Monessen Hearth ARTISAN Series Installation Manual page 6

D. Getting Started
9HULI\ WKDW DOO OLVWHG SDUWV KDYH EHHQ UHFHLYHG <RX VKRXOG
have the following:
‡ 8QYHQWHG JDV KHDWHU
• Two (2) anchoring screws
‡ ,QVWDOODWLRQ DQG 2ZQHU¶V LQVWUXFWLRQV
‡  QRQFRPEXVWLEOH ERDUG
‡ 'HÀHFWRU JODVV
‡ )LYH  EDJV FUXVKHG JODVV PHGLD  DSSOLDQFHV
‡ )RXU  EDJV FUXVKHG JODVV PHGLD  DQG 
appliances)
‡ 5& UHPRWH FRQWURO
&DUHIXOO\ LQVSHFW WKH FRQWHQWV IRU VKLSSLQJ GDPDJH ,I DQ\
parts are missing or damaged, immediately inform the
GHDOHU IURP ZKRP \RX SXUFKDVHG WKH DSSOLDQFH Do not
attempt to install any part of the appliance unless you
have all parts in good condition.
WARNING
Do not install the heater:
•
Where curtains, furniture, clothing, or
RWKHU ÀDPPDEOH REMHFWV DUH OHVV WKDQ
36" from the front of the heater.
•
,Q KLJK WUD F DUHDV
•
In windy or drafty areas.
WARNING
Gloves are recommended when handling
FHUDPLF ¿EHU ORJV WR SUHYHQW VNLQ LUULWDWLRQ
IURP ORRVH ¿EHUV /RJV DUH IUDJLOH²KDQGOH
with care.
E. Planning the Installation
When planning the installation of the appliance it is neces-
sary to determine where the appliance is to be installed
DQG ZKHWKHU RSWLRQDO DFFHVVRULHV DUH GHVLUHG *DV VXSSO\
SLSLQJ VKRXOG DOVR EH SODQQHG 7KH IROORZLQJ VWHSV UHSUH-
VHQW WKH QRUPDO VHTXHQFH RI LQVWDOODWLRQ (DFK LQVWDOODWLRQ
LV XQLTXH KRZHYHU DQG PLJKW UHTXLUH D GL HUHQW VHTXHQFH
 3RVLWLRQ DSSOLDQFH LQ GHVLUHG ORFDWLRQ 5HIHU WR WKH Appli-
ance Location (page 7, Figure 2.2) and Clearances and
Height Requirements (page 12, Figures 3.6 and 3.7)
sections and Appliance and Framing Dimensions (page
10 and 11, Figure 3.4 and 3.5) illustration found in this
PDQXDO
NOTE: Be sure all packing material has been removed
IURP XQGHU DQG EHKLQG WKH XQLW
 ,QVWDOO IROORZLQJ WKH LQVWUXFWLRQV IRXQG LQ WKLV PDQXDO
 )LHOG ZLUH PDLQ SRZHU VXSSO\ WR MXQFWLRQ ER[ 5HIHU WR WKH
Electrical Installation section (page 23). (Electrical con-
nections should only be performed by an experienced,
OLFHQVHG FHUWL¿HG VHUYLFH SHUVRQ 

Monessen • AVFL Series Installation Manual • 4099-901 Rev. E • 01/22
 3OXPE JDV OLQH *DV OLQH PD\ EH UXQ HLWKHU WKURXJK
ERWWRP RI XQLW RU OHIW VLGH 7KHUH LV QR ULJKW VLGH DFFHVV
5HIHU WR WKH Connect the Gas (page 20, Figure 5.3)
VHFWLRQ IRXQG LQ WKLV PDQXDO *DV FRQQHFWLRQV VKRXOG
RQO\ EH SHUIRUPHG E\ DQ H[SHULHQFHG OLFHQVHGFHUWL¿HG
VHUYLFH SHUVRQ 
 &RPSOHWH ¿QLVK ZDOO PDWHULDO DQGRU VXUURXQG
F. Adequate Combustion Ventilation Air
7KLV KHDWHU VKDOO QRW EH LQVWDOOHG LQ D FRQ¿QHG VSDFH RU
unusually tight construction unless provisions are provided
IRU DGHTXDWH FRPEXVWLRQ DQG YHQWLODWLRQ DLU
7KH 1DWLRQDO )XHO *DV &RGH $16, =1)3$ 
GH¿QHV D FRQ¿QHG VSDFH DV D VSDFH ZKRVH YROXPH LV OHVV
WKDQ  FXELF IHHW SHU  %78 SHU KRXU P
of the aggregate input rating of all appliances installed in
WKDW VSDFH DQG DQ XQFRQ¿QHG VSDFH DV D VSDFH ZKRVH
YROXPH LV QRW OHVV WKDQ  FXELF IHHW SHU  %78 SHU
KRXU  P 3 per kw) of the aggregate input rating of all
DSSOLDQFHV LQVWDOOHG LQ WKDW VSDFH 5RRPV FRPPXQLFDWLQJ
directly with the space in which the appliances are installed,
through openings not furnished with doors, are considered
D SDUW RI D FRQ¿QHG VSDFH
8QXVXDOO\ WLJKW FRQVWUXFWLRQ LV GH¿QHG DV FRQVWUXFWLRQ
where:
a :alls and ceilings exposed to the outside atmosphere
have a continuous water vapor retarder with a rating of
 SHUP  [  11 NJ SHU SDVHFP
gasketed or sealed, and
b :eather stripping has been added to windows and
doors, and
c &aulking or sealants are applied to areas such as joints
around window and door frames, between sole plates
DQG ÀRRUV EHWZHHQ ZDOOFHLOLQJ MRLQWV EHWZHHQ ZDOO
panels, at penetrations for plumbing, electrical and gas
OLQHV DQG RWKHU RSHQLQJV
The following formula can be used to determine the maxi-
PXP KHDWHU UDWLQJ SHU WKH GH¿QLWLRQ RI XQFRQ¿QHG VSDFH
%78+U / + L
1
Consider two connecting rooms with an open area
between, with the following dimensions:
1
L   )W /  )W :
1 2 2
%78+U 
If there were a door between the two rooms the calculation
ZRXOG EH EDVHG RQO\ RQ WKH URRP ZLWK WKH KHDWHU
%78+U 
3
per kw)
2 ) or less with openings
)W [ : )W [ + )W
2
50
 )W +  )W
1  + 12) x (12) x (8)
2
50
1
 ) x (12) x (8)
2
50