommended cold inflation • Bearing lube and tightness pressure indicated on your trailer's tire label placard or •...
Important Trailer Safety Information Tow Vehicles Make sure that the trailer safety chains are properly connected to the towing vehicle and trailer according to WARNING: Serious injury or property damage can SAE J684. See Safety Chain information in your result if the total weight of your loaded trailer manual.
Important Trailer Safety Information Maintenance • Check to see that the coupler housing has not been damaged, keeping the ball hitch from Keep ball pocket and mechanism clean. The following fitting completely into the housing as designed. procedures should be performed at least annually: 3.
Important Trailer Safety Information Safety Chains spacing and making the chain shorter. Also by keeping your chains as short as possible you prevent them from Listed in the chart below are the different class sizes of dragging on the road and wearing the chain links. If for safety chains and the rated load each chain must be any reason you find it necessary to replace a safety capable of withstanding.
What to Check And How To Check IMPORTANT: The total weight of the load must Example: The total weight of the trailer with load is never exceed the weight of cargo listed on the tire 6500 pounds. The tongue weight should not be less label and/or the maximum load carrying capacity than 650 pounds (10%).
What to Check And How To Check Wheel Torque Requirements Use tire mounting procedures as outlined by the Rubber Manufacturer’s Association or the tire manufac- TORQUE SEQUENCE turers. WHEEL 1st Stage 2nd Stage 3rd Stage SIZE NOTE: Tire wear should be checked frequently because once a wear pattern becomes firmly 15"...
What to Check And How To Check WARNING: To prevent runaway tires make certain Breakaway Switch & that the tire is centered on the tire carrier when D.O.T. Wet Cell Battery mounted and torque all hardware to maintain your After hitching to the tow vehicle, pull the safety pin on spare tire carrier.
What to Check And How To Check Brakes Do not lift or place supports on any part of the suspen- sion system. Your trailer is equipped with one of several brake type options. Brake Cleaning & Inspection Complete service and repair information for each Your trailer brakes must be inspected and serviced at available type brake is found in the Axle Break Service yearly intervals or more often as use and performance...
What to Check And How To Check Trailer Storage Preparation After Prolonged Storage — Inspection Procedures Before removing trailer from jack stands: If your trailer is to be stored for an extended period of 1. Remove all wheels and hubs or brake drums. Note time or over the winter, it is important that the trailer be which spindle and brake that the drum was prepared properly.
Maintenance Trailer Preventive Maintenance This trailer was produced with the best available materials and quality craftsmanship. However, you as the owner, have certain responsibilities for the correct care of the equipment. Attention to regular preventative maintenance procedures will assist in preserving the performance of your equipment. MAINTENANCE SCHEDULE Tire Air Pressure Inflate to proper pressure indicated on sidewall...
Maintenance Trailer Winterization another 15 seconds. Turn the key to the OFF position. To protect your machine from severe damage • Remove the inlet feed line from the antifreeze caused by water freezing inside the components, it mixture and replace the plug. is important to winterize it whenever it is subjected •...
Maintenance Troubleshooting PROBLEM POSSIBLE CAUSE SOLUTION Flex coupling slipping on fuel Replace if needed. pump shaft or burner motor shaft Check for electrical current reaching burner assembly On-Off switch defective with burner switch on. Heavy sooting on coil and burner can cause interruption of air flow Clean as required.
Maintenance Pressure Washer Maintenance Chart This pressure washer was produced with the best available materials and quality craftsmanship. However, you as the owner have certain responsibilities for the correct care of the equipment. Attention to regular preventative main- tenance procedures will assist in preserving the performance of your equipment. Contact your Pressure Washers dealer for maintenance.
Hose Routing (Driver's Side) I N N 1 ” I D E ” H 3 / 8 ” P 3 / 4 DRIVER SIDE TANKS (FRONT VIEW) 1 ” I D E Landa ECOS Trailer 7000 Service Manual 9.801-315.0 - AC...
Water Tank - Left Side (Driver Side) Landa ECOS Trailer 7000 Service Manual 9.801-315.0 - AC...
Page 31
Water Tank - Left Side (Driver Side) PART NO. DESCRIPTION NOTES 8.750-983.0 TANK, 100 GALLON WATER 8.919-198.0 WLMT, TANK SUPPORT, DRVR SIDE 8.919-199.0 WLMT, TANK SUPPORT, PASS SIDE 8.919-186.0 WLMT, TANK BASE, FENDER WELL, DRVR SIDE 8.919-299.0 WLMT, REAR TANK SUPPORT, HOSE REEL 8.919-301.0 WLMT, SUPPORT, TANK END, FRONT 8.600-262.0...
Water Tank - Right Side (Passenger) Inside Tank Similar For Both Tanks Inside Tank Inside Tank Outside Tank Landa ECOS Trailer 7000 Service Manual 9.801-315.0 - AC...
Page 33
Water Tank - Right Side (Passenger) PART NO. DESCRIPTION NOTES 8.750-983.0 TANK, 100 GALLON WATER 8.919-198.0 WLMT, TANK SUPPORT, DRVR SIDE 8.919-199.0 WLMT, TANK SUPPORT, PASS SIDE 8.919-186.0 WLMT, TANK BASE, FENDER WELL 8.919-300.0 WLMT, SUPPORT, REAR TANK END, VAC SIDE 8.919-301.0 WLMT, SUPPORT, TANK END, FRONT 8.600-262.0...
Power Platform Landa ECOS Trailer 7000 Service Manual 9.801-315.0 - AC...
Page 35
Power Platform PART NO. DESCRIPTION NOTES 8.752-148.0 ENGINE, HONDA, GX660R NO THROTTLE 8.754-499.0 GENERATOR, AB40 8.919-259.0 ASSEMBLY, PUMP, ECOS 7000 8.919-294.0 ASSEMBLY, UNLOADER,ECOS 7000 8.919-182.0 WLMT, POWER PLATFORM FRAME 8.919-179.0 WLMT, 4KW GENERATOR, MOUNT 8.919-176.0 WLMT, 4KW GENERATOR,SIDE RAIL 8.917-389.0 RAIL, PUMP 9.802-392.0 PULLEY, 3TB34...
Page 36
Power Platform PART NO. DESCRIPTION NOTES 8.719-047.0 WASHER, NYLON, .390 ID X 1 X OD .25 THICK 8.932-965.0 LABEL, WARNING, EXPOSED PULLEYS 8.919-314.0 GUARD, BELT, GEN TOP, ECOS 8.919-303.0 WLMT, BELT GUARD GEN, ECOS 8.919-305.0 GUARD, BELT, CENTER, ECOS 8.919-302.0 WLMT, BELT GUARD PUMP, ECOS 9.802-754.0 SCREW, 1/4"...
Page 37
Power Platform PART NO. DESCRIPTION NOTES 8.917-015.0 LABEL, REGULATION 4442.6 9.802-959.0 KEY, 0.247 SQR X 2.125" 8.751-241.0 BOLT, SQR HEAD, 3/8-16 X 1" 8.716-011.0 13 ft. CONDUIT, FLEXO, 1/2 BLK NOT SHOWN 9.803-836.0 6 ft. WIRE, THWN, 6 GA. RED NOT SHOWN 9.803-837.0 6 ft.
Valves To Inner Tank From Unloader To Outer Tank Strainer Replacement Parts To Feed Pump From Inner Tank From Outer Tank Landa ECOS Trailer 7000 Service Manual 9.801-315.0 - AC...
Page 49
Valves PART NO. DESCRIPTION NOTES 8.919-152.0 PANEL, VALVE CONTROL 9.807-351.0 LABEL, CONTROL PANEL, LOWER 9.802-802.0 WASHER, 1/4" FLAT SAE ZINC 9.802-705.0 BOLT, 1/4"-20 X 1" CARRIAGE 9.802-773.0 NUT, 1/4"-20 ESNA 8.919-188.0 WLMT, COUPLER, VALVE SUPPORT 9.803-557.0 ELBOW, 3/4" SAE X 3/4" 90° BRASS 8.706-057.0 NIPPLE, 3/4"...
Left Tank Box Landa ECOS Trailer 7000 Service Manual 9.801-315.0 - AC...
Page 55
Left Tank Box PART NO. DESCRIPTION NOTES 8.919-144.0 WLMT, CONTROL BOX, FRONT 8.919-143.0 WLMT, CONTROL BOX, REAR 8.919-149.0 DOOR, CONTROL BOX, DRIVER SIDE 8.751-055.0 RIVET, ALUMINUM 3/16" DIA 062-.125 GRIP 8.900-520.0 LABEL, DO NOT STAND OR STEP 8.751-128.0 HANDLE, LOCKING, VECTOR T-HNDL 8.718-813.0 SCREW, 10/32 X 1/2 BH SOC, SS 8.718-860.0...
Assembly Landa ECOS Trailer 7000 Service Manual 9.801-315.0 - AC...
Page 63
Assembly PART NO. DESCRIPTION NOTES SEE RIGHT SIDE WATER TANK ASSEMBLY SEE LEFT SIDE WATER TANK ASSEMBLY SEE POWER PLATFORM ASSSEMBLY SEE VACUUM ASSEMBLY SEE CONTROL BOX EXPLODED VIEW SEE LEFT TANK BOX EXPLODED VIEW SEE CHASSIS ASSEMBLY SEE HEAT EXCHANGER ASSEMBLY 8.706-529.0 GROMMET, 1-3/4"...
Control Cabinet Landa ECOS Trailer 7000 Service Manual 9.801-315.0 - AC...
Page 67
Control Cabinet PART NO. DESCRIPTION NOTES SEE CONTROL BOX ASSEMBLY SEE PASSENGER SIDE WATER TANK ASSEMBLY SEE CHASSIS ASSEMBLY SEE CONTROL PANEL ASSEMBLY SEE VALVES EXPLODED VIEW SEE TRANSFORMER BOX ASSEMBLY 8.919-347.0 PLATE, ACCESS COVER CONTROL BOX 8.919-153.0 COVER, SHELF, CONTROL BOX 9.802-776.0 NUT, 5/16"...
Page 73
VRT3 Unloader Unloader Adjustment Procedures 1. Remove lock nut (Item 19). 2. Remove adjustment knob (Item 18). 3. Loosen the two (2) nuts (Item 15), move them upward on stem (Item 8) until you see 4 or more threads below the nut.
LT.2 Series Pump TORQUE SPECS ITEM # FT. LBS. PART NO. DESCRIPTION NOTES 8.752-825.0 CRANKCASE PLUNGER OIL SEAL SEE KITS TABLE O-RING Ø1.78 X 37.82 SEE KITS TABLE PRESSURE RING, 18MM SEE KITS TABLE U-SEAL, 18MM SEE KITS TABLE INTERMEDIATE RING, 18MM SEE KITS TABLE U-SEAL, 18MM SEE KITS TABLE...
Page 79
LT.2 Series Pump PART NO. DESCRIPTION NOTES VALVE SPRING SEE KITS TABLE VALVE CAGE SEE KITS TABLE 8.752-830.0 HEX SCREW 9.802-884.0 WASHER 9.803-182.0 CLOSED BEARING HOUSING 9.803-186.0 O-RING Ø2.62 X 71.12 9.803-160.0 ROLLER BEARING 8.753-818.0 CRANKSHAFT Ø25 (4540) 8.752-827.0 CRANKSHAFT Ø25 (6036) 9.803-167.0 CRANKSHAFT KEY 8.752-834.0...
Need help?
Do you have a question about the LANDA ECOS 7000 Series and is the answer not in the manual?
Questions and answers