Table of Contents
Advertisement
Quick Links
INSTALLER: Leave this manual with party responsible for use and operation.
OWNER: Retain this manual for future reference.
Contact your dealer with questions regarding installation, operation or service.
NOTICE: DO NOT discard this manual!
Artisan
Series
Models:
This appliance may be installed in an after-
market, permanently located, manufactured
(mobile) home, where not prohibited by local
codes.
This appliance is only for use with the type of
gas indicated on the rating plate. This appli-
ance is not convertible for use with other
gases.
Owner's Manual
Care and Operation
Monessen • AVFL60 Owner's Manual • 4605-900 Rev. A • 5/17
WARNING:
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly
could result in serious injury, death, or
property damage.
• DO NOT store or use gasoline or other flam-
mable vapors and liquids in the vicinity of this
or any other appliance.
• What to do if you smell gas
- DO NOT try to light any appliance.
- DO NOT touch any electrical switch. DO
NOT use any phone in your building.
- Leave the building immediately.
- Immediately call your gas supplier from
a neighbor's phone. Follow the gas sup-
plier's instructions.
- If you cannot reach your gas supplier, call
the fire department.
• Installation and service must be performed
by a qualified installer, service agency, or the
gas supplier.
In the Commonwealth of Massachusetts installation must be
performed by a licensed plumber or gas fitter.
See appliance installation manual for additional
Commonwealth of Massachusetts requirements.
• DO NOT install this unit in a bedroom or
bathroom. Please refer to page 6 Section
F of the Installation Manual for proper unit
placement.
1
Advertisement
Table of Contents
Troubleshooting
Related Manuals for Monessen Hearth AVFL60NIP
Summary of Contents for Monessen Hearth AVFL60NIP
-
Page 1: Care And Operation
Owner’s Manual Care and Operation INSTALLER: Leave this manual with party responsible for use and operation. OWNER: Retain this manual for future reference. Contact your dealer with questions regarding installation, operation or service. NOTICE: DO NOT discard this manual! WARNING: FIRE OR EXPLOSION HAZARD Artisan Failure to follow safety warnings exactly... -
Page 2: Table Of Contents
Safety Alert Key: • DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury. • WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury. • CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury. •... -
Page 3: Welcome
Welcome Read this manual before operating this appliance. Please retain this Owner’s Manual for future reference. Read the Installation Manual before making any installation or finishing changes. A. Congratulations This owner’s manual should be retained for future reference. We suggest that you keep it with your other Congratulations and thank you for selecting a Monessen important documents and product manuals. -
Page 4: Limited Lifetime Warranty
B. Limited Lifetime Warranty Hearth & Home Technologies LIMITED LIFETIME WARRANTY Hearth & Home Technologies, on behalf of its hearth brands (“HHT”), extends the following warranty for HHT gas, wood, pellet, coal and electric hearth appliances that are purchased from an HHT authorized dealer. WARRANTY COVERAGE: HHT warrants to the original owner of the HHT appliance at the site of installation, and to any transferee taking ownership of the appliance at the site of installation within two years following the date of original purchase, that the HHT appliance... - Page 5 B. Limited Lifetime Warranty (continued) WARRANTY CONDITIONS: • This warranty only covers HHT appliances that are purchased through an HHT authorized dealer or distributor. A list of HHT authorized dealers is available on the HHT branded websites. • This warranty is only valid while the HHT appliance remains at the site of original installation. •...
-
Page 6: Product Specific Information
Product Specific Information A. Appliance Certification B. BTU Specifications Minimum Models Maximum Orifice MODEL: AVFL60NIP, AVFL60PIP Input Input BTU/h Size (DMS) (U.S. or Canada) BTU/h LABORATORY: CSA AVFL60NIP (0-4500 FT) 38,000 25,000 TYPE: Unvented Gas Heater STANDARD: ANSI Z21.11.2013 AVFL60PIP... -
Page 7: Important Safety And Operating Information
Important Safety and Operating Information A. Appliance Safety Clear Space WARNING! DO NOT place combustible objects in front WARNING! DO NOT operate fireplace before reading of the fireplace. High temperatures may start a fire. See and understanding operating instructions. Failure Figure 3.1. - Page 8 Important Safety and Operating Information (con’t) OWNER Please retain these instructions for future reference. WARNING • Any change to this heater or its controls can be dangerous. • Improper installation or use of the heater can cause serious injury or death from fire, burns, explosion or carbon monoxide poisoning.
-
Page 9: General Operating Parts
B. General Operating Parts harmful but may produce annoying smoke and smells as they are burned off during the initial operation of the Figure 3.2 references the general operating parts of the appliance; possibly causing headaches or eye or lung appliance and the section of this manual in which they are irritation. -
Page 10: Good Faith Wall Surface/Tv Guidelines
D. Good Faith Wall Surface TV Guidelines Good Faith Guidelines for TV Installations above a Typical Gas Fireplace TV recessed into the wall TV on the wall Noncombustible Mantel (required) Measured from top 6” Min. of rebox opening. 4” Min. 4”... -
Page 11: Before Lighting Appliance
E. Before Lighting Appliance Before operating this fireplace for the first time, have a qualified service technician: • Verify all shipping materials have been removed from inside and/or underneath the firebox. • Review proper placement of fireglass media. • Ensure that there are no gas leaks. •... -
Page 12: Lighting Instructions (Ipi)
F. Lighting Instructions (IPI) FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: If you do not follow these instructions exactly, a fi re or explosion may result causing property damage, personal injury or loss of life. • Immediately call your gas supplier from a neighbor’s phone. Follow the gas sup- A. -
Page 13: Initial Use
G. Initial Use Wireless Remote: • Remote receiver is integrated into the ignition module Initial Break-in Procedure • Use the remote to turn the appliance on. • The fireplace should run three to four hours continuously on high. • To preserve battery life, do not use the HI/LO flame or THERMOSTAT options. - Page 14 IntelliFire Plus Remote Control RC300 IntelliFire Plus™ Multifunction Remote Control Installation & Operating Instructions FCC Requirements Hearth & Home Technologies disclaims any responsibility WARNING! Risk of Fire! Changes or modifications to for, and the warranty will be voided by, the following actions: this unit not expressly approved by the party responsible •...
- Page 15 Installation of Remote Control Housing 5. Close the housing door. See Figure 4. CAUTION! Risk of Fire! DO NOT install damaged or modified components Warranty will be voided if damaged or modified components are installed. Kit components: One remote control, two #6 screws, two wall anchors, 3 AAA batteries and one AUX300 module.
- Page 16 Programming the RC300 to the Control Module CAUTION! Risk of burns! DO NOT program the remote control to the control module when fireplace is hot. • Verify the ON/OFF/REMOTE switch is in the REMOTE position. Green LED light will blink three times and wall switch will beep once 5 seconds later when ready.
- Page 17 Display Screen Idle When Remote is in ON Mode The remote control will go into an idle mode if no but- THERMOSTAT DESIRED tons are pressed within 5 seconds. Press any button to FIREPLACE STATUS TEMP SETTING resume full functionality. In idle mode, only active func- tions will show on the screen.
-
Page 18: Adjusting Flame Height
Adjusting Thermostat About ON Mode • Press the MENU button to activate the menu. • All functions can be accessed when the remote control is in the ON mode. • Using the UP and DOWN arrows highlight the THERMO icon and press SELECT. •... -
Page 19: Power Outage
Power Outage LED Control Operation • If fireplace battery backup system IS installed at time of • The AVFL60 series appliance comes standard with power outage, fireplace operation will not be interrupted. a two (2) button LED control panel located under the •... - Page 20 LED Control Rocker Switch • Multi-colored LED lights - These two (2) buttons turn On/Hi/Med/Lo/ LEDs ON (HI/MED/LO) and OFF function and cycle through the color selection. 1. Color Fade - This setting will cycle through the colors shown below at a slower rate. 2.
- Page 21 Frequently Asked Questions/Troubleshooting Symptom Possible Cause Corrective Action Batteries Verify batteries are functional and installed correctly. Remote control is in Child Disengage Child Lock mode. Remote control will not transmit Lock mode Buttons not being pressed Press button firmly for one to two seconds to ensure transmis- firmly sion to module.
-
Page 22: Maintenance And Service
Maintenance and Service Surrounds Any safety screen or guard removed for servicing must be replaced prior to operating the fireplace. Frequency: Annually When properly maintained, your fireplace will give you By: Homeowner many years of trouble-free service. Contact your dealer Tools needed: Protective gloves, stable work surface to answer questions regarding proper operation, trouble- •... -
Page 23: Maintenance Tasks: Qualified Service Technician
Bulb Installation C. Maintenance Tasks: Qualified Service Technician The following tasks must be performed by a qualified ser- Turn OFF the main power supply before perform- vice technician. ing any service work on the unit, including install- Pilot ing or replacing light bulbs. Frequency: Annually TOP LIGHT LOCATION By: Qualified Service Technician... - Page 24 Accessing the LEDs Burner Ignition and Operation 1. Turn off gas supply and disconnect main power to ap- Frequency: Annually pliance before performing any maintenance. By: Qualified Service Technician 2. Remove glass deflection shield and place on a clean Tools needed: Protective gloves, vacuum cleaner, whisk flat surface.
-
Page 25: Frequently Asked Questions And Troubleshooting
Frequently Asked Questions and Troubleshooting A. Frequently Asked Questions ISSUE SOLUTION When first operated, this fireplace may release an odor for the first several hours. This is caused by the burning off of any oils remaining from manufacturing or from finishing materials or adhesives used around the fireplace during installation. - Page 26 IntelliFire™ Plus ODS Ignition System (Continued) Verify that incoming gas line ball valve is “open”. Verify Gas supply. that inlet pressure reading is within acceptable limits. Verify gap of igniter to right side of pilot hood. The gap Ignitor gap is too large. should be approximately .17 in.
-
Page 27: Troubleshooting-Screen/Leds/Control Panel
C. Troubleshooting – Screen/LEDs/Control Panel SYMPTOM POSSIBLE CAUSE CORRECTIVE ACTION Check that GFCI breaker is operating as intended and is not tripped. Verify that AC power has been connected to No AC power to ap- the appliance. Ensure that both the 3V IPI control module pliance power supply as well as the LED power supply are securely plugged into the appliance junction box. -
Page 28: Reference Materials
Reference Materials A. Accessories Install approved accessories per instructions included with accessories. Contact your dealer for a list of ap- proved accessories. WARNING! Risk of Fire and Electric Shock! Use ONLY Hearth & Home Technologies-approved optional acces- sories with this appliance. Using non-listed accessories could result in a safety hazard and will void the warranty. -
Page 29: Service Parts
B. Service Parts AVFL60NIP, AVFL60PIP Service Parts Beginning Manufacturing Date: June 2017 Ending Manufacturing Date: Active 60” Artisan Vent Free Linear Fireplace Part number list on following page. 05/17 Monessen • AVFL60 Owner’s Manual • 4605-900 Rev. A • 5/17... -
Page 30: Service Parts
AVFL60NIP, AVFL60PIP Service Parts Beginning Manufacturing Date: June 2017 Ending Manufacturing Date: Active IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or distributor. Hearth and Stocked Home Technologies does not sell directly to consumers. Provide model number and serial number when requesting service parts from your dealer or distributor. - Page 31 AVFL60NIP, AVFL60PIP Service Parts Beginning Manufacturing Date: June 2017 Ending Manufacturing Date: Active IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or distributor. Hearth and Stocked Home Technologies does not sell directly to consumers. Provide model number and serial number when requesting service parts from your dealer or distributor.
- Page 32 AVFL60NIP, AVFL60PIP Service Parts Beginning Manufacturing Date: June 2017 Ending Manufacturing Date: Active IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or distributor. Hearth and Stocked Home Technologies does not sell directly to consumers. Provide model number and serial number when requesting service parts from your dealer or distributor.
-
Page 33: Contact Information
C. Contact Information Monessen, a brand of Hearth & Home Technologies 7571 215 Street West, Lakeville, MN 55044 www.monessenhearth.com Please contact your dealer with any questions or concerns. For the location of your nearest dealer, please visit www.monessenhearth.com - NOTES - ________________________________________________________________________________ ________________________________________________________________________________ ________________________________________________________________________________...